| Most common failures | No# failures |
|---|
| Windscreen wiper does not clear the windscreen effectively | 15 |
| Parking brake: efficiency below requirements |3.7.B.7| | 13 |
| Registration plate lamp issues | 13 |
| Brake hose excessively deteriorated | 11 |
| Brake pipe excessively corroded | 11 |
| Headlamp aim out of alignment | 10 |
| Rear parking brake recording little or no effort | 9 |
| Rear brake binding | 5 |
| Rear Mechanical brake component has restricted free movement | 4 |
| Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 4 |
| Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 3 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 3 |
| Rear Exhaust system not adequately supported |7.1.1| | 3 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 3 |
| Exhaust emits an excessive level of metered smoke for a non-turbo charged engine |7.4.B.3b| | 3 |
| Steering system has excessive free play detected at the steering wheel |steering box fitted| |2.2.A.1a| | 2 |
| Service brake: efficiency below requirements |3.7.B.7| | 2 |
| Offside Rear rear brake recording little or no effort |3.7.B.5a| | 2 |
| Nearside Front front brake binding |3.7.B.1| | 2 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Offside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Brake valve corroded and excessively weakened |3.6.A.2b| | 2 |
| Horn not working |1.6.2a| | 2 |
| Centre Statutory seat belt missing |5.1.1| | 2 |
| Nearside Rear Body has a sharp edge caused by damage |6.1.C.1| | 2 |
| Offside Front Windscreen wiper blade deteriorated |8.2.2| | 2 |
| Offside Rear fog lamp emits a light other than red |1.3.2e| | 2 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 2 |
| Front position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 2 |
| Power steering component|s| leaking |2.3.3b| | 2 |
| Nearside Front Lower Body has a sharp edge caused by corrosion |6.1.C.1| | 2 |
| Nearside Stop lamp not working |1.2.1b| | 2 |
| Offside Stop lamp not working |1.2.1b| | 2 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Nearside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Rear fog lamp tell tale not working |1.3.1b| | 2 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 2 |
| Hazard warning lamps not flashing in phase, with ignition on |1.4.B.1f| | 2 |
| Hazard warning lamps not flashing in phase, with ignition off |1.4.B.1f| | 2 |
| Hazard warning tell tale not working correctly |1.4.B.1e| | 2 |
| Parking brake is not capable of being maintained in operation by direct mechanical action only |3.1.2| | 2 |
| Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Offside Body has a projection caused by corrosion |6.1.C.1| | 1 |
| Offside Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Offside Rear Leaf spring fractured |2.4.B.1a| | 1 |
| Offside Obligatory mirror missing |8.1.1| | 1 |
| Offside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Rear Vehicle structure has an unsatisfactory modification, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Inner Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Inner Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Fuel pipe leaking |7.2.3| | 1 |
| Centre Front Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
| Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Offside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Rear fog lamp does not emit a steady red light |1.3.2e| | 1 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Nearside Rear Exhaust has a part missing |7.1.1a| | 1 |
| Nearside Outer Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Inner Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear Panhard rod locating pin insecure |2.4.G.3a| | 1 |
| Offside Front Seat belt affected by an insecure seat fixing |5.2.1b| | 1 |
| Nearside Front Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Nearside Front Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Offside Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Offside Outer Front Lower Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Outer Front Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Offside Rear fog lamp not working |1.3.2b| | 1 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 1 |
| Offside Rear Rear position lamp|s| excessively damaged so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Upper Steering column top bearing excessively worn |2.1.2c| | 1 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Front Body has a projection caused by damage |6.1.C.1| | 1 |
| Offside Front Body has a projection caused by damage |6.1.C.1| | 1 |
| Nearside Headlamp not working on main beam |1.7.5a| | 1 |
| Rear fog lamp not working |1.3.2b| | 1 |
| Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Front Body or chassis is damaged, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Centre Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Power steering pump drive system defective |2.3.6| | 1 |
| Nearside Front Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Rear Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Rear Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
| Front Ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Steering pivot point has excessive play |2.2.B.1g| | 1 |
| Front brake disc excessively pitted |3.5.1h| | 1 |
| Offside Headlamp not working on main beam |1.7.5a| | 1 |
| Exhaust emits an excessive level of metered smoke for a turbo charged engine |7.4.B.3b| | 1 |
| Nearside Rear brake drum contaminated by oil |3.5.1h| | 1 |
| Rear brake application uneven | 1 |
| Direction indicators not working |1.4.A.2c| | 1 |
| Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Front Headlamp not working on main beam |1.7.5a| | 1 |
| Rear Rear fog lamp not working |1.3.2b| | 1 |
| Centre Front An item not tested |Manual| | 1 |
| Front Steering column universal joint has excessive play |2.1.5| | 1 |
| Front Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Front Steering pivot point has excessive play |2.2.B.1g| | 1 |
| Offside Front Steering pivot point has excessive play |2.2.B.1g| | 1 |
| Brake pedal creeps down when held under pressure |3.3.B.1a| | 1 |
| Nearside Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Nearside Indicator tell tale inoperative |1.4.A.2a| | 1 |
| Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 1 |
| Brake pedal anti-slip provision worn smooth |3.3.A.1b| | 1 |
| Nearside Outer Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Outer Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Fuel cap/sealing device mounting flange/sealing method defective |7.2.4c| | 1 |
| Nearside Headlamp insecure |1.7.3| | 1 |
| Offside Headlamp insecure |1.7.3| | 1 |
| Nearside Rear Upper Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Offside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Brakes imbalanced across an axle | 1 |
| Nearside Rear brake drum in such a condition that it is seriously weakened |3.5.1i| | 1 |
| Offside Rear brake drum in such a condition that it is seriously weakened |3.5.1i| | 1 |
| Offside Rear wheel bearing rough when rotated |2.6.1| | 1 |
| Nearside Front Anti-roll bar rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Anti-roll bar rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |