| Most common failures | No# failures |
|---|
| Brakes imbalanced across an axle | 45 |
| Windscreen wiper does not clear the windscreen effectively | 24 |
| Headlamp aim out of alignment | 19 |
| Brake pipe excessively corroded | 18 |
| Registration plate lamp issues | 13 |
| Front brake application uneven | 12 |
| Horn not working |1.6.2a| | 12 |
| Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 9 |
| Rear brake application uneven | 9 |
| Registration plate issues | 8 |
| Offside front brake binding |3.7.B.1| | 8 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 7 |
| Exhaust emissions hydrocarbon content excessive |7.3.B.1b| | 7 |
| Offside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 7 |
| Offside Rear fog lamp not working |1.3.2b| | 7 |
| Nearside front brake binding |3.7.B.1| | 7 |
| Offside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 7 |
| Nearside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 6 |
| Nearside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 5 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 5 |
| Offside Front front brake binding |3.7.B.1| | 4 |
| Offside Front Body has a sharp edge caused by corrosion |6.1.C.1| | 4 |
| Nearside Windscreen wiper blade deteriorated |8.2.2| | 4 |
| Offside Windscreen wiper blade deteriorated |8.2.2| | 4 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 4 |
| Exhaust system not adequately supported |7.1.1| | 4 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 4 |
| Offside Stop lamp not working |1.2.1b| | 4 |
| Parking brake: efficiency below requirements |3.7.B.7| | 4 |
| Offside Front Shock absorber has a serious fluid leak |2.7.3| | 4 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 4 |
| Nearside Front Shock absorber has a serious fluid leak |2.7.3| | 4 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 4 |
| Service brake: efficiency below requirements |3.7.B.7| | 4 |
| Emissions not tested |7.0| | 3 |
| Front brake excessively fluctuating | 3 |
| Nearside Front front brake binding |3.7.B.1| | 3 |
| Rear Exhaust system not adequately supported |7.1.1| | 3 |
| Nearside Front Body has a sharp edge caused by corrosion |6.1.C.1| | 3 |
| Nearside Rear Body has a sharp edge caused by corrosion |6.1.C.1| | 3 |
| Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 3 |
| Centre Exhaust system not adequately supported |7.1.1| | 3 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 3 |
| Rear parking brake recording little or no effort | 3 |
| Nearside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 3 |
| Offside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 3 |
| Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 3 |
| Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 3 |
| Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Offside front brake recording little or no effort |3.7.B.5a| | 2 |
| Nearside Stop lamp not working |1.2.1b| | 2 |
| Offside Headlamp not working on main beam |1.7.5a| | 2 |
| Brake master cylinder/servo mounting prescribed area is excessively corroded |3.6.C.3| | 2 |
| Exhaust engine idle speed too high |7.3.A.2a| | 2 |
| Offside Rear fog lamp insecure |1.3.2a| | 2 |
| Exhaust emissions carbon monoxide content excessive |8.2.1.2 |b|| | 2 |
| Exhaust emissions hydrocarbon content excessive |8.2.1.2 |b|| | 2 |
| Nearside Front Anti-roll bar pin or bush excessively worn (5.3.4 (a) (i)) | 2 |
| Offside Rear Body has a sharp edge caused by corrosion |6.1.C.1| | 2 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 2 |
| Stop lamp remains on when the brakes are released | 2 |
| Nearside Body has a sharp edge caused by corrosion |6.1.C.1| | 2 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 2 |
| Nearside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 2 |
| Rear fog lamp tell tale not working |1.3.1b| | 2 |
| Offside Rear fog lamp missing |1.3.2a| | 2 |
| Brake pedal spongy |3.3.B.1b| | 2 |
| Parking brake lever has no reserve travel |3.1.6b| | 2 |
| Offside Front front brake recording little or no effort |3.7.B.5a| | 2 |
| Towbar component insecure |6.6.1| | 2 |
| Nearside Front Lower Ball joint has excessive play |2.2.B.1f| | 2 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Nearside Front Shock absorbers has a serious fluid leak | 2 |
| Offside front brake grabbing severely |3.7.A.2b| | 1 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Rear Rear fog lamp not working |1.3.2b| | 1 |
| Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Service brake is causing the steering wheel to severely pull one way |3.7.C.2| | 1 |
| Nearside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Brake hydraulic reservoir fluid level below minimum level |3.6.G.1b| | 1 |
| Rear Brake pipe excessively damaged |3.6.B.2c| | 1 |
| Nearside Rear front brakes release unevenly |3.7.B.4| | 1 |
| Offside Rear front brakes release unevenly |3.7.B.4| | 1 |
| Nearside Front Parking brake mechanism/associated mounting prescribed area is excessively corroded |3.1.9| | 1 |
| Nearside Front Steering component mounting prescribed area is excessively corroded |2.2.C.1h| | 1 |
| Offside Front Brake actuating linkage mounting prescribed area is excessively corroded |3.3.A.2| | 1 |
| Nearside Front Upper Seat belt insecurely fixed to the vehicles structure |5.2.1a| | 1 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Brake hose excessively deteriorated | 1 |
| Nearside Rear Fuel tank insecure |7.2.1| | 1 |
| Nearside Rear Exhaust system not adequately supported |7.1.1| | 1 |
| Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 1 |
| Offside Front Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Rear Stop lamp not working |1.2.1b| | 1 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Obligatory mirror insecure |8.1.1| | 1 |
| Offside Front Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Nearside Front Ball joint has excessive play |2.2.B.1f| | 1 |
| Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
| Battery insecure |1.9.1| | 1 |
| Nearside Front Anti-roll bar locating pin insecure |2.4.G.3a| | 1 |
| Offside Front Anti-roll bar locating pin insecure |2.4.G.3a| | 1 |
| Offside Front Upper Suspension arm corroded and seriously weakened |2.4.G.1| | 1 |
| Offside Rear fog lamp excessively deteriorated so that it is not visible from a reasonable distance |1.3.2d| | 1 |
| Trailer electrical socket |13 pin| not operating the trailer lamps as intended |1.9.4| | 1 |
| Nearside Headlamp not working on main beam |1.7.5a| | 1 |
| Fuel cap/sealing device missing |7.2.4a| | 1 |
| Nearside Front Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
| Centre Front Horn not working |1.6.2a| | 1 |
| Front Service brake imbalanced across an axle |1.2.1 |b| |i|| | 1 |
| Exhaust fumes causing a danger to health of persons on board |6.1.2 |b| |ii|| | 1 |
| Exhaust has a major leak of exhaust gases |6.1.2 |a|| | 1 |
| Offside Front Service brake excessively binding (1.2.1 (f)) | 1 |
| Offside Front Anti-roll bar pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Vehicle structure strengthening plate or fastening insecure by steering box (6.1.1 (b) (i)) | 1 |
| Nearside Rear Inner Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced wheel arch (6.1.1 (c) (i)) | 1 |
| Offside Rear Inner Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced wheel arch x2 (6.1.1 (c) (i)) | 1 |
| Rear Spare wheel carrier fractured (6.1.5 (a)) | 1 |
| Nearside Front Lower Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Front Steering pivot point has excessive play |2.2.B.1g| | 1 |
| Offside Front Steering pivot point has excessive play |2.2.B.1g| | 1 |
| Rear Rear fog lamp switch missing |1.3.1a| | 1 |
| Offside Front Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
| Offside Outer Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Inner Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Outer Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Rear brake binding | 1 |
| Offside Front Steering component mounting prescribed area is excessively corroded |2.2.C.1h| | 1 |
| Nearside Front Brake pipe fouled by moving parts |3.6.B.2a| | 1 |
| Offside Front Brake pipe fouled by moving parts |3.6.B.2a| | 1 |
| Nearside Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside front brake recording little or no effort |3.7.B.5a| | 1 |
| Brake pedal creeps down while the pedal is held under pressure |3.3.B.1a| | 1 |
| Brake actuating linkage mounting prescribed area is excessively corroded |3.3.A.2| | 1 |
| Rear Exhaust mounting missing |7.1.1b| | 1 |
| Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Centre Passenger`s seat cannot be secured in the upright position. |6.2.A.2| | 1 |
| Driver`s seat insecure |6.2.A.1| | 1 |
| Windscreen has a sticker or other obstruction encroaching by more than 10mm within zone `A` |8.3.1b| | 1 |
| Exhaust system not adequately supported back box |7.1.1| | 1 |
| Offside Windscreen wiper not operating over a large enough area to give an adequate view |8.2.1c| | 1 |
| Offside Front Service brake lagging in operation (1.2.1 (d)) | 1 |
| Offside Front Brake performance not tested |3.7.A.1| | 1 |
| Emissions not tested |7.3.A.1| | 1 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Front Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Front Headlamp not working on main beam |1.7.5a| | 1 |
| Emissions not tested Tick over to high |7.3.A.1| | 1 |
| Offside Front Lower Steering pivot point has excessive play |2.2.B.1g| | 1 |
| Centre Exhaust mounting missing |7.1.1b| | 1 |
| Rear Exhaust has a part missing |7.1.1a| | 1 |
| Nearside Front Service brake excessively binding (1.2.1 (f)) | 1 |
| Offside Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 1 |
| Fuel cap/sealing device sealing washer missing |7.2.4c| | 1 |
| Offside Front front brake grabbing severely |3.7.A.2b| | 1 |
| Offside Rear front brake recording little or no effort |3.7.B.5a| | 1 |
| Offside Rear front parking brake recording little or no effort |3.7.B.6a| | 1 |
| front brakes release unevenly |3.7.B.4| | 1 |
| Nearside Seat belt anchorage prescribed area is inadequately repaired |5.2.6| | 1 |
| Offside Seat belt anchorage prescribed area is inadequately repaired |5.2.6| | 1 |
| Offside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Rear Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Nearside Side repeater not working |1.4.A.2c| | 1 |
| Nearside Front Valve stem seriously damaged |4.1.D.1e| | 1 |
| Offside Front Valve stem seriously damaged |4.1.D.1e| | 1 |
| Offside Rear An item not tested |Manual| | 1 |
| Centre Front passenger seat insecure |6.2.3| | 1 |
| Rear Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Front Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Nearside Front front brake recording little or no effort |3.7.B.5a| | 1 |
| Offside Headlamp insecure |1.7.3| | 1 |
| Indicator switch insecure |1.4.A.1| | 1 |
| Headlamp switch insecure |1.7.1| | 1 |
| Offside Ball joint has excessive play |2.2.B.1f| | 1 |
| Brake master cylinder fluid level below minimum level |3.6.G.1e| | 1 |
| Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Offside Front Headlamp aim not tested |1.8.A.1c| | 1 |
| Offside Front Lower Body has a sharp edge caused by damage |6.1.C.1| | 1 |
| Centre Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Nearside Rear Lower Vehicle structure excessively corroded within 30cm of towbar mounting |6.6.6| | 1 |
| Offside Rear Lower Vehicle structure excessively corroded within 30cm of towbar mounting |6.6.6| | 1 |
| Nearside Rear Vehicle structure excessively corroded within 30cm of towbar mounting |6.6.6| | 1 |
| Offside Rear Vehicle structure excessively corroded within 30cm of towbar mounting |6.6.6| | 1 |
| Nearside Rear Leaf spring anchor bracket corroded and seriously weakened |2.4.B.6d| | 1 |
| Nearside Rear Lower Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Rear Lower Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Nearside Steering pivot point has excessive play |2.2.B.1g| | 1 |
| Offside Steering pivot point has excessive play |2.2.B.1g| | 1 |
| Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Offside Front Lower Ball joint has excessive play |2.2.B.1f| | 1 |
| Rear fog lamp lens defective such that emitted light is adversely affected |4.5.1 |b| |ii|| | 1 |
| Offside Obligatory mirror missing |3.3 |a|| | 1 |
| Nearside Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Brake fluid warning lamp illuminated |3.6.G.2| | 1 |
| Rear Rear fog lamp emits a light other than red |1.3.2e| | 1 |
| Offside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Rear Rear fog lamp insecure |1.3.2a| | 1 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Front Seat belt insecurely fixed to the vehicles structure |5.2.1a| | 1 |
| Offside Body or chassis is cracked, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Rear Direction indicator not working |1.4.A.2c| | 1 |
| Offside Rear fog lamp excessively damaged so that it is not visible from a reasonable distance |1.3.2d| | 1 |
| Rear fog lamp switch faulty |1.3.1a| | 1 |
| Brake has no servo assistance |3.3.B.2| | 1 |
| Offside Front Upper Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Front Lower Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Parking brake is not capable of being maintained in operation by direct mechanical action only |3.1.2| | 1 |
| Offside Rear Suspension spring mounting prescribed area is inadequately repaired |2.4.A.3| | 1 |
| Offside Front Seat belt not functioning as intended |7.1.2 |c|| | 1 |
| Nearside Front Position lamp adversely affected by the operation of another lamp |4.2.3 |c|| | 1 |
| Offside Front Position lamp adversely affected by the operation of another lamp |4.2.3 |c|| | 1 |
| Nearside Rear Position lamp adversely affected by the operation of another lamp |4.2.3 |c|| | 1 |
| Offside Rear Position lamp adversely affected by the operation of another lamp |4.2.3 |c|| | 1 |
| Offside Front Road wheel fixing missing |5.2.1 |a| |i|| | 1 |
| Offside Rear Road wheel fixing missing |5.2.1 |a| |i|| | 1 |
| Nearside Rear Outer Suspension component mounting prescribed area is inadequately repaired Lower quarter panel |5.3.6 |a| |i|| | 1 |
| Rear fog lamp not working |1.3.2b| | 1 |
| Nearside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Rear Service brake imbalanced across an axle 49% (1.2.1 (b) (i)) | 1 |
| Stop lamp adversely affected by the operation of another lamp both rear |1.2.1f| | 1 |
| Nearside Rear Service brake effort inadequate at a wheel (1.2.1 (a) (i)) | 1 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Offside Rear Rear fog lamp does not emit a steady red light (4.5.4 (a)) | 1 |
| Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| All position lamps not working |1.1.A.3b| | 1 |
| Nearside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Body has a projection caused by corrosion |6.1.C.1| | 1 |
| An item not tested |Manual| | 1 |
| Nearside Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Rear Stop lamp not working |1.2.1b| | 1 |
| Offside Rear Inner Suspension spring mounting prescribed area is inadequately repaired sill |5.3.6 |a| |i|| | 1 |
| Offside Rear Outer Suspension spring mounting prescribed area excessively corroded significantly reducing structural strength sill |5.3.6 |a| |i|| | 1 |
| Exhaust emissions carbon monoxide content excessive high |7.3.B.1a| | 1 |
| Offside Rear Suspension spring mounting prescribed area is excessively corroded inner/outer sills |2.4.A.3| | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength outer sills |5.3.6 |a| |i|| | 1 |
| Offside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |