Most common failures | No# failures |
---|
Headlamp aim out of alignment | 19 |
Parking brake: efficiency below requirements |3.7.B.7| | 16 |
Windscreen wiper does not clear the windscreen effectively | 15 |
Rear parking brake recording little or no effort | 14 |
Registration plate issues | 7 |
Brake pipe excessively corroded | 7 |
Registration plate lamp issues | 6 |
Rear brake binding | 6 |
Parking brake efficiency less than 50% of the required value |1.4.2 |a| |ii|| | 4 |
Parking brake: efficiency below requirements |3.7.C.1b| | 4 |
Parking brake lever has no reserve travel |3.1.6b| | 4 |
Rear fog lamp tell tale not working |1.3.1b| | 4 |
Offside Rear fog lamp not working |1.3.2b| | 4 |
Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 3 |
Brakes imbalanced across an axle | 3 |
Nearside Front Direction indicator not working |1.4.A.2c| | 3 |
Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
Nearside Front wheel bearing rough when rotated |2.5.A.2| | 2 |
Offside Front wheel bearing rough when rotated |2.5.A.2| | 2 |
Rear fog lamp not working |1.3.2b| | 2 |
Offside Front position lamp|s| not working |1.1.A.3b| | 2 |
Nearside Front Side repeater not working |1.4.A.2c| | 2 |
Nearside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
Rear Rear fog lamp missing |1.3.2a| | 2 |
Offside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 2 |
Battery insecure |1.9.1| | 2 |
Rear brake application uneven | 2 |
Offside Rear fog lamp missing |1.3.2a| | 2 |
Rear fog lamp switch missing |1.3.1a| | 2 |
Nearside Front Seat belt locking mechanism does not secure or release |5.2.5a| | 2 |
Nearside Headlamp not working on main beam |1.7.5a| | 2 |
Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
Nearside Headlamp aim not tested |1.8.A.1c| | 2 |
Rear fog lamp not working |4.5.1 |a| |ii|| | 2 |
Driver`s seat cannot be secured in the upright position. |6.2.A.2| | 2 |
Nearside Headlamp aim beam image kick up to the offside |1.8| | 2 |
Offside Headlamp aim beam image kick up to the offside |1.8| | 2 |
Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
Nearside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
Nearside Rear Lower Shock absorber has an excessively worn bush |2.7.4| | 1 |
Offside Rear Lower Shock absorber has an excessively worn bush |2.7.4| | 1 |
Service brake: efficiency below requirements |3.7.B.7| | 1 |
Nearside Front All position lamps not working |1.1.A.3b| | 1 |
Nearside Front Upper Suspension arm ball joint excessively worn |5.3.4 |a| |i|| | 1 |
Offside Seat belt anchorage prescribed area strength or continuity significantly reduced outer sill |7.1.1 |a| |i|| | 1 |
Nearside Seat belt anchorage prescribed area strength or continuity significantly reduced outer sill |7.1.1 |a| |i|| | 1 |
Exhaust emissions carbon monoxide content excessive |8.2.1.2 |b|| | 1 |
Nearside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
Front Brake cable has restricted free movement |3.5.1k| | 1 |
Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
Nearside Front Direction indicators not working |1.4.A.2c| | 1 |
Nearside Rear Direction indicators not working |1.4.A.2c| | 1 |
Offside Front Direction indicators not working |1.4.A.2c| | 1 |
Offside Rear Direction indicators not working |1.4.A.2c| | 1 |
Hazard warning tell tale not working correctly |1.4.B.1e| | 1 |
Hazard warning lamps not flashing in phase, with ignition on |1.4.B.1f| | 1 |
Hazard warning lamps not flashing in phase, with ignition off |1.4.B.1f| | 1 |
Nearside Stop lamp not working |1.2.1b| | 1 |
Offside Stop lamp not working |1.2.1b| | 1 |
Steering column locking device insecure |2.1.6| | 1 |
Indicator switch insecure |1.4.A.1| | 1 |
Front Front position lamp|s| incorrect colour |1.1.A.3e| | 1 |
Brake master cylinder fluid level below minimum level |3.6.G.1e| | 1 |
Nearside Rear Upper Coil spring not correctly located |2.4.C.2| | 1 |
Nearside front brake binding |3.7.B.1| | 1 |
Offside Rear Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
Offside Headlamp insecure |1.7.3| | 1 |
Nearside Front Direction indicator not working |4.4.1 |a| |ii|| | 1 |
Nearside Front Seat belt not functioning as intended |7.1.2 |c|| | 1 |
Offside Front Seat belt not functioning as intended |7.1.2 |c|| | 1 |
Nearside Track rod end modification unsafe fouling against wheel |2.1.3 |f| |i|| | 1 |
Offside Track rod end modification unsafe fouling against wheel |2.1.3 |f| |i|| | 1 |
Offside Front Service brake excessively binding |1.2.1 |f|| | 1 |
Nearside Rear Service brake excessively binding |1.2.1 |f|| | 1 |
Front passenger door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
Front passenger door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
Nearside Front position lamp|s| not working |1.1.A.3b| | 1 |
Stop lamp not working |1.2.1b| | 1 |
Nearside Rear Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
Windscreen washer control missing |8.2.1a| | 1 |
Nearside Front Headlamp not working on main beam |1.7.5a| | 1 |
Front Steering damper leaking oil |2.2.C.1f| | 1 |
Nearside Direction indicator flashing less than 60 times a minute |1.4.A.2g| | 1 |
Nearside Front Side repeater adversely affected by the operation of another lamp |1.4.A.2h| | 1 |
Offside Front Side repeater adversely affected by the operation of another lamp |1.4.A.2h| | 1 |
Nearside Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
Offside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
Offside Front Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
Nearside Rear brake caliper leaking flexi pipe to caliper |3.6.A.1| | 1 |
Central Fuel tank leaking |7.2.3| | 1 |
Nearside Rear Lower Suspension arm has excessive play in a pin/bush inner bushes |2.4.G.2| | 1 |
Nearside Rear Parking brake lever inappropriately repaired |3.1.8| | 1 |
Offside Front Steering locking device missing track rod end split pin missing |2.2.C.1g| | 1 |
Offside Rear Rear fog lamp missing |1.3.2a| | 1 |
Nearside Front Front position lamp|s| incorrect colour |1.1.A.3e| | 1 |
Offside Front Front position lamp|s| incorrect colour |1.1.A.3e| | 1 |
Offside Headlamp not working on dipped beam |1.7.5a| | 1 |
Offside Headlamp not working on main beam |1.7.5a| | 1 |
Nearside Front position lamp|s| incorrect colour |1.1.A.3e| | 1 |
Offside Front position lamp|s| incorrect colour |1.1.A.3e| | 1 |
Front rear brakes release unevenly |3.7.B.4| | 1 |
front brakes release unevenly |3.7.B.4| | 1 |
Nearside Headlamp not in good working order |not working| |1.2.4a| | 1 |
Rear Rear fog lamp tell tale not working |1.3.1b| | 1 |
Offside Front Seat belt flexible stalk deteriorated likely to lead to failure under load |5.2.4a| | 1 |
Nearside Front Steering box has relative movement between sector shaft and the drop arm |2.2.B.1b| | 1 |
Nearside Front Lower Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Driver`s seat backrest cannot be secured in the upright position. |6.2.5 |b| |ii|| | 1 |
Parking brake lever defective so that it cannot be satisfactorily operated movement restricted by modified dash |1.1.6 |d|| | 1 |
Offside Front Direction indicator light intensity significantly reduced |4.4.3 |a|| | 1 |
Offside Front Position lamp light intensity significantly reduced |4.2.3 |a| |ii|| | 1 |
Offside Front Position lamp has a product on the lens or light source which significantly reduces light intensity |4.2.3 |b| |ii|| | 1 |
Nearside Front Driver`s seat backrest cannot be secured in the upright position. |6.2.5 |b| |ii|| | 1 |
Offside Front Passenger`s seat backrest cannot be secured in the upright position. |6.2.6 |a| |i|| | 1 |
Offside Rear Seat belt retracting mechanism defective |5.2.5b| | 1 |
Offside Front Passenger`s seat cannot be secured in the upright position. |6.2.A.2| | 1 |
Nearside Front coil spring incomplete |2.4.C.1a| | 1 |
Nearside Rear Exhaust system not adequately supported |7.1.1| | 1 |
Offside Side repeater not working |4.4.1 |a| |ii|| | 1 |
Bonnet cannot be secured in the closed position |3.1 |b| |i|| | 1 |
Offside Rear Rear fog lamp not working |4.5.1 |a| |ii|| | 1 |
Nearside Front Electrical wiring insulation in such a condition there is an imminent risk of fire or formation of sparks under headlamp |4.11 |c| |iii|| | 1 |
Offside Headlamp are incorrectly positioned |4.1.4 |a|| | 1 |
Offside Rear Anti-roll bar linkage rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
Offside Rear fog lamp not working |4.5.1 |a| |ii|| | 1 |
Offside Headlamp has a product on the light source so that the light output is severely reduced |4.1.4 |b|| | 1 |
Windscreen washer not working | 1 |
Front position lamp|s| incorrect colour |1.1.A.3e| | 1 |
Nearside Headlamp does not operate immediately when selected on main beam |1.7.4a| | 1 |
Nearside Headlamp does not operate immediately when selected on dipped beam |1.7.4a| | 1 |
Offside Front coil spring broken |2.4.C.1a| | 1 |
Nearside Front Seat belt anchorage prescribed area is excessively corroded floorpan |5.2.6| | 1 |
Nearside Front Lower Seat belt anchorage prescribed area is excessively corroded sill |5.2.6| | 1 |
Nearside Rear Suspension component mounting prescribed area is excessively corroded inner sill |2.4.A.3| | 1 |
Offside Rear Suspension component mounting prescribed area is excessively corroded inner sill |2.4.A.3| | 1 |
Offside rear brake excessively fluctuating |3.7.B.3| | 1 |
Nearside Driver`s seat cannot be secured in the upright position. |6.2.A.2| | 1 |
Offside Front Anti-roll bar linkage fractured |2.4.G.1| | 1 |
Service brake is causing the vehicle to swerve to the offside |3.7.C.2| | 1 |
Nearside Headlamp insecure |1.7.3| | 1 |
Offside Passenger`s seat cannot be secured in the upright position. |6.2.A.2| | 1 |
Service brake is causing the steering wheel to severely pull one way |3.7.C.2| | 1 |
Offside Front Anti-roll bar linkage rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Front brake application uneven | 1 |
Offside Rear Stop lamp not working |1.2.1b| | 1 |
Rear Exhaust has a part missing |7.1.1a| | 1 |
Offside Front Anti-roll bar severely distorted |2.4.G.1| | 1 |
Emissions not tested |7.0| | 1 |
Nearside Front passenger door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
Offside Rear Lower Suspension arm ball joint excessively worn |5.3.4 |a| |i|| | 1 |
Parking brake lever has excessive movement indicating incorrect adjustment |1.1.6 |c|| | 1 |
Nearside Headlamp aim so that beam "kick up" is not visible on the screen |4.1.2 |a|| | 1 |
Nearside Rear Hydraulic brake cylinder leaking hydraulic fluid |3.6.A.1| | 1 |
Nearside Rear Macpherson strut insecure |2.4.G.1| | 1 |
Nearside Front suspension has a suspension upper ball joint securing nut loose |2.5.B.1a| | 1 |
Offside Rear wheel bearing has excessive play |2.6.2| | 1 |
Offside Front Rear wheel bearing has excessive play |2.6.2| | 1 |
Direction indicators flashing more than 120 times a minute |1.4.A.2g| | 1 |
Nearside Front Seat belt retracting mechanism defective |5.2.5b| | 1 |
Steering column movement between the shaft and steering wheel |2.1.2b| | 1 |
Offside Front Direction indicator not working |1.4.A.2c| | 1 |
Offside Side repeater incorrect colour |1.4.A.2f| | 1 |
Nearside Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 1 |
Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
Bootlid cannot be secured in the closed position |6.4.1| | 1 |
An item not tested |Manual| | 1 |
Nearside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Offside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
Nearside Rear An item not tested |Manual| | 1 |
Offside Rear An item not tested |Manual| | 1 |
Rear Exhaust system not adequately supported |7.1.1| | 1 |
Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
Offside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
Offside Brake cable has restricted free movement |3.5.1k| | 1 |
Nearside Brake cable locking device missing |3.5.1l| | 1 |
Nearside Front Service brake excessively binding (1.2.1 (f)) | 1 |
Parking brake efficiency below requirements (1.4.2 (a) (i)) | 1 |
Nearside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
Offside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
Nearside Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
Offside Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
Bonnet primary retaining device ineffective (3.1 (c)) | 1 |
Nearside Front Service brake excessively fluctuating (1.2.1 (e)) | 1 |
Stop lamp(s) all not working (4.3.1 (a) (iii)) | 1 |
Nearside Front Seat belt anchorage loose (7.1.1 (b)) | 1 |