| Most common failures | No# failures |
|---|
| Windscreen wiper does not clear the windscreen effectively | 23 |
| Registration plate lamp issues | 19 |
| Headlamp aim out of alignment | 18 |
| Offside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 6 |
| Nearside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 6 |
| Offside Stop lamp not working |1.2.1b| | 6 |
| Parking brake: efficiency below requirements |3.7.B.7| | 6 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 6 |
| Registration plate issues | 6 |
| Nearside Stop lamp not working |1.2.1b| | 5 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 5 |
| Windscreen wiper blade insecure | 4 |
| Windscreen has damage | 4 |
| Offside Front Windscreen wiper blade deteriorated |8.2.2| | 4 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 4 |
| Brake pipe excessively corroded | 4 |
| Offside Rear fog lamp not working |1.3.2b| | 3 |
| Brake hose excessively deteriorated | 3 |
| Offside Front Seat belt damaged sufficient to obstruct correct operation of the belt |5.2.2a| | 3 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 3 |
| Parking brake lever has no reserve travel |3.1.6b| | 3 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
| Brakes imbalanced across an axle | 3 |
| Offside Front Body has a sharp edge caused by corrosion |6.1.C.1| | 3 |
| Fuel tank leaking |7.2.3| | 3 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 3 |
| Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 3 |
| Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 3 |
| Rear parking brake recording little or no effort | 3 |
| Emissions not tested |7.0| | 3 |
| Service brake: efficiency below requirements |3.7.B.7| | 2 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Front Exhaust system not adequately supported |7.1.1| | 2 |
| Nearside Front Windscreen wiper blade deteriorated |8.2.2| | 2 |
| Offside Inner Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 2 |
| Offside Windscreen wiper blade deteriorated |8.2.2| | 2 |
| Offside Rear Leaf spring fractured |2.4.B.1a| | 2 |
| Nearside Rear Stop lamp not working |1.2.1b| | 2 |
| Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 2 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 2 |
| Exhaust system not adequately supported |7.1.1| | 2 |
| Rear brake binding | 2 |
| Horn not working (7.7 (a) (ii)) | 2 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 2 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds manufacturers specified limits (8.2.1.2 (a)) | 2 |
| Rear Exhaust system not adequately supported |7.1.1| | 2 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 2 |
| Nearside Front Body has a sharp edge caused by corrosion |6.1.C.1| | 2 |
| Offside Rear fog lamp emits a light other than red |1.3.2e| | 2 |
| Nearside Rear Seat belt damaged sufficient to obstruct correct operation of the belt |5.2.2a| | 2 |
| Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 2 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 2 |
| Rear fog lamp tell tale not working |1.3.1b| | 2 |
| Nearside Rear Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Nearside Panhard rod has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Rear Panhard rod has excessive play in a ball joint |2.4.G.2| | 1 |
| Exhaust engine idle speed too high |7.3.D.1| | 1 |
| Steering system excessively rough |2.2.D.1| | 1 |
| Nearside Inner Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Rear Upper Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Rear Stop lamp not working |1.2.1b| | 1 |
| Nearside Front front brake binding |3.7.B.1| | 1 |
| Offside Obligatory mirror missing |8.1.1| | 1 |
| Nearside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Offside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Offside Rear position lamp|s| not in a clean condition and function impaired |1.1.4a| | 1 |
| Position lamp switch faulty |1.1.A.1| | 1 |
| Horn not working |1.6.2a| | 1 |
| Nearside Ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Ball joint has excessive play |2.2.B.1f| | 1 |
| Front brake disc in such a condition that it is seriously weakened | 1 |
| Offside Front Headlamp not working on main beam |1.7.5a| | 1 |
| Nearside Front Wheel insecure |4.2.A.1c| | 1 |
| Nearside Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Centre Exhaust mounting missing |7.1.1b| | 1 |
| Nearside Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Offside Front position lamp|s| insecure |1.1.A.3a| | 1 |
| Nearside Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Rear Leaf spring fractured |2.4.B.1a| | 1 |
| Offside Rear Stop lamp excessively damaged so that it is not visible from a reasonable distance |1.2.1d| | 1 |
| Offside Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Offside Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Offside Front Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Nearside Front Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Rear brake application uneven | 1 |
| Nearside rear brake grabbing severely |3.7.A.5b| | 1 |
| Offside rear brake grabbing severely |3.7.A.5b| | 1 |
| Nearside rear brake juddering severely |3.7.A.5b| | 1 |
| Nearside Front Headlamp aim beam image kick up to the offside |1.6.B1| | 1 |
| Offside Front Headlamp aim beam image kick up to the offside |1.6.B1| | 1 |
| Rear Exhaust mounting missing |7.1.1b| | 1 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Exhaust hydrocarbon content after 2nd fast idle exceeds manufacturers specified limits (8.2.1.2 (a)) | 1 |
| Exhaust emits clearly visible black smoke during acceleration (8.2.1.2 (g)) | 1 |
| Brake pedal anti-slip provision worn smooth (1.1.2 (c)) | 1 |
| Offside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Oil leaking excessively from engine (8.4.1 (a) (i)) | 1 |
| Nearside Rear Inner Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting sill (6.2.2 (d) (i)) | 1 |
| Nearside Front Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting outrigger (6.2.2 (d) (i)) | 1 |
| Offside Rear Inner Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting sill (6.2.2 (d) (i)) | 1 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded lower arm / chassis box |2.4.A.3| | 1 |
| Brake pedal anti-slip provision worn smooth |3.3.A.1b| | 1 |
| Brake lever has abnormal movement of levers indicating excessive wear |3.5.1f| | 1 |
| Stop lamp emits other than a steady red light |1.2.1e| | 1 |
| Stop lamp excessively deteriorated so that it is not visible from a reasonable distance |1.2.1d| | 1 |
| Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Centre Front Seat belt damaged sufficient to obstruct correct operation of the belt |5.2.2a| | 1 |
| Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Nearside Rear Direction indicator excessively deteriorated so that it is not visible from a reasonable distance |1.4.A.2e| | 1 |
| Offside Rear Rear position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Offside Front Headlamp insecure |1.7.3| | 1 |
| Nearside Rear Direction indicator incomplete |1.5.A1b| | 1 |
| Offside Rear position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Offside Stop lamp emits other than a steady red light |1.2.1e| | 1 |
| Offside Rear Rear passenger seat cannot be secured in the upright position. |6.2.3| | 1 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 1 |
| Offside Front Wheel bearing has excessive play (5.1.3 (a) (i)) | 1 |
| Nearside Front Track rod end ball joint dust cover insecure so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Nearside Rear Seat belt buckle not functioning as intended (7.1.2 (d)) | 1 |
| Offside Rear Anti-roll bar linkage pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Exhaust has a major leak of exhaust gases flexi pipe (6.1.2 (a)) | 1 |
| Offside Rear Anti-roll bar pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Rear Position lamp showing white light to the rear (4.2.3 (a) (ii)) | 1 |
| Nearside Rear Anti-roll bar pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Rear Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Outer Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Rear Rear position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| front brake binding |3.7.B.1| | 1 |
| Offside Front Brake hose twisted |3.6.B.4c| | 1 |
| Dipswitch operation does not extinguish all main beam headlamps leaving at least one pair of dipped beam headlamps |1.7.4b| | 1 |
| Offside Front Obligatory mirror missing |8.1.1| | 1 |
| Offside Rear Rear fog lamp missing |1.3.2a| | 1 |
| Nearside Front Body has a projection caused by corrosion |6.1.C.1| | 1 |
| Offside Rear passenger door does not latch securely closed |6.2.B.1a| | 1 |
| Nearside Rear Brake back plate|s| securing device excessively deteriorated |3.5.1j| | 1 |
| Offside Rear Brake back plate|s| securing device excessively deteriorated |3.5.1j| | 1 |
| Nearside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Front Body or chassis has an unsatisfactory modification, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Rear Exhaust has a part missing |7.1.1a| | 1 |
| Nearside Front Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
| Offside Front Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
| Nearside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Front Brake lining|s| less than 1.5 mm thick |3.5.1g| | 1 |
| Rear fog lamp not working |1.3.2b| | 1 |
| Offside Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Brake load sensing valve linkage seized |3.6.E.3| | 1 |
| Offside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Exhaust emissions - engine idle speed too high (8.2.1.2 (e)) | 1 |
| Offside Front Anti-roll bar linkage fractured (5.3.3 (b) (ii)) | 1 |
| Nearside Rear Stop lamp excessively damaged so that it is not visible from a reasonable distance |1.2.1d| | 1 |
| Nearside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Rear Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Offside Front Anti-roll bar linkage insecure |2.4.G.1| | 1 |