| Most common failures | No# failures |
|---|
| Registration plate lamp issues | 22 |
| Windscreen wiper does not clear the windscreen effectively | 16 |
| Horn not working |1.6.2a| | 13 |
| Headlamp aim out of alignment | 9 |
| Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 9 |
| Exhaust emissions hydrocarbon content excessive |7.3.B.1b| | 8 |
| Rear brake application uneven | 8 |
| Offside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 7 |
| Brake pipe excessively corroded | 7 |
| Brakes imbalanced across an axle | 7 |
| Offside Rear fog lamp not working |1.3.2b| | 5 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 5 |
| Nearside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 5 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 4 |
| Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 4 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 4 |
| Offside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 4 |
| Offside front brake binding |3.7.B.1| | 4 |
| Offside rear brake grabbing severely |3.7.A.5b| | 4 |
| Offside Rear fog lamp missing |1.3.2a| | 3 |
| Rear fog lamp tell tale not working |1.3.1b| | 3 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
| Nearside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 3 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 3 |
| Rear fog lamp not working |1.3.2b| | 3 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 3 |
| Rear fog lamp insecure |1.3.2a| | 3 |
| Offside Front Seat belt locking mechanism does not secure or release |5.2.5a| | 3 |
| Centre Front passenger seat cannot be secured in the upright position. |6.2.4| | 3 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
| Nearside Front position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 2 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 2 |
| Nearside front brake binding |3.7.B.1| | 2 |
| Nearside Front front brake binding |3.7.B.1| | 2 |
| Windscreen has a sticker or other obstruction encroaching by more than 10mm within zone `A` |8.3.1b| | 2 |
| Exhaust engine idle speed too high |7.3.A.2a| | 2 |
| Nearside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Offside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Offside Headlamp not working on main beam |1.7.5a| | 2 |
| Nearside Steering pivot point has excessive play |2.2.B.1g| | 2 |
| Nearside Headlamp not working on main beam |1.7.5a| | 2 |
| Rear Exhaust system not adequately supported |7.1.1| | 2 |
| Nearside Rear Body has a sharp edge caused by corrosion |6.1.C.1| | 2 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 2 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 2 |
| Brake hydraulic reservoir fluid level below minimum level |3.6.G.1b| | 2 |
| Rear fog lamp obviously incorrectly positioned |1.3.2a| | 2 |
| Offside Front Shock absorber has a serious fluid leak |2.7.3| | 2 |
| Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Nearside rear brake grabbing severely |3.7.A.5b| | 2 |
| Registration plate issues | 2 |
| Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
| Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
| Parking brake lever has no reserve travel |3.1.6b| | 2 |
| Offside Inner Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 2 |
| Emissions not tested |8.2.1.2 |d|| | 2 |
| Offside Inner Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Offside Front position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Nearside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Offside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Exhaust tailpipe not capable of allowing the emission probe to be inserted |7.3.B.1| | 1 |
| Nearside Body insecure and dangerous to other road users |6.1.B.1b| | 1 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Brake hose damaged | 1 |
| Brake performance not tested |3.7.A.1| | 1 |
| Service brake: efficiency below requirements |3.7.B.7| | 1 |
| Offside Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Nearside Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Nearside Inner Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Offside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Steering box has a significant oil leak |2.2.D.2e| | 1 |
| Nearside Steering lock stop fractured and unserviceable |2.2.C.1d| | 1 |
| Nearside Front Body has a projection caused by corrosion |6.1.C.1| | 1 |
| Offside Rear Body has a projection caused by corrosion |6.1.C.1| | 1 |
| Nearside Rear Body has a projection caused by corrosion |6.1.C.1| | 1 |
| Nearside Rear Body has a projection caused by damage |6.1.C.1| | 1 |
| Nearside Body has a projection caused by corrosion |6.1.C.1| | 1 |
| Front Body has a projection caused by corrosion |6.1.C.1| | 1 |
| Offside Front Body has a projection caused by corrosion |6.1.C.1| | 1 |
| Windscreen wiper blade insecure | 1 |
| Nearside Front Steering lock stop deformed and unserviceable |2.2.C.1d| | 1 |
| Nearside Stop lamp not working |1.2.1b| | 1 |
| Nearside Windscreen wiper blade missing |8.2.2| | 1 |
| Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Nearside Front suspension has excessive play in a pin or bush of an upper wishbone inner bearing |2.5.B.1a| | 1 |
| Offside Front suspension has excessive play in a pin or bush of an upper wishbone inner bearing |2.5.B.1a| | 1 |
| Nearside Body has a sharp edge caused by corrosion side door |6.1.C.1| | 1 |
| Offside Rear Body has a sharp edge caused by corrosion wheel arch |6.1.C.1| | 1 |
| Rear Body has a sharp edge caused by corrosion number plate lamp area |6.1.C.1| | 1 |
| Nearside Rear Inner Vehicle structure has an unsatisfactory modification, seriously affecting its strength within 30cm of the body mountings wheel arch |6.1.B.2| | 1 |
| Offside Rear Inner Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings wheel arch |6.1.B.2| | 1 |
| Nearside Front Inner Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings lower pillor |6.1.B.2| | 1 |
| Offside Front Vehicle structure has an unsatisfactory modification, seriously affecting its strength within 30cm of the body mountings door pillor area |6.1.B.2| | 1 |
| Exhaust emissions - engine idle speed too high (8.2.1.2 (e)) | 1 |
| Exhaust emissions carbon monoxide content excessive co to high (8.2.1.2 (b)) | 1 |
| Windscreen wiper blade missing |8.2.2| | 1 |
| An item not tested |Manual| | 1 |
| Nearside Front Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced door pillar corroded excessive |6.1.1 |c| |i|| | 1 |
| Offside Front Outer Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting outer sill corroded |6.2.2 |d| |i|| | 1 |
| Nearside Rear Suspension component mounting prescribed area fractured significantly reducing structural strength valance is excessively corroded |5.3.6 |a| |i|| | 1 |
| Offside Front Seat belt anchorage prescribed area strength or continuity significantly reduced front seat mount in wheel arch corroded |7.1.1 |a| |i|| | 1 |
| Exhaust emissions carbon monoxide content excessive |8.2.1.2 |b|| | 1 |
| Offside Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
| Nearside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings rear valance |6.1.B.2| | 1 |
| Nearside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings outer sill |6.1.B.2| | 1 |
| Nearside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings outer sill |6.1.B.2| | 1 |
| Offside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings outer sill |6.1.B.2| | 1 |
| Nearside Front Headlamp not working on main beam |1.7.5a| | 1 |
| Offside Front Headlamp not working on main beam |1.7.5a| | 1 |
| Direction indicators not working |1.4.A.2c| | 1 |
| Hazard warning tell tale not working correctly |1.4.B.1e| | 1 |
| Hazard warning lamps inoperative |1.4.B.1b| | 1 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front Body or chassis is damaged, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Emissions not tested |7.0| | 1 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Nearside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Rear parking brake recording little or no effort | 1 |
| Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Offside Front Seat belt attachment fitting badly deteriorated |5.2.3| | 1 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Rear fog lamp does not face the rear |1.3.2a| | 1 |
| Nearside Front Direction indicators incorrect colour |1.4.A.2f| | 1 |
| Seat belt damaged sufficient to obstruct correct operation of the belt |5.2.2a| | 1 |
| Offside Front Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Front Anti-roll bar linkage rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Vehicle structure has an unsatisfactory modification, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Rear Rear fog lamp insecure |1.3.2a| | 1 |
| Nearside Front Shock absorber has an excessively worn linkage |2.7.4| | 1 |
| Nearside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Rear Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Fuel cap/sealing device does not fasten securely by positive means |7.2.4b| | 1 |
| Rear Rear fog lamp not working |1.3.2b| | 1 |
| Nearside Front Direction indicators not working |1.4.A.2c| | 1 |
| Nearside Front Body has a sharp edge caused by damage |6.1.C.1| | 1 |
| Offside Front An item not tested |Manual| | 1 |
| Front brake application uneven | 1 |
| Nearside Outer Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Outer Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Rear Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Offside Outer Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Inner Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Steering damper leaking oil |2.2.C.1f| | 1 |
| Front Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Offside Inner Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Outer Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Inner Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Offside Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Rear Mechanical brake component has restricted free movement | 1 |
| Offside Rear Rear fog lamp missing |1.3.2a| | 1 |
| Nearside Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 1 |
| Nearside Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 1 |
| Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Headlamp aim headlamp not in good working order adversely affecting beam image |1.2.4b| | 1 |
| Offside Headlamp aim headlamp not in good working order adversely affecting beam image |1.2.4b| | 1 |
| Offside Front Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Rear Leaf spring has a deteriorated shackle pin rubber bush resulting in excessive movement |2.4.B.2| | 1 |
| Tailgate cannot be secured in the closed position |6.4.1| | 1 |
| Centre Front Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Rear Loading door cannot be secured in the closed position |6.4.1| | 1 |
| Offside Front Inner Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced inner sill panel |6.1.1 |c| |i|| | 1 |
| Nearside Rear Inner Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced inner sill panel |6.1.1 |c| |i|| | 1 |
| Rear fog lamp missing |4.5.1 |a| |ii|| | 1 |
| Exhaust has a major leak of exhaust gases |6.1.2 |a|| | 1 |
| Exhaust fumes causing a danger to health of persons on board |6.1.2 |b| |ii|| | 1 |
| Emissions not tested (8.2.1.2 (d)) | 1 |
| Brake performance not tested (1.2.1 (g)) | 1 |
| Offside Front Seat belt anchorage prescribed area strength or continuity significantly reduced (7.1.1 (a) (i)) | 1 |
| Nearside Front Seat belt anchorage prescribed area strength or continuity significantly reduced (7.1.1 (a) (i)) | 1 |
| Nearside Front Passengers seat backrest cannot be secured in the upright position. (6.2.6 (a) (i)) | 1 |
| Nearside Front Upper Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Rear Outer Suspension component mounting prescribed area excessively corroded significantly reducing structural strength sill (5.3.6 (a) (i)) | 1 |
| Offside Rear Inner Suspension component mounting prescribed area excessively corroded significantly reducing structural strength sill (5.3.6 (a) (i)) | 1 |
| Nearside Front Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Rear rear brakes release unevenly |3.7.B.4| | 1 |
| Nearside Rear rear brake excessively fluctuating |3.7.B.3| | 1 |
| Offside Rear rear brake excessively fluctuating |3.7.B.3| | 1 |
| rear parking |secondary| brakes imbalanced | 1 |
| Rear rear parking |secondary| brake grabbing severely |3.7.B.6b| | 1 |
| Nearside Stop lamp excessively damaged so that it is not visible from a reasonable distance |1.2.1d| | 1 |
| Nearside Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 1 |
| Offside Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 1 |
| Nearside Headlamp insecure |1.7.3| | 1 |
| Offside Rear fog lamp insecure |1.3.2a| | 1 |
| Nearside Rear Suspension component mounting prescribed area is inadequately repaired |2.4.A.3| | 1 |
| Offside Rear Vehicle structure excessively corroded within 30cm of towbar mounting |6.6.6| | 1 |
| Nearside Rear Vehicle structure excessively corroded within 30cm of towbar mounting |6.6.6| | 1 |
| Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Front Headlamp not working on main beam |1.7.5a| | 1 |
| Offside Rear Rear fog lamp tell tale not working |1.3.1b| | 1 |
| Hazard warning switch faulty |1.4.B.1d| | 1 |
| Hazard warning lamps not flashing in phase, with ignition on |1.4.B.1f| | 1 |
| Centre Exhaust mounting missing |7.1.1b| | 1 |
| Offside Front Steering component mounting prescribed area is excessively corroded |2.2.C.1h| | 1 |
| Nearside Front Seat belt anchorage prescribed area is fractured |5.2.6| | 1 |
| Front Steering component mounting prescribed area is excessively corroded |2.2.C.1h| | 1 |
| Nearside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Steering system has excessive free play detected at the steering wheel |steering box fitted| |2.2.A.1a| | 1 |
| Nearside Rear rear brake grabbing severely |3.7.A.5b| | 1 |
| Offside Rear rear brake grabbing severely |3.7.A.5b| | 1 |
| Nearside Front passenger seat cannot be secured in the upright position. |6.2.4| | 1 |
| Offside Front Brake master cylinder/servo mounting prescribed area is excessively corroded |3.6.C.3| | 1 |
| Nearside Front Suspension component mounting prescribed area is inadequately repaired |2.4.A.3| | 1 |
| Nearside Front brake disc excessively pitted |3.5.1h| | 1 |
| Offside Front brake disc excessively pitted |3.5.1h| | 1 |
| Nearside Rear Stop lamp not working |1.2.1b| | 1 |
| Nearside Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Offside Front Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Rear Fuel pipe leaking |7.2.3| | 1 |
| Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Brake master cylinder/servo mounting prescribed area is excessively corroded |3.6.C.3| | 1 |
| Front Parking brake mechanism/associated mounting prescribed area is excessively corroded |3.1.9| | 1 |
| Horn not working |7.7 |a| |ii|| | 1 |
| Exhaust hydrocarbon content after 2nd fast idle exceeds manufacturer`s specified limits |8.2.1.2 |a|| | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength |5.3.6 |a| |i|| | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength |5.3.6 |a| |i|| | 1 |