Most common failures | No# failures |
---|
Brakes imbalanced across an axle | 20 |
Windscreen wiper does not clear the windscreen effectively | 16 |
Registration plate lamp issues | 10 |
Brake pipe excessively corroded | 9 |
Horn not working |1.6.2a| | 8 |
Offside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 8 |
Headlamp aim out of alignment | 8 |
Nearside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 6 |
Front brake application uneven | 6 |
Rear brake application uneven | 5 |
Registration plate issues | 5 |
Exhaust has a major leak of exhaust gases |7.1.2| | 5 |
Offside Front Headlamp not working on dipped beam |1.7.5a| | 4 |
Rear brake binding | 4 |
Rear parking brake recording little or no effort | 3 |
Exhaust emissions hydrocarbon content excessive |7.3.B.1b| | 3 |
Parking brake lever has no reserve travel |3.1.6b| | 2 |
Nearside rear brake recording little or no effort |3.7.B.5a| | 2 |
Rear Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
Offside Rear Suspension spring mounting prescribed area is inadequately repaired |2.4.A.3| | 2 |
Nearside Rear Suspension spring mounting prescribed area is inadequately repaired |2.4.A.3| | 2 |
Brake master cylinder/servo mounting prescribed area is excessively corroded |3.6.C.3| | 2 |
Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
Offside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 2 |
Nearside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 2 |
Nearside Front Seat belt retracting mechanism defective |5.2.5b| | 2 |
Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
Service brake: efficiency below requirements |3.7.B.7| | 2 |
Centre Exhaust system not adequately supported |7.1.1| | 2 |
Centre Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
Front Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
Emissions not tested |7.0| | 2 |
Brake pedal spongy |3.3.B.1b| | 2 |
Nearside Rear Body has a sharp edge caused by corrosion |6.1.C.1| | 2 |
Nearside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 2 |
Offside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 2 |
Driver`s seat insecure |6.2.A.1| | 2 |
Offside rear brake recording little or no effort |3.7.B.5a| | 2 |
Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 2 |
Offside Stop lamp not working |1.2.1b| | 2 |
Nearside front brake binding |3.7.B.1| | 2 |
Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 2 |
Steering system has excessive free play detected at the steering wheel |steering box fitted| |2.2.A.1a| | 2 |
Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 2 |
Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
Offside Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
Nearside Rear Suspension spring mounting prescribed area is excessively corroded outer sill |2.4.A.3| | 1 |
Offside Rear Suspension spring mounting prescribed area is excessively corroded inner sill |2.4.A.3| | 1 |
Steering box has a significant oil leak |2.2.D.2e| | 1 |
Offside Front Body or chassis has an inadequate repair, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
Parking brake mechanism/associated mounting prescribed area is excessively corroded |3.1.9| | 1 |
Offside Front Brake master cylinder/servo mounting prescribed area is excessively corroded |3.6.C.3| | 1 |
Offside Front Steering component mounting prescribed area is excessively corroded |2.2.C.1h| | 1 |
Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Front Front position lamp|s| excessively damaged so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
Offside Front Headlamp aim not tested |1.8.A.1c| | 1 |
Nearside Seat belt insecurely fixed to the vehicles structure |5.2.1a| | 1 |
Service brake is causing the vehicle to swerve to the nearside |3.7.C.2| | 1 |
Nearside wheel cylinder has restricted free movement |3.5.1k| | 1 |
Nearside Front Tie bar/rod rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Offside Front Tie bar/rod rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Offside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
Nearside Windscreen wiper blade deteriorated |8.2.2| | 1 |
Offside Windscreen wiper blade deteriorated |8.2.2| | 1 |
Nearside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
An item not tested |Manual| | 1 |
Brake load sensing valve linkage seized |3.6.E.3| | 1 |
Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Steering box deformed and unserviceable |2.2.C.1d| | 1 |
Nearside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
Offside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
rear brake recording little or no effort |3.7.B.5a| | 1 |
Parking brake: efficiency below requirements |3.7.B.7| | 1 |
Offside Front front brake grabbing severely |3.7.A.2b| | 1 |
Nearside Headlamp not in a clean condition affecting beam image |1.2.4a| | 1 |
Offside front brake recording little or no effort |3.7.B.5a| | 1 |
Exhaust system not adequately supported |7.1.1| | 1 |
Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
Rear Direction indicator adversely affected by the operation of another lamp |1.4.A.2h| | 1 |
Fuel cap/sealing device missing |7.2.4a| | 1 |
Nearside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
Nearside front brake juddering severely |3.7.A.2b| | 1 |
Offside front brake juddering severely |3.7.A.2b| | 1 |
rear brakes release unevenly |3.7.B.4| | 1 |
Nearside Rear rear brake grabbing severely |3.7.A.5b| | 1 |
Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Nearside Front Service brake excessively binding (1.2.1 (f)) | 1 |
Offside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
Rear Spare wheel carrier insecure (6.1.5 (a)) | 1 |
Rear Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced cross member holed,nsr inner corner and osr inner corner (6.1.1 (c) (i)) | 1 |
Nearside Rear Inner Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced wheel arch/end of sill (6.1.1 (c) (i)) | 1 |
Offside Rear Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced inner/outer sill (6.1.1 (c) (i)) | 1 |
Offside Front Inner Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced sill (6.1.1 (c) (i)) | 1 |
Nearside Rear Suspension spring mounting prescribed area excessively corroded significantly reducing structural strength front leaf spring mount upper holed (5.3.6 (a) (i)) | 1 |
Offside Rear Suspension spring mounting prescribed area excessively corroded significantly reducing structural strength front leaf spring mount upper holed (5.3.6 (a) (i)) | 1 |
Offside Front Headlamp not in good working order |not working| |1.2.4a| | 1 |
Nearside Rear Shock absorber missing |2.7.1b| | 1 |
Offside Rear Shock absorber missing |2.7.1b| | 1 |
Nearside Front Shock absorber has negligible damping effect |2.7.5| | 1 |
Offside Front Shock absorber has negligible damping effect |2.7.5| | 1 |
Body insecure and dangerous to other road users |6.1.B.1b| | 1 |
Offside Front front brake binding |3.7.B.1| | 1 |
Offside Headlamp not working on dipped beam |1.7.5a| | 1 |
Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
Nearside Front passenger seat cannot be secured in the upright position. |6.2.4| | 1 |
Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
Offside Front Headlamp insecure |1.7.3| | 1 |
Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
Rear position lamp|s| missing |1.1.A.3a| | 1 |
Offside Front position lamp|s| not working |1.1.A.3b| | 1 |
Offside Rear reflector missing |1.5.1a| | 1 |
Nearside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Front Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
Nearside Rear Road wheel badly damaged |4.2.A.1a| | 1 |
Offside Rear position lamp|s| incomplete |1.1.4a| | 1 |
Brake hose excessively deteriorated | 1 |
Nearside Front Anti-roll bar linkage fractured |2.4.G.1| | 1 |
Nearside Front Brake lining|s| less than 1.5 mm thick |1.1.13 |a| |ii|| | 1 |
Brake performance not tested |1.2.1 |g|| | 1 |
Nearside Stop lamp not working |1.2.1b| | 1 |
Emissions not tested |7.3.A.1| | 1 |
Offside Stop lamp emits other than a steady red light |1.2.1e| | 1 |
Nearside Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
Nearside Obligatory mirror missing |8.1.1| | 1 |
Offside Rear Suspension has inadequate clearance with the bump stop |2.4.A.1a| | 1 |
Nearside Suspension has inadequate clearance with the bump stop |2.4.A.1a| | 1 |
Offside Front Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
Exhaust engine idle speed too high |7.3.A.2a| | 1 |
Nearside rear brake excessively fluctuating |3.7.B.3| | 1 |
Offside rear brake excessively fluctuating |3.7.B.3| | 1 |
Nearside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
Offside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
Offside Front Seat belt insecurely fixed to the vehicles structure |5.2.1a| | 1 |
Offside Front Body has a sharp edge caused by corrosion door |6.1.C.1| | 1 |
Rear Body has a sharp edge caused by corrosion tail gate |6.1.C.1| | 1 |
Nearside Front Body has a sharp edge caused by corrosion door |6.1.C.1| | 1 |
Nearside Rear Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
Offside Front Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
Fuel cap/sealing device sealing washer missing |7.2.4c| | 1 |
Offside Front Braking system leaking Reservoir pipe to master cylinder |1.1.3 |d|| | 1 |
Rear Exhaust has a major leak of exhaust gases |6.1.2 |a|| | 1 |
Offside Front Upper Suspension arm ball joint dust cover no longer prevents the ingress of dirt |5.3.4 |b| |ii|| | 1 |
Nearside Front Drag link end ball joint has excessive play Bush |2.1.3 |b| |i|| | 1 |
Dipswitch operation does not deflect all main beam headlamps to make them dipped beams |1.7.4b| | 1 |
Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
Nearside Obligatory mirror insecure |8.1.1| | 1 |
Nearside Passenger`s seat insecure |6.2.A.1| | 1 |
Offside Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
Nearside Rear Direction indicator adversely affected by the operation of another lamp |1.4.A.2h| | 1 |
Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
Offside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
Offside Obligatory mirror missing |8.1.1| | 1 |
Front Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
Offside Rear Wheel nut|s| missing |4.2.A.1e| | 1 |
Offside Headlamp aim beam image kick up to the offside |1.6.B1| | 1 |
Rear Stop lamp not working |1.2.1b| | 1 |
Braking system leaking |3.6.A.1| | 1 |
Nearside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
Nearside Headlamp not working on main beam |1.7.5a| | 1 |
Offside Headlamp not working on main beam |1.7.5a| | 1 |
Nearside Indicator tell tale inoperative |1.4.A.2a| | 1 |
Hazard warning lamps not flashing in phase, with ignition off |1.4.B.1f| | 1 |
Front Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
Offside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
Nearside Front Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
Nearside Front Steering pivot point has excessive play |2.2.B.1g| | 1 |
Rear Rear position lamp|s| insecure |1.1.A.3a| | 1 |
Offside Front Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
Nearside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
Nearside Front Lower Ball joint has excessive play |2.2.B.1f| | 1 |
Offside Steering box has relative movement between sector shaft and the drop arm |2.2.B.1b| | 1 |