| Most common failures | No# failures |
|---|
| Windscreen wiper does not clear the windscreen effectively | 23 |
| Headlamp aim out of alignment | 15 |
| Brake pipe excessively corroded | 12 |
| Anti-lock braking system warning lamp indicates an ABS fault | 7 |
| Offside Rear Wheel bearing rough when rotated (5.1.3 (b) (i)) | 4 |
| Front brake disc in such a condition that it is seriously weakened | 4 |
| Registration plate issues | 4 |
| Front Exhaust system insecure (6.1.2 (a)) | 3 |
| Front Exhaust system not adequately supported |7.1.1| | 3 |
| Nearside Rear Service brake excessively binding (1.2.1 (f)) | 3 |
| Offside Front Coil spring fractured or broken (5.3.1 (b) (i)) | 3 |
| Windscreen washer not working | 3 |
| Registration plate lamp issues | 3 |
| Front brake application uneven | 2 |
| Offside Rear Wheel bearing has excessive play |5.1.3 |a| |i|| | 2 |
| Offside Rear Wheel bearing rough when rotated |5.1.3 |b| |i|| | 2 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 2 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 2 |
| Nearside Rear Wheel bearing rough when rotated (5.1.3 (b) (i)) | 2 |
| Offside Front Side repeater not working (4.4.1 (a) (ii)) | 2 |
| Brakes imbalanced across an axle | 2 |
| Nearside Front coil spring broken |2.4.C.1a| | 2 |
| Parking brake: efficiency below requirements |3.7.B.7| | 2 |
| Rear Exhaust system not adequately supported |7.1.1| | 2 |
| Central Rear Exhaust system insecure rubber mount (6.1.2 (a)) | 1 |
| Offside Rear Outer Suspension component mounting prescribed area excessively corroded significantly reducing structural strength Sill (5.3.6 (a) (i)) | 1 |
| Rear brake application uneven | 1 |
| Nearside Front Outer Anti-lock braking system component excessively damaged ABS ring (1.6 (e)) | 1 |
| Offside Front Headlamp insecure (4.1.1 (c)) | 1 |
| Offside Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Front Lower Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Offside Rear Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Nearside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Front Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Front Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Brake servo defective or ineffective Sponginess (1.1.10 (a) (i)) | 1 |
| Rear fog lamp light intensity significantly reduced (4.5.4 (a)) | 1 |
| Drivers view of an obligatory external mirror significantly affected by an obstruction (3.1 (a) (ii)) | 1 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 1 |
| Central Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Offside Rear fog lamp missing |1.3.2a| | 1 |
| Nearside Rear reflector missing |1.5.1a| | 1 |
| Offside Rear reflector missing |1.5.1a| | 1 |
| Headlamp aim projected beam image is obviously incorrect both (4.1.2 (c)) | 1 |
| Centre Rear Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Offside Front Drivers view of the road through the swept area of the windscreen materially affected by an obstruction sun visor doesnt secure in upright position (3.1 (a) (ii)) | 1 |
| Rear Exhaust system insecure (6.1.2 (a)) | 1 |
| Offside Drivers view of the road through the swept area of the windscreen materially affected by an obstruction (3.1 (a) (ii)) | 1 |
| Nearside Rear Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 1 |
| Offside Front Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Rear fog lamp not working |4.5.1 |a| |ii|| | 1 |
| Rear Rear fog lamp not working |1.3.2b| | 1 |
| Front Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 1 |
| Front Bumper insecure (6.1.4 (a) (i)) | 1 |
| Offside Side repeater incorrect colour (4.4.3 (a)) | 1 |
| Supplementary restraint system warning lamp indicates a fault (7.1.6 (a)) | 1 |
| Offside Front Body has a sharp edge caused by damage bumper |6.1.C.1| | 1 |
| Offside Front Drive shaft which forms part of the suspension coupling gaiter insecure to the extent that it no longer prevents the ingress of dirt etc |2.4.G.4e| | 1 |
| Nearside Rear Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Electronic stability system warning lamp indicates a fault |3.4.1c| | 1 |
| Windscreen wiper blade insecure | 1 |
| Rear fog lamp not working |1.3.2b| | 1 |
| Nearside Front Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
| Offside Front Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
| Rear Exhaust system not adequately supported tail pipe |7.1.1| | 1 |
| Nearside Front Brake disc significantly and obviously worn inner face (1.1.14 (a) (i)) | 1 |
| Nearside Front Wheel bearing rough when rotated (5.1.3 (b) (i)) | 1 |
| Offside Side repeater not working |1.4.A.2c| | 1 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Rear Bumper insecure (6.1.4 (a) (i)) | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds default limits (8.2.1.2 (b)) | 1 |
| Rear Exhaust silencer insecure (8.1.1 (b) (i)) | 1 |
| Offside Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 1 |
| Fuel cap/sealing device ineffective seal split |6.1.3 |b| |i|| | 1 |
| Offside Rear Driver`s view of the road through the swept area of the windscreen materially affected by an obstruction sun visor insecure |3.1 |a| |ii|| | 1 |
| Exhaust system insecure front & rear exhaust hangers snapped (6.1.2 (a)) | 1 |
| Nearside Front Battery insecure and likely to cause a short circuit (4.13 (a) (ii)) | 1 |
| Offside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Rear Rear wheel bearing has excessive play |2.6.2| | 1 |
| Offside Rear Rear wheel bearing rough when rotated |2.6.1| | 1 |
| Nearside Rear Rear wheel bearing rough when rotated |2.6.1| | 1 |
| Front Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Emissions unable to be completed major leak (8.2.1.2 (d)) | 1 |
| Nearside Front Coil spring with an unsafe modification scrapping with the body (5.3.1 (d) (i)) | 1 |
| Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt both (2.1.3 (g) (ii)) | 1 |
| Nearside Front Outer Prop shaft joint constant velocity boot no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Offside Rear Exhaust system insecure (6.1.2 (a)) | 1 |
| Front Headlamp has a product on the lens so that the light output is severely reduced both headlamps have no visible beam image due to product on the lenses . (4.1.4 (b)) | 1 |
| Nearside Rear Service brake excessively binding could not check wheel bearing (1.2.1 (f)) | 1 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 1 |
| Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Battery insecure |1.9.1| | 1 |
| Upper Stop lamp not working |1.2.1b| | 1 |
| Nearside Front Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Nearside Front Coil spring fractured or broken (5.3.1 (b) (i)) | 1 |
| Nearside Front Track rod end ball joint has excessive play |2.1.3 |b| |i|| | 1 |
| Offside Front Track rod end ball joint has excessive play |2.1.3 |b| |i|| | 1 |
| Offside Front Coil spring fractured or broken |5.3.1 |b| |i|| | 1 |
| Nearside Rear Service brake excessively binding |1.2.1 |f|| | 1 |
| Offside Rear Coil spring fractured or broken |5.3.1 |b| |i|| | 1 |
| Horn sounds harsh or grating |1.6.2e| | 1 |
| Offside Rear Seat belt webbing significantly weakened (7.1.2 (b) (ii)) | 1 |
| Offside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Offside Front brake disc modified and seriously weakened |3.5.1n| | 1 |
| Nearside Stop lamp not working |1.2.1b| | 1 |
| Offside Front coil spring broken |2.4.C.1a| | 1 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Front Service brake excessively binding (1.2.1 (f)) | 1 |
| Offside Front Service brake excessively binding (1.2.1 (f)) | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength sill (5.3.6 (a) (i)) | 1 |
| Offside Rear Suspension arm fractured (5.3.3 (b) (ii)) | 1 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Stop lamp not working |1.2.1b| | 1 |
| Offside Front Coil spring insecure fouling body (5.3.1 (a) (i)) | 1 |
| Offside Front Position lamp not working |4.2.1 |a|| | 1 |
| Offside Rear Coil spring fractured or broken (5.3.1 (b) (i)) | 1 |
| Nearside Rear Wheel bearing play so excessive it is likely to break up (5.1.3 (a) (ii)) | 1 |
| Offside Rear Wheel bearing has excessive play (5.1.3 (a) (i)) | 1 |
| Offside Rear Suspension arm corroded and seriously weakened (5.3.3 (b) (i)) | 1 |
| Parking brake lever has excessive movement indicating incorrect adjustment (1.1.6 (c)) | 1 |
| Nearside Rear wheel bearing rough when rotated |2.6.1| | 1 |
| Offside Rear wheel bearing has excessive play |2.6.2| | 1 |
| Offside Front Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |