| Most common failures | No# failures |
|---|
| Windscreen wiper does not clear the windscreen effectively | 39 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds manufacturers specified limits (8.2.1.2 (a)) | 33 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 27 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds default limits (8.2.1.2 (b)) | 22 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 21 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 20 |
| Brake hose excessively deteriorated | 16 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 14 |
| Exhaust carbon monoxide content at idle exceeds manufacturers specified limits (8.2.1.2 (b)) | 12 |
| Exhaust carbon monoxide content at idle exceeds default limits (8.2.1.2 (b)) | 12 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 12 |
| Rear Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 11 |
| Headlamp aim out of alignment | 11 |
| Nearside Front Service brake excessively binding (1.2.1 (f)) | 9 |
| Horn not working (7.7 (a)) | 9 |
| Anti-lock braking system warning lamp indicates an ABS fault | 9 |
| Registration plate issues | 8 |
| Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 8 |
| Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 8 |
| Registration plate lamp issues | 8 |
| Nearside Front Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 7 |
| Windscreen washer not working | 7 |
| Nearside Side repeater not working (4.4.1 (a) (ii)) | 7 |
| Offside Side repeater not working (4.4.1 (a) (ii)) | 7 |
| Brakes imbalanced across an axle | 7 |
| Offside Front Service brake excessively binding (1.2.1 (f)) | 7 |
| Nearside Front Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 6 |
| Nearside Rear Direction indicator not working (4.4.1 (a) (ii)) | 6 |
| Nearside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 6 |
| Exhaust hydrocarbon content after 2nd fast idle exceeds manufacturers specified limits (8.2.1.2 (a)) | 6 |
| Horn sound not in accordance with requirements (7.7 (c)) | 5 |
| Offside Stop lamp(s) not working (4.3.1 (a) (ii)) | 5 |
| Brake lever has insufficient reserve travel (1.1.2 (a)) | 5 |
| Offside Rear fog lamp not working (4.5.1 (a) (ii)) | 5 |
| Offside Front Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 4 |
| Battery insecure and likely to fall from carrier (4.13 (a) (ii)) | 4 |
| Battery insecure and likely to cause a short circuit (4.13 (a) (ii)) | 4 |
| Exhaust emissions carbon monoxide content excessive (8.2.1.2 (b)) | 4 |
| Offside Parking brake inoperative on one side (1.4.1 (a)) | 4 |
| Offside Front Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 4 |
| Nearside Rear Service brake excessively binding (1.2.1 (f)) | 4 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner sill (5.3.6 (a) (i)) | 4 |
| Nearside Rear Shock absorbers has a serious fluid leak | 4 |
| Offside Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 4 |
| Anti-lock braking system warning lamp does not illuminate (1.6 (a)) | 4 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 4 |
| Nearside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 3 |
| Offside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 3 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 3 |
| Oil leaking excessively from engine (8.4.1 (a) (i)) | 3 |
| Nearside Front Direction indicator not working (4.4.1 (a) (ii)) | 3 |
| Nearside Rear Position lamp not working (4.2.1 (a) (ii)) | 3 |
| Emissions unable to be completed (8.2.1.2 (d)) | 3 |
| Prop shaft bearing excessively worn (6.1.7 (b) (i)) | 3 |
| Nearside Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 3 |
| Fuel cap/sealing device ineffective (6.1.3 (b) (i)) | 3 |
| Nearside Front Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 3 |
| Nearside Front Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 3 |
| Rear Exhaust system insecure (6.1.2 (a)) | 3 |
| Offside Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 3 |
| Emissions not tested (8.2.1.2 (d)) | 3 |
| Offside Rear Stop lamp(s) adversely affected by the operation of another lamp (4.3.3 (b)) | 3 |
| Nearside Front Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 3 |
| Nearside Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 3 |
| Nearside Parking brake inoperative on one side (1.4.1 (a)) | 3 |
| Offside Rear Position lamp not working (4.2.1 (a) (ii)) | 3 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 2 |
| Nearside Front Brake hose excessively damaged (1.1.12 (b) (ii)) | 2 |
| Nearside Front Side repeater not working (4.4.1 (a) (ii)) | 2 |
| Central Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 2 |
| Front Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 2 |
| Rear Exhaust silencer likely to become detached (8.1.1 (b) (ii)) | 2 |
| Offside Front Anti-roll bar linkage fractured (5.3.3 (b) (ii)) | 2 |
| Offside Rear Position lamp adversely affected by the operation of another lamp (4.2.3 (c)) | 2 |
| Nearside Front Shock absorbers has a serious fluid leak | 2 |
| Offside Rear Parking brake inoperative on one side (1.4.1 (a)) | 2 |
| Speedometer clearly inoperative (7.8 (b) (ii)) | 2 |
| Offside Rear Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 2 |
| Nearside Rear Position lamp adversely affected by the operation of another lamp (4.2.3 (c)) | 2 |
| Nearside Front Seat belt anchorage prescribed area strength or continuity significantly reduced (7.1.1 (a) (i)) | 2 |
| Nearside Rear Rear reflector defective or damaged by more than 50% of the reflecting surface (4.8.1 (a) (ii)) | 2 |
| Exhaust hydrocarbon content after 2nd fast idle exceeds default limits (8.2.1.2 (b)) | 2 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength outer sill (5.3.6 (a) (i)) | 2 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner sill (5.3.6 (a) (i)) | 2 |
| Rear Exhaust has a major leak of exhaust gases silencer (6.1.2 (a)) | 2 |
| Nearside Rear Inner Suspension component mounting prescribed area excessively corroded significantly reducing structural strength sill (5.3.6 (a) (i)) | 2 |
| Nearside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 2 |
| Offside Front Outer Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 2 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 2 |
| Nearside Front Headlamp not working on main beam (4.1.1 (a) (ii)) | 2 |
| Exhaust has a major leak of exhaust gases front and rear (6.1.2 (a)) | 2 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner cill (5.3.6 (a) (i)) | 2 |
| Offside Headlamp light intensity severely reduced (4.1.4 (a)) | 2 |
| Offside Headlamp not working on main beam (4.1.1 (a) (ii)) | 2 |
| All direction indicators not working (4.4.1 (a) (ii)) | 1 |
| Hazard warning lamps inoperative (4.4.1 (e)) | 1 |
| Hazard warning switch inoperative (4.4.2 (a) (ii)) | 1 |
| Nearside Rear Lower Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Offside Rear Lower Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Offside Rear Anti-roll bar insecurely attached bolt missimg (5.3.3 (a) (i)) | 1 |
| Rear Brake cable insecure | 1 |
| Offside Rear Exhaust has a major leak of exhaust gases middle box blowing and u pipe corroded and blowing (6.1.2 (a)) | 1 |
| Offside Front Brake hose excessively damaged (1.1.12 (b) (ii)) | 1 |
| Nearside Front Lower Macpherson strut ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Lower Macpherson strut ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Rear Service brake excessively binding Parking brake (1.2.1 (f)) | 1 |
| Exhaust has a major leak of exhaust gases Centre Silencer. (6.1.2 (a)) | 1 |
| Offside Rear Brake cable damaged handbrake cable corroded and frayed (1.1.15 (a)) | 1 |
| Nearside Front Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced (6.1.1 (c) (i)) | 1 |
| Offside Front Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced (6.1.1 (c) (i)) | 1 |
| Nearside Front Lower Suspension component mounting prescribed area excessively corroded significantly reducing structural strength main arm mounting area (5.3.6 (a) (i)) | 1 |
| Nearside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength anti-roll bar area (5.3.6 (a) (i)) | 1 |
| Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength anti-roll bar area (5.3.6 (a) (i)) | 1 |
| Offside Rear Shock absorbers has a serious fluid leak | 1 |
| Offside Rear Outer Seat belt anchorage prescribed area strength or continuity significantly reduced sill (7.1.1 (a) (i)) | 1 |
| Steering column attachment defective movement side to side (2.2.2 (d) (i)) | 1 |
| Offside Rear Road wheel spigot mounting worn to the extent that wheel is likely to become detached Spacer not fitted to hub correctly - movement suggests loose bolts (5.2.2 (c) (ii)) | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength Inner sill (5.3.6 (a) (i)) | 1 |
| Nearside Rear reflector defective or damaged by more than 50% of the reflecting surface (4.8.1 (a) (ii)) | 1 |
| Nearside Bonnet primary retaining device ineffective (3.1 (c)) | 1 |
| Nearside Front Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting chassis (6.2.2 (d) (i)) | 1 |
| Exhaust emissions exceed level of metered smoke for a non-turbo charged engine (8.2.2.2 (b)) | 1 |
| Windscreen wiper not working (3.4 (a)) | 1 |
| Exhaust emissions hydrocarbon content excessive (8.2.1.2 (b)) | 1 |
| Nearside Rear Position lamp showing white light to the rear light lense broken (4.2.3 (a) (ii)) | 1 |
| Fuel tank insecure tank securing strap broken (6.1.3 (a) (i)) | 1 |
| Exhaust system insecure rear mountings missing (6.1.2 (a)) | 1 |
| Brake fluid significantly below minimum mark (1.1.10 (d) (ii)) | 1 |
| Brake cable damaged broken across rear axle (1.1.15 (a)) | 1 |
| Offside Rear Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced (6.1.1 (c) (i)) | 1 |
| Brake cable guide defective and affecting operation Both on the rear axle (1.1.15 (d)) | 1 |
| Nearside Front Suspension rod pin or bush excessively worn Torque reaction front most bushes (5.3.4 (a) (i)) | 1 |
| Nearside Rear Other passenger door likely to open inadvertently or not remain closed (6.2.3 (b) (ii)) | 1 |
| Front Sub-frame corroded and seriously weakened (5.3.3 (b) (i)) | 1 |
| Rear Exhaust has a major leak of exhaust gases and centre (6.1.2 (a)) | 1 |
| Front passenger door does not latch securely closed (6.2.3 (a)) | 1 |
| Offside Rear fog lamp does not emit a steady red light (4.5.4 (a)) | 1 |
| Nearside Front Direction indicator incorrect colour broken lens (4.4.3 (a)) | 1 |
| Offside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Exhaust has a major leak of exhaust gases cat-middle blowing (6.1.2 (a)) | 1 |
| Nearside Front Suspension component ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Subframe mounting prescribed area excessively damaged significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Offside Front Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Rear Brake cable damaged (1.1.15 (a)) | 1 |
| Hazard warning switch inoperative Missing (4.4.2 (a) (ii)) | 1 |
| Nearside Front Lower Suspension arm ball joint excessively worn Bottom ball joint (5.3.4 (a) (i)) | 1 |
| Nearside Front Anti-roll bar linkage fractured (5.3.3 (b) (ii)) | 1 |
| Rear Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 1 |
| Parking brake lever has excessive movement indicating incorrect adjustment (1.1.6 (c)) | 1 |
| Rear Fuel pipe leaking excessively or a risk of fire (6.1.3 (b) (ii)) | 1 |
| Offside Front Coil spring fractured or broken (5.3.1 (b) (i)) | 1 |
| Nearside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Offside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Exhaust has a major leak of exhaust gases MIDDLE BOX (6.1.2 (a)) | 1 |
| Nearside Front Direction indicator incorrect colour (4.4.3 (a)) | 1 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits 2.046 (8.2.1.2 (c)) | 1 |
| Nearside Outer Seat belt anchorage prescribed area strength or continuity significantly reduced sill (7.1.1 (a) (i)) | 1 |
| Rear Exhaust has a major leak of exhaust gases REAR SILENCER HOLED (6.1.2 (a)) | 1 |
| Emissions unable to be completed MAJOR EXHAUST LEAK (8.2.1.2 (d)) | 1 |
| Front Exhaust has a major leak of exhaust gases manifold area (6.1.2 (a)) | 1 |
| Brake relay lever excessively worn for handbrake cable over rear axle (1.1.15 (b)) | 1 |
| Offside Rear Upper Fuel pipe leaking excessively or a risk of fire (6.1.3 (b) (ii)) | 1 |
| Nearside Front Upper Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced floor (6.1.1 (c) (i)) | 1 |
| Offside Front Inner Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced arch (6.1.1 (c) (i)) | 1 |
| Offside Front Inner Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced sill (6.1.1 (c) (i)) | 1 |
| Offside Rear Inner Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced sill (6.1.1 (c) (i)) | 1 |
| Parking brake lever has excessive movement indicating incorrect adjustment excessive travel (1.1.6 (c)) | 1 |
| Nearside Parking brake inoperative on one side little to no effort / inop (1.4.1 (a)) | 1 |
| Offside Parking brake inoperative on one side little to no effort / inop (1.4.1 (a)) | 1 |
| Nearside Front Lower Suspension arm ball joint excessively worn outer (5.3.4 (a) (i)) | 1 |
| Exhaust has a major leak of exhaust gases center (6.1.2 (a)) | 1 |
| Central Exhaust system insecure (6.1.2 (a)) | 1 |
| Central Prop shaft bearing excessively worn proper bearing (6.1.7 (b) (i)) | 1 |
| Emissions unable to be completed not tested due to excessive leak in exhaust system (8.2.1.2 (d)) | 1 |
| Offside Seat belt anchorage prescribed area strength or continuity significantly reduced inner and outer sill panel (7.1.1 (a) (i)) | 1 |
| Nearside Seat belt anchorage prescribed area strength or continuity significantly reduced inner and outer sill panel (7.1.1 (a) (i)) | 1 |
| Nearside Parking brake inoperative on one side n/s effort 19kg o/s effort 212kg (1.4.1 (a)) | 1 |
| Central Prop shaft bearing excessively worn (6.1.7 (b) (i)) | 1 |
| Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner wing near anti roll bar mounting (5.3.6 (a) (i)) | 1 |
| Nearside Front Suspension arm pin or bush excessively worn Central (5.3.4 (a) (i)) | 1 |
| Offside Rear Wheel bearing rough when rotated (5.1.3 (b) (i)) | 1 |
| Offside Front Obligatory mirror insecure (3.3 (b) (ii)) | 1 |
| Nearside Stop lamp(s) not working lens damaged (4.3.1 (a) (ii)) | 1 |
| Nearside Rear Position lamp not working lens damaged (4.2.1 (a) (ii)) | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength outer sill (5.3.6 (a) (i)) | 1 |
| Nearside Front Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced inner wing under washer tank (6.1.1 (c) (i)) | 1 |
| Offside Front Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced inner wing under battery (6.1.1 (c) (i)) | 1 |
| Offside Front Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced chassis leg/inner wing (6.1.1 (c) (i)) | 1 |
| Exhaust has a major leak of exhaust gases leaking at 2 x joints (6.1.2 (a)) | 1 |
| Rear Exhaust has a major leak of exhaust gases silencer corroded & holed (6.1.2 (a)) | 1 |
| Emissions unable to be completed due to several leaks in system (8.2.1.2 (d)) | 1 |
| Offside Front Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced chassis between battery - engine mount and abs unit (6.1.1 (c) (i)) | 1 |
| Offside Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Nearside Inner Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Power steering malfunctioning judders (2.1.5 (a)) | 1 |
| Nearside Front Anti-roll bar linkage pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Anti-roll bar linkage pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Rear Wheel bearing has excessive play (5.1.3 (a) (i)) | 1 |
| Offside Front Lower Suspension component mounting prescribed area is corroded to the extent that control of the vehicle is likely to be adversely affected (5.3.6 (a) (ii)) | 1 |
| Offside Front Suspension component ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Front Direction indicator incorrect colour lens damaged (4.4.3 (a)) | 1 |
| Offside Front Side repeater not working (4.4.1 (a) (ii)) | 1 |
| Offside Side repeater incorrect colour (4.4.3 (a)) | 1 |
| Offside Rear Stop lamp(s) all not working (4.3.1 (a) (iii)) | 1 |
| Offside Front Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Front Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting inner wheel; arch (6.2.2 (d) (i)) | 1 |
| Nearside Front Track rod end ball joint dust cover insecure so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Brake lever has insufficient reserve travel hand brake (1.1.2 (a)) | 1 |
| Offside Rear Inner Suspension component mounting prescribed area excessively corroded significantly reducing structural strength sill (5.3.6 (a) (i)) | 1 |
| Nearside Front Subframe mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Front Windscreen wiper blade missing both rubbers split (3.4 (b) (ii)) | 1 |
| Parking brake lever inoperative (1.1.6 (d)) | 1 |
| Exhaust system insecure BACK BOX (6.1.2 (a)) | 1 |
| Offside Front Shock absorbers has a serious fluid leak | 1 |
| Offside Front Sub-frame corroded and seriously weakened (5.3.3 (b) (i)) | 1 |
| Rear Exhaust system insecure mounting bracket broken (6.1.2 (a)) | 1 |
| Offside Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced (6.1.1 (c) (i)) | 1 |
| Front Anti-roll bar pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Brake hose excessively twisted (1.1.12 (b) (ii)) | 1 |
| Offside Rear Outer Seat belt buckle not functioning as intended (7.1.2 (d)) | 1 |
| Offside Front Suspension arm ball joint excessively worn [up/down play] (5.3.4 (a) (i)) | 1 |
| Exhaust has a major leak of exhaust gases back box (6.1.2 (a)) | 1 |
| Offside Front Seat belt anchorage prescribed area strength or continuity significantly reduced floor (7.1.1 (a) (i)) | 1 |
| Nearside Seat belt anchorage prescribed area strength or continuity significantly reduced outer sill (7.1.1 (a) (i)) | 1 |
| Nearside Rear Hydraulic brake calliper leaking (1.1.16 (b) (i)) | 1 |
| Nearside Front Body component damaged and likely to cause injury light unit (6.2.1 (a) (i)) | 1 |
| Windscreen damaged and affecting the drivers view of the road (3.2 (a) (ii)) | 1 |
| Power steering pipe/hose leaking at steering rack joint (2.1.5 (a)) | 1 |
| Power steering pipe/hose leaking steeing rack / banjo connection leaking (2.1.5 (a)) | 1 |
| Power steering malfunctioning pump very noisey (2.1.5 (a)) | 1 |
| Nearside Front Inner Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced Hole and corrosion on chassis rail by front jacking point. (6.1.1 (c) (i)) | 1 |
| Nearside Front Inner Suspension component mounting prescribed area excessively corroded significantly reducing structural strength marked in white (5.3.6 (a) (i)) | 1 |
| Offside Front Body panel corroded and likely to cause injury Wing holed (6.2.1 (a) (i)) | 1 |
| Offside Rear Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting Jacking point (6.2.2 (d) (i)) | 1 |
| Offside Front Integral body structure inadequately repaired such that structural rigidity is significantly reduced Inner wheel arch (6.1.1 (d) (i)) | 1 |
| Nearside Front Battery insecure and likely to fall from carrier Battery tray corroded and holed (4.13 (a) (ii)) | 1 |
| Rear Exhaust silencer insecure Exhaust mounts broken and backbox insecure (8.1.1 (b) (i)) | 1 |
| Offside Obligatory mirror missing (3.3 (a)) | 1 |
| Oil leaking excessively from engine bellhousing area (8.4.1 (a) (i)) | 1 |
| Offside Front Direction indicator not working (4.4.1 (a) (ii)) | 1 |
| Nearside Front Upper Anti-roll bar pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Upper Anti-roll bar pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner wheel arch (5.3.6 (a) (i)) | 1 |
| Nearside Front Seat belt anchorage prescribed area strength or continuity significantly reduced outer sill (7.1.1 (a) (i)) | 1 |
| Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner wheel arch (5.3.6 (a) (i)) | 1 |
| Nearside Rear Inner Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced rear cross member n/s and o/s corroded cracked (6.1.1 (c) (i)) | 1 |
| Offside Front Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced chassis to body (6.1.1 (c) (i)) | 1 |
| Offside Front Outer Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Exhaust system insecure rear mounts broken / perished also centre clamp broke (6.1.2 (a)) | 1 |
| Offside Front Inner Anti-roll bar pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Lower Suspension component ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Front Inner Anti-roll bar pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Front Lower Suspension component ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively damaged significantly reducing structural strength jacking point and just in front . (5.3.6 (a) (i)) | 1 |
| Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Front Lower Anti-roll bar linkage pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Emissions unable to be completed due to exhaust leaks (8.2.1.2 (d)) | 1 |
| Offside Rear Subframe mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Nearside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Nearside Front Windscreen wiper missing (3.4 (a)) | 1 |
| Power steering malfunctioning (2.1.5 (a)) | 1 |
| Exhaust emissions likely to be affected by an exhaust leak (8.2.2.1 (b)) | 1 |
| Emissions unable to be completed engine idling very erratically, co over 9% (8.2.1.2 (d)) | 1 |
| Offside Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Brake performance not tested (1.2.1 (g)) | 1 |
| Offside Front Anti-roll bar linkage pin or bush likely to become detached retaining bolt insecure (5.3.4 (a) (ii)) | 1 |
| Supplementary restraint system warning lamp indicates a fault (7.1.6 (a)) | 1 |
| Nearside Rear Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced INNER SILL (6.1.1 (c) (i)) | 1 |
| Offside Rear Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced INNER SILL (6.1.1 (c) (i)) | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength INNER WHEEL ARCH (5.3.6 (a) (i)) | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Offside Front Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Offside Front Headlamp has a product on the light source so that the light output is severely reduced (4.1.4 (b)) | 1 |
| Offside Front Service brake excessively fluctuating (1.2.1 (e)) | 1 |
| Central Exhaust has a major leak of exhaust gases silencer (6.1.2 (a)) | 1 |
| Emissions unable to be completed back back corroded blowing (8.2.1.2 (d)) | 1 |
| Emissions not tested exhaust blowing (8.2.1.2 (d)) | 1 |
| Offside Front Headlamp light source and lamp not compatible Lights dim (4.1.4 (c)) | 1 |
| Offside Front Direction indicator adversely affected by the operation of another lamp (4.4.3 (b)) | 1 |
| Nearside Rear Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting Sill at jacking point (6.2.2 (d) (i)) | 1 |
| Nearside Front Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting (6.2.2 (d) (i)) | 1 |
| Offside Front Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting (6.2.2 (d) (i)) | 1 |
| Exhaust system insecure Various exhaust rubbers broken . Centre joint loose (6.1.2 (a)) | 1 |
| Exhaust emits dense blue smoke at idle (8.2.1.2 (f)) | 1 |
| Nearside Rear Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 1 |
| Offside Rear Vehicle structure has excessive corrosion which adversely affects braking or steering (6.1.1 (c) (ii)) | 1 |
| Nearside Suspension component mounting prescribed area excessively damaged significantly reducing structural strength front chassis (5.3.6 (a) (i)) | 1 |
| Nearside Rear Shock absorbers has negligible damping effect (5.3.2 (d)) | 1 |
| Offside Rear Shock absorbers has negligible damping effect (5.3.2 (d)) | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner cill (5.3.6 (a) (i)) | 1 |
| Nearside Front Inner Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced wing with in 30 cm of mount (6.1.1 (c) (i)) | 1 |
| Offside Rear Exhaust system insecure rear silencer (6.1.2 (a)) | 1 |
| Exhaust has a major leak of exhaust gases leaking at several joints (6.1.2 (a)) | 1 |
| Emissions unable to be completed due to excessive smoke and exhaust leaks (8.2.1.2 (d)) | 1 |
| Front Outer Track rod end ball joint has excessive play both sides (2.1.3 (b) (i)) | 1 |
| Rear Exhaust has a major leak of exhaust gases before axle (6.1.2 (a)) | 1 |
| Front Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Offside Outer Seat belt anchorage prescribed area strength or continuity significantly reduced outer sill (7.1.1 (a) (i)) | 1 |
| Offside Front Suspension arm pin or bush excessively worn stabilizer arm (5.3.4 (a) (i)) | 1 |
| Nearside Front Brake hose excessively twisted (1.1.12 (b) (ii)) | 1 |
| Offside Rear Position lamp light intensity significantly reduced Light Unit Taped Over (4.2.3 (a) (ii)) | 1 |
| Exhaust emissions likely to be affected by an exhaust leak (8.2.1.1 (b)) | 1 |
| Rear Exhaust silencer insecure (8.1.1 (b) (i)) | 1 |
| Nearside Rear Position lamp adversely affected by the operation of another lamp Earth fault (4.2.3 (c)) | 1 |
| Offside Rear Position lamp adversely affected by the operation of another lamp Earth fault (4.2.3 (c)) | 1 |
| Rear fog lamp tell-tale not working (4.9.1 (a) (ii)) | 1 |
| Nearside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner wing (5.3.6 (a) (i)) | 1 |
| Offside Front Steering rack casing fractured lower rack mount corroded (2.1.2 (d) (i)) | 1 |
| Offside Direction indicator adversely affected by the operation of another lamp front and rear (4.4.3 (b)) | 1 |
| Nearside Front Windscreen washer jets misaligned and not providing sufficient fluid to the windscreen (3.5 (a)) | 1 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 1 |
| Brake performance unable to be tested (1.2.1 (g)) | 1 |
| Power steering inoperative and steering adversely affected (2.1.5 (c) (ii)) | 1 |
| Exhaust silencer insecure (8.1.1 (b) (i)) | 1 |
| Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Emissions unable to be completed (8.2.2.2 (e)) | 1 |
| Nearside Rear Inner Vehicle structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting sill as marked with yellow chalk jacking point (6.2.2 (d) (i)) | 1 |
| Offside Rear Inner Vehicle structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting sill as marked with yellow chalk jacking point (6.2.2 (d) (i)) | 1 |
| Nearside Rear Outer Cab or chassis has excessive corrosion, seriously affecting its strength within 30cm of a cab mounting sill (6.2.2 (d) (i)) | 1 |
| Nearside Front Inner Cab or chassis has excessive corrosion, seriously affecting its strength within 30cm of a cab mounting chassis piece (6.2.2 (d) (i)) | 1 |
| Nearside Front Suspension arm pin or bush excessively worn brake reaction arm rear bush (5.3.4 (a) (i)) | 1 |
| Track rod end ball joint has excessive play o/s/f (2.1.3 (b) (i)) | 1 |
| Offside Stop lamp(s) all not working (4.3.1 (a) (iii)) | 1 |
| Rear Stop lamp(s) adversely affected by the operation of another lamp (4.3.3 (b)) | 1 |
| Nearside Front Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Exhaust has a major leak of exhaust gases Centre exhaust box (6.1.2 (a)) | 1 |
| Nearside Rear Seat belt buckle not functioning as intended (7.1.2 (d)) | 1 |
| Nearside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength chassis by anti roll bar (5.3.6 (a) (i)) | 1 |
| Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength chassis by anti roll bar (5.3.6 (a) (i)) | 1 |
| Fuel pipe leaking above exhaust rear box (6.1.3 (b) (i)) | 1 |
| Front passenger door cannot be opened from outside the vehicle (6.2.3 (a)) | 1 |
| Offside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Nearside Rear Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Nearside Rear Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced inner sill x2 (6.1.1 (c) (i)) | 1 |
| Rear Exhaust system insecure boc (6.1.2 (a)) | 1 |
| Nearside Front Inner Suspension component mounting prescribed area excessively corroded significantly reducing structural strength arch (5.3.6 (a) (i)) | 1 |
| Offside Front Inner Suspension component mounting prescribed area excessively corroded significantly reducing structural strength arch (5.3.6 (a) (i)) | 1 |
| Nearside Suspension component mounting prescribed area excessively corroded significantly reducing structural strength floor (5.3.6 (a) (i)) | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength sill (5.3.6 (a) (i)) | 1 |
| Emissions unable to be completed Exhaust Blowing (8.2.2.2 (e)) | 1 |
| Nearside Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Hydraulic fluid leaking excessively from rack (8.4.1 (a) (i)) | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner and outer sills (5.3.6 (a) (i)) | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength iner and outer sills (5.3.6 (a) (i)) | 1 |
| Central Seat belt anchorage prescribed area strength or continuity significantly reduced outer sill (7.1.1 (a) (i)) | 1 |
| Central Seat belt anchorage prescribed area strength or continuity significantly reduced outer sill nearside (7.1.1 (a) (i)) | 1 |
| Offside Brake cable damaged (1.1.15 (a)) | 1 |
| Rear Exhaust has a major leak of exhaust gases Very rear silencer and pipe over rear axle . (6.1.2 (a)) | 1 |
| Exhaust emits clearly visible black smoke during acceleration (8.2.1.2 (g)) | 1 |
| Nearside Rear Brake hose bulging under pressure (1.1.12 (d)) | 1 |
| Offside Rear Brake hose bulging under pressure (1.1.12 (d)) | 1 |