| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 42 |
| Windscreen wiper does not clear the windscreen effectively | 36 |
| Registration plate lamp issues | 23 |
| Registration plate issues | 7 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 6 |
| Nearside Stop lamp not working |1.2.1b| | 5 |
| Brake pipe excessively corroded | 5 |
| Nearside Rear Shock absorber has a serious fluid leak |2.7.3| | 4 |
| Offside Rear Shock absorber has a serious fluid leak |2.7.3| | 4 |
| Nearside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 4 |
| Offside Front Shock absorber has a serious fluid leak |2.7.3| | 4 |
| Offside Rear Shock absorbers has a serious fluid leak | 3 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 3 |
| Nearside Front Upper Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 3 |
| Offside Front Shock absorbers has a serious fluid leak | 3 |
| Offside Front Upper Suspension arm ball joint excessively worn |5.3.4 |a| |i|| | 3 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 3 |
| Nearside Front Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 3 |
| Offside Front Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 3 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 3 |
| Brakes imbalanced across an axle | 3 |
| Rear fog lamp missing (4.5.1 (a) (ii)) | 2 |
| Engine MIL inoperative or indicates a malfunction |8.2.1.2 |h|| | 2 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 2 |
| Rear fog lamp tell-tale not working |4.9.1 |a| |ii|| | 2 |
| Nearside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
| Offside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
| Nearside Parking brake inoperative on one side (1.4.1 (a)) | 2 |
| Offside Parking brake inoperative on one side (1.4.1 (a)) | 2 |
| Nearside Front Outer Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 2 |
| Offside Front Outer Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 2 |
| Nearside Front Shock absorbers has a serious fluid leak | 2 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 2 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 2 |
| Anti-lock braking system warning lamp indicates an ABS fault | 2 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 2 |
| Offside Rear fog lamp not working (4.5.1 (a) (ii)) | 2 |
| Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 2 |
| Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 2 |
| Nearside Front Upper Suspension arm ball joint excessively worn |5.3.4 |a| |i|| | 2 |
| Nearside Front Shock absorber has a serious fluid leak |2.7.3| | 2 |
| Offside Stop lamp not working |1.2.1b| | 2 |
| Stop lamp not working |1.2.1b| | 2 |
| Offside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
| Nearside Headlamp insecure |1.7.3| | 2 |
| Nearside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 2 |
| Offside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 2 |
| Windscreen has damage | 2 |
| Rear Anti-roll bar linkage pin or bush excessively worn Both (5.3.4 (a) (i)) | 1 |
| Rear fog lamp switch missing (4.5.3 (a)) | 1 |
| Nearside Front All position lamps not working |1.1.A.3b| | 1 |
| Centre Rear Stop lamp not working |1.2.1b| | 1 |
| Offside Rear Rear reflector excessively damaged so that its function is impaired |1.5.1c| | 1 |
| Offside Front Obligatory mirror seriously obscured affecting the rear view |8.1.2a| | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Nearside Front Seat belt buckle not functioning as intended |7.1.2 |d|| | 1 |
| Nearside Rear Position lamp not working |4.2.1 |a|| | 1 |
| Exhaust carbon monoxide content at idle exceeds manufacturers specified limits (8.2.1.2 (b)) | 1 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 1 |
| Offside Rear Shock absorbers insecurely attached (5.3.2 (a) (i)) | 1 |
| Offside Rear Shock absorbers damaged to the extent that it does not function (5.3.2 (b)) | 1 |
| Nearside Front Outer Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Centre Stop lamp not working |1.2.1b| | 1 |
| Offside Front Headlamp not working on main beam |4.1.1 |a| |ii|| | 1 |
| Nearside Front Headlamp light source and lamp not compatible |4.1.4 |c|| | 1 |
| Offside Front Headlamp light source and lamp not compatible |4.1.4 |c|| | 1 |
| Nearside Front Headlamp aim so that beam "kick up" is not visible on the screen |4.1.2 |a|| | 1 |
| Stop lamp(s) adversely affected by the operation of another lamp (4.3.3 (b)) | 1 |
| Nearside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Offside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Obligatory mirror does not provide a view to the rear |8.1.2b| | 1 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength outer sill (5.3.6 (a) (i)) | 1 |
| Nearside Front Inner Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Windscreen washer jets misaligned and not providing sufficient fluid to the windscreen |3.5 |a|| | 1 |
| Horn not working |7.7 |a| |ii|| | 1 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits |8.2.1.2 |c|| | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds default limits |8.2.1.2 |b|| | 1 |
| Exhaust has a major leak of exhaust gases |6.1.2 |a|| | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength |Sill| |5.3.6 |a| |i|| | 1 |
| Offside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 1 |
| Exhaust emissions hydrocarbon content after 2nd fast idle excessive |7.3.D.3| | 1 |
| Nearside Ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Headlamp not working on dipped beam aim not checked |1.7.5a| | 1 |
| Offside Rear Outline marker lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Suspension arm ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Battery insecure and likely to fall from carrier (4.13 (a) (ii)) | 1 |
| Nearside Outer Front Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Nearside Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 1 |
| Offside Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 1 |
| Offside Rear Inner Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 1 |
| Offside Inner Stop lamp not working |1.2.1b| | 1 |
| Offside Rear Inner Drive shaft which forms part of the suspension coupling gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.4.G.4e| | 1 |
| Rear fog lamp not working |1.3.2b| | 1 |
| Passengers seat insecure (6.2.6 (a) (ii)) | 1 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Front Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Front Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Nearside Front Position lamp missing bulb missing (4.2.1 (a) (ii)) | 1 |
| Offside Front Position lamp missing bulb missing (4.2.1 (a) (ii)) | 1 |
| Nearside Headlamp lens seriously defective No visible beam pattern (4.1.1 (b) (ii)) | 1 |
| Offside Headlamp lens seriously defective No visible beam pattern (4.1.1 (b) (ii)) | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds manufacturers specified limits (8.2.1.2 (a)) | 1 |
| Nearside Front Lower Shock absorbers has an excessively worn bush (5.3.2 (c)) | 1 |
| Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 1 |
| Nearside Front Power steering component|s| leaking rack |2.3.3b| | 1 |
| Nearside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Offside Front Side repeater not working (4.4.1 (a) (ii)) | 1 |
| Nearside Front Anti-roll bar linkage ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front Anti-roll bar linkage ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Side repeater not working |1.4.A.2c| | 1 |
| Spare wheel carrier insecure |6.4.2| | 1 |
| Nearside Inner Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 1 |
| Offside Front Inner Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 1 |
| Rear fog lamp missing |1.3.2a| | 1 |
| Nearside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Offside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Nearside Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
| Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt both sides, inscure |6.1.7 |g| |ii|| | 1 |
| Front Wheel bearing has excessive play both sides |5.1.3 |a| |i|| | 1 |
| Nearside Side repeater not working (4.4.1 (a) (ii)) | 1 |
| Battery insecure and likely to cause a short circuit (4.13 (a) (ii)) | 1 |
| Fuel cap/sealing device ineffective (6.1.3 (b) (i)) | 1 |
| Front Upper Suspension arm ball joint excessively worn ns and os (5.3.4 (a) (i)) | 1 |
| Shock absorbers has negligible damping effect all (5.3.2 (d)) | 1 |
| Nearside Rear Road wheel fixing missing (5.2.1 (a) (i)) | 1 |
| Nearside Rear Service brake excessively fluctuating (1.2.1 (e)) | 1 |
| Offside Rear Wheel stud|s| missing |4.2.A.1e| | 1 |
| Nearside Front Position lamp not working |4.2.1 |a|| | 1 |
| Brake hose excessively deteriorated | 1 |
| Nearside Front Headlamp has a product on the lens so that the light output is severely reduced |4.1.4 |b|| | 1 |
| Offside Front Headlamp has a product on the lens so that the light output is severely reduced |4.1.4 |b|| | 1 |
| Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Nearside Front Anti-roll bar ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Front Anti-roll bar ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
| Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Offside Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Offside Front Anti-roll bar linkage rubber bush bonding deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Front Upper Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Battery insecure |1.9.1| | 1 |
| Nearside Front Anti-roll bar linkage rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Anti-roll bar linkage rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Front Obligatory mirror missing |8.1.1| | 1 |
| Fuel cap/sealing device sealing washer missing |7.2.4c| | 1 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Front Driver`s seat with a defective structure |6.2.5 |a| |i|| | 1 |
| Offside Front Headlamp aim projected beam image is obviously incorrect |4.1.2 |c|| | 1 |
| Nearside Loading door likely to open inadvertently or not remain closed in the case of a sliding door |6.2.3 |b| |i|| | 1 |
| Front brake application uneven | 1 |
| Fuel tank leaking |7.2.3| | 1 |
| Horn not a continuous or uniform sound |1.6.2e| | 1 |
| Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Nearside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Rear Shock absorbers has a serious fluid leak | 1 |
| Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Rear Rear fog lamp lens defective such that emitted light is adversely affected damaged (4.5.1 (b) (ii)) | 1 |
| Nearside Rear Inner Drive shaft which forms part of the suspension coupling gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.4.G.4e| | 1 |
| Horn not working |1.6.2a| | 1 |
| Nearside Front Headlamp insecure |4.1.1 |c|| | 1 |
| Offside Front Headlamp insecure |4.1.1 |c|| | 1 |
| Offside Front Position lamp not working |4.2.1 |a| |ii|| | 1 |
| Headlamp levelling device inoperative |4.1.5 |a|| | 1 |
| Offside Rear Position lamp showing white light to the rear (4.2.3 (a) (ii)) | 1 |
| Rear fog lamp switch not operating in accordance with the requirements (4.5.3 (a)) | 1 |
| Offside Front Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced jacking point (6.1.1 (c) (i)) | 1 |
| Nearside Front Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Nearside Windscreen washer jets misaligned and not providing sufficient fluid to the windscreen (3.5 (a)) | 1 |
| Nearside Rear Brake load sensing valve linkage defective and function impaired |3.6.E.3| | 1 |
| Rear Rear fog lamp not working |1.3.2b| | 1 |
| Front Shock absorbers has a serious fluid leak |5.3.2 |b|| | 1 |
| Rear Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt |5.3.4 |b| |ii|| | 1 |
| Offside Rear fog lamp insecure |1.3.2a| | 1 |
| Offside Rear fog lamp obviously incorrectly positioned |1.3.2a| | 1 |
| Offside Rear fog lamp does not face the rear |1.3.2a| | 1 |
| Offside Stop lamp|s| light intensity significantly reduced bulb in wrong |4.3.3 |a| |ii|| | 1 |
| Offside Rear Outer Suspension component mounting prescribed area excessively corroded significantly reducing structural strength sill |5.3.6 |a| |i|| | 1 |
| Nearside Rear Seat belt missing |7.1.2 |a|| | 1 |
| Offside Rear Seat belt missing |7.1.2 |a|| | 1 |
| Nearside Rear Service brake lagging in operation (1.2.1 (d)) | 1 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded outersill |2.4.A.3| | 1 |
| Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength Outer sill (5.3.6 (a) (i)) | 1 |
| Rear fog lamp switch missing |1.3.1a| | 1 |