| Most common failures | No# failures |
|---|
| Brakes imbalanced across an axle | 38 |
| Windscreen wiper does not clear the windscreen effectively | 32 |
| Rear brake application uneven | 25 |
| Headlamp aim out of alignment | 24 |
| Front brake application uneven | 23 |
| Registration plate lamp issues | 17 |
| Brake pipe excessively corroded | 14 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 13 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 8 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 7 |
| Offside front brake binding |3.7.B.1| | 7 |
| Rear parking brake recording little or no effort | 7 |
| Registration plate issues | 7 |
| Horn not working |1.6.2a| | 7 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 6 |
| Offside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 6 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 6 |
| Offside Headlamp not working on main beam |1.7.5a| | 6 |
| Exhaust emissions hydrocarbon content excessive |7.3.B.1b| | 6 |
| Parking brake: efficiency below requirements |3.7.B.7| | 6 |
| Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 6 |
| Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 5 |
| Rear brake binding | 5 |
| rear brakes release unevenly |3.7.B.4| | 5 |
| Offside Obligatory mirror insecure |8.1.1| | 4 |
| Nearside front brake binding |3.7.B.1| | 4 |
| Offside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 4 |
| Offside Stop lamp not working |1.2.1b| | 3 |
| Offside Front front brake binding |3.7.B.1| | 3 |
| Brake pedal spongy |3.3.B.1b| | 3 |
| Exhaust system not adequately supported |7.1.1| | 3 |
| Offside Front front brake recording little or no effort |3.7.B.5a| | 3 |
| Offside Front Shock absorber has a serious fluid leak |2.7.3| | 3 |
| Centre Exhaust system not adequately supported |7.1.1| | 3 |
| Service brake: efficiency below requirements |3.7.B.7| | 3 |
| Nearside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 3 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
| Nearside Headlamp not working on main beam |1.7.5a| | 3 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 3 |
| Nearside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 3 |
| Nearside Front Shock absorber has negligible damping effect |2.7.5| | 3 |
| Offside Front Shock absorber has negligible damping effect |2.7.5| | 3 |
| Nearside Stop lamp not working |1.2.1b| | 3 |
| Nearside Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Offside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 2 |
| Offside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Windscreen has damage | 2 |
| Parking brake lever has no reserve travel |3.1.6b| | 2 |
| Offside Steering arm has relative movement at its fixings |2.2.B.1h| | 2 |
| Centre Exhaust mounting missing |7.1.1b| | 2 |
| Steering system has excessive free play detected at the steering wheel |steering box fitted| |2.2.A.1a| | 2 |
| Nearside Front Shock absorber has a serious fluid leak |2.7.3| | 2 |
| Offside Front wheel bearing has excessive play |2.5.A.3c| | 2 |
| Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 2 |
| Offside Rear Direction indicator adversely affected by the operation of another lamp |1.4.A.2h| | 2 |
| Nearside Front Body has a sharp edge caused by corrosion |6.1.C.1| | 2 |
| Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| front brakes release unevenly |3.7.B.4| | 2 |
| Nearside Front Direction indicator excessively damaged so that it is not visible from a reasonable distance |1.4.A.2e| | 2 |
| Nearside Body has a sharp edge caused by corrosion |6.1.C.1| | 2 |
| Rear Exhaust system not adequately supported |7.1.1| | 2 |
| Offside Front Headlamp not working on main beam |1.7.5a| | 2 |
| Steering component mounting prescribed area is excessively corroded |2.2.C.1h| | 2 |
| Offside Rear Stop lamp not working |1.2.1b| | 2 |
| Offside Rear Body has a sharp edge caused by corrosion |6.1.C.1| | 2 |
| Nearside Front front brake binding |3.7.B.1| | 2 |
| Fuel pipe excessively chafed |7.2.2| | 2 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 2 |
| Nearside Rear Rear position lamp|s| not working |1.1.A.3b| | 2 |
| Nearside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Offside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Fuel tank leaking |7.2.3| | 2 |
| Emissions not tested |7.0| | 2 |
| Brake pedal has insufficient reserve movement |3.3.A.5| | 2 |
| Exhaust mounting missing |7.1.1b| | 2 |
| Braking system leaking |3.6.A.1| | 2 |
| Rear Mechanical brake component has restricted free movement | 2 |
| Offside Front Drag link end ball joint has excessive play |2.2.B.1f| | 2 |
| Offside Front Direction indicator not working |1.4.A.2c| | 2 |
| Mechanical brake component has restricted free movement | 2 |
| Driver`s door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
| Nearside Front passenger door does not latch securely closed |6.2.B.1a| | 1 |
| Nearside Front suspension has a suspension lower ball joint securing nut not locked |2.5.B.1a| | 1 |
| Offside Front suspension has a suspension lower ball joint securing nut not locked |2.5.B.1a| | 1 |
| Nearside Front Braking system leaking |3.6.A.1| | 1 |
| Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 1 |
| Nearside Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 1 |
| Offside Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 1 |
| Nearside Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
| Front Exhaust mounting missing |7.1.1b| | 1 |
| Offside Front Lower Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Exhaust system insecure |6.1.2 |a|| | 1 |
| Offside Front Lower Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Front Seat belt has a cut which has significantly weakened the webbing |5.2.2a| | 1 |
| Nearside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Brake hose damaged | 1 |
| Nearside Front Brake pipe inadequately supported |3.6.B.1| | 1 |
| Rear Exhaust has a part missing |7.1.1a| | 1 |
| Nearside front brake grabbing severely |3.7.A.2b| | 1 |
| An item not tested |Manual| | 1 |
| Offside Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 1 |
| Offside Front Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Exhaust emits excessive dense blue smoke during acceleration |7.3.A.2c| | 1 |
| Exhaust emits dense blue smoke at idle |7.3.A.2b| | 1 |
| Nearside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Driver`s door pillar insecure |6.2.B.2| | 1 |
| Brake pipe inadequately supported across the rear axle |3.6.B.1| | 1 |
| Steering component mounting prescribed area is excessively corroded offside front inner and outer sill |2.2.C.1h| | 1 |
| Steering component mounting prescribed area is excessively corroded offside front floor |2.2.C.1h| | 1 |
| Offside Front Seat belt anchorage prescribed area is excessively corroded inner wing below divers seat |5.2.6| | 1 |
| Rear Upper Brake pipe leaking |3.6.A.1| | 1 |
| Nearside front brake recording little or no effort |3.7.B.5a| | 1 |
| Nearside Front passenger door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
| Brake pedal creeps down while the pedal is held under pressure |3.3.B.1a| | 1 |
| Rear Brake pipe leaking |3.6.A.1| | 1 |
| Offside Inner Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Inner Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Centre Statutory seat belt missing |5.1.1| | 1 |
| Offside Driver`s seat insecure |6.2.A.1| | 1 |
| Centre Front Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Offside Front Brake pipe leaking |3.6.A.1| | 1 |
| Nearside Front front brake recording little or no effort |3.7.B.5a| | 1 |
| Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Parking brake not fitted on at least two wheels |3.1.1| | 1 |
| Nearside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Front Upper Suspension arm corroded and seriously weakened |2.4.G.1| | 1 |
| Offside Front Steering pivot point has excessive play |2.2.B.1g| | 1 |
| Offside Indicator tell tale inoperative |1.4.A.2a| | 1 |
| Fuel cap/sealing device sealing washer torn |7.2.4c| | 1 |
| front brake juddering severely |3.7.A.2b| | 1 |
| Offside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Nearside Rear rear brake grabbing severely |3.7.A.5b| | 1 |
| Offside Outer Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Nearside Rear rear parking |secondary| brake grabbing severely |3.7.B.6b| | 1 |
| Offside Rear rear parking |secondary| brake grabbing severely |3.7.B.6b| | 1 |
| Horn not working |7.7 |a| |ii|| | 1 |
| Exhaust has a major leak of exhaust gases |6.1.2 |a|| | 1 |
| Emissions not tested Due to leak of exhaust producing an untrue reading |8.2.1.2 |d|| | 1 |
| Rear fog lamp not working |1.3.2b| | 1 |
| Offside Suspension spring mounting prescribed area is deliberately modified which significantly reduces the original strength |2.4.A.3| | 1 |
| Windscreen wiper blade insecure | 1 |
| Offside Rear Rear wheel bearing rough when rotated |2.6.1| | 1 |
| Nearside Outer Rear Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Nearside Rear Stop lamp not working |1.2.1b| | 1 |
| Offside Rear rear brake juddering severely |3.7.A.5b| | 1 |
| Nearside Rear Direction indicator not working |1.4.A.2c| | 1 |
| Spare wheel insecure |6.4.2| | 1 |
| Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Front Shock absorber has negligible damping effect |2.7.5| | 1 |
| Nearside Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Offside Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Rear Rear wheel bearing rough when rotated |2.6.1| | 1 |
| Offside Rear Direction indicator incomplete |1.5.A1b| | 1 |
| Offside Rear Brake pipe inadequately clipped |3.6.B.1| | 1 |
| Nearside Front Seat belt insecurely fixed to the vehicles structure |5.2.1a| | 1 |
| Offside Front Driver`s seat cannot be secured in the upright position. |6.2.A.2| | 1 |
| Nearside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Hazard warning lamps not flashing in phase, with ignition on |1.4.B.1f| | 1 |
| Hazard warning lamps not flashing in phase, with ignition off |1.4.B.1f| | 1 |
| Hazard warning tell tale not working correctly |1.4.B.1e| | 1 |
| Nearside Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 1 |
| Nearside Rear Direction indicators adversely affected by the operation of another lamp |1.4.A.2h| | 1 |
| Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Obligatory mirror insecure |8.1.1| | 1 |
| Centre Exhaust system not adequately supported and rear |7.1.1| | 1 |
| Nearside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Offside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Offside Front Front suspension has excessive play in an outer ball joint |2.5.B.2a| | 1 |
| Offside Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 1 |
| Brake servo vacuum pipe deteriorated |3.6.C.1b| | 1 |
| Offside Front Obligatory mirror missing |8.1.1| | 1 |
| Nearside front brake juddering severely |3.7.A.2b| | 1 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Front front brake grabbing severely |3.7.A.2b| | 1 |
| Offside Rear Fuel pipe leaking |7.2.3| | 1 |
| Nearside Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Brake hose excessively deteriorated | 1 |
| Nearside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Front Anti-roll bar linkage rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Anti-roll bar linkage rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Braking system leaking |3.6.A.1| | 1 |
| Exhaust emissions carbon monoxide content excessive |8.2.1.2 |b|| | 1 |
| Offside Front Braking system leaking wheel cylinder |3.6.A.1| | 1 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Body has a projection caused by damage |6.1.C.1| | 1 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Nearside Indicator tell tale inoperative |1.4.A.2a| | 1 |
| Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Offside Fuel tank leaking |7.2.3| | 1 |
| Service brake is causing the steering wheel to severely pull one way |3.7.C.2| | 1 |
| Centre Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Windscreen wiper not operating over a large enough area to give an adequate view |8.2.1c| | 1 |
| Offside Windscreen wiper not operating over a large enough area to give an adequate view |8.2.1c| | 1 |
| Brake pipe inadequately clipped |3.6.B.1| | 1 |
| Brake master cylinder/servo mounting prescribed area is excessively corroded |3.6.C.3| | 1 |
| Parking brake mechanism/associated mounting prescribed area is excessively corroded |3.1.9| | 1 |
| Nearside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Front Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 1 |