Most common failures | No# failures |
---|
Registration plate lamp issues | 29 |
Brake pipe excessively corroded | 27 |
Rear brake binding | 15 |
Headlamp aim out of alignment | 13 |
Windscreen wiper does not clear the windscreen effectively | 12 |
Nearside Rear Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 10 |
Offside Rear Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 10 |
Registration plate issues | 6 |
Rear parking brake recording little or no effort | 6 |
Nearside Front position lamp|s| not working |1.1.A.3b| | 5 |
Parking brake: efficiency below requirements |3.7.B.7| | 5 |
Nearside Stop lamp not working |1.2.1b| | 4 |
Windscreen washer not working | 4 |
Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 4 |
Offside Front position lamp|s| not working |1.1.A.3b| | 3 |
Offside Stop lamp not working |1.2.1b| | 3 |
Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
Offside Track rod end ball joint has excessive play |2.2.B.1f| | 3 |
Offside Front Position lamp not working (4.2.1 (a) (ii)) | 3 |
Mechanical brake component has restricted free movement | 3 |
Exhaust system not adequately supported |7.1.1| | 3 |
Nearside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 3 |
Driver`s seat insecure |6.2.A.1| | 2 |
Brakes imbalanced across an axle | 2 |
Offside Front Front position lamp|s| not working |1.1.A.3b| | 2 |
Parking brake: efficiency below requirements |3.7.C.1b| | 2 |
Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
Rear fog lamp not working |1.3.2b| | 2 |
Rear Exhaust system not adequately supported |7.1.1| | 2 |
Rear Mechanical brake component has restricted free movement | 2 |
Nearside Front Shock absorber has an excessively worn bush |2.7.4| | 2 |
Offside Front Shock absorber has an excessively worn bush |2.7.4| | 2 |
Nearside Rear Leaf spring has a deteriorated shackle pin rubber bush resulting in excessive movement |2.4.B.2| | 2 |
Offside Rear Leaf spring has a deteriorated shackle pin rubber bush resulting in excessive movement |2.4.B.2| | 2 |
Exhaust emits an excessive level of metered smoke for a turbo charged engine |7.4.B.3b| | 2 |
Anti-lock braking system warning lamp indicates an ABS fault | 2 |
Parking brake lever has no reserve travel |3.1.6b| | 2 |
Front brake disc in such a condition that it is seriously weakened | 2 |
Nearside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 2 |
Offside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 2 |
Offside Rear Brake hose leaking on a hydraulic braking system pipe |1.1.12 |c| |ii|| | 1 |
Brake performance not tested system leaking |1.2.1 |g|| | 1 |
Nearside Front Upper Anti-roll bar attachment bracket/mounting insecure (5.3.3 (a) (i)) | 1 |
Nearside Rear Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
Nearside Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
Direction indicators not working |1.4.A.2c| | 1 |
Central Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
Offside Front brake caliper has restricted free movement binding |3.5.1k| | 1 |
Offside Rear Direction indicators incorrect colour |1.4.A.2f| | 1 |
Nearside front brake binding |3.7.B.1| | 1 |
Rear Brake pipe inadequately clipped on axle |3.6.B.1| | 1 |
Rear Exhaust has a major leak of exhaust gases silencer |7.1.2| | 1 |
Stop lamp not working both |1.2.1b| | 1 |
Main beam `tell-tale` not working |1.7.4c| | 1 |
Offside Front Fuel pipe insecure (6.1.3 (a) (i)) | 1 |
Nearside Rear Leaf spring cracked |2.4.B.1a| | 1 |
Offside Rear Leaf spring cracked |2.4.B.1a| | 1 |
Offside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
Nearside Front Brake hose excessively twisted (1.1.12 (b) (ii)) | 1 |
Offside Front Track rod end ball joint has excessive play |2.1.3 |b| |i|| | 1 |
Rear fog lamp tell tale not working |1.3.1b| | 1 |
Nearside Rear position lamp|s| not working |1.1.A.3b| | 1 |
Central Stop lamp not working |1.2.1b| | 1 |
Battery insecure |1.9.1| | 1 |
Nearside Rear Direction indicator incorrect colour |4.4.3 |a|| | 1 |
Rear Leaf spring cracked |2.4.B.1a| | 1 |
Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
Offside Rear Rear fog lamp does not emit a steady red light (4.5.4 (a)) | 1 |
Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength Cross member (5.3.6 (a) (i)) | 1 |
Nearside Outer Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Offside Outer Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Nearside Rear Body has a sharp edge caused by damage |6.1.C.1| | 1 |
Offside Rear Service brake lagging in operation (1.2.1 (d)) | 1 |
Rear Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced cross member (6.1.1 (c) (i)) | 1 |
Windscreen wiper not working (3.4 (a)) | 1 |
Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
Front Shock absorber has negligible damping effect |2.7.5| | 1 |
Rear Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 1 |
Nearside Front Position lamp not working |4.2.1 |a|| | 1 |
Offside Front Position lamp not working |4.2.1 |a|| | 1 |
Rear Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
Power steering inoperative and steering adversely affected (2.1.5 (c) (ii)) | 1 |
Nearside Rear position lamp|s| incorrect colour |1.1.A.3e| | 1 |
Nearside Stop lamp emits other than a steady red light |1.2.1e| | 1 |
Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
Nearside Seat belt anchorage prescribed area strength or continuity significantly reduced sill (7.1.1 (a) (i)) | 1 |
Offside Seat belt anchorage prescribed area strength or continuity significantly reduced sill (7.1.1 (a) (i)) | 1 |
Rear Exhaust system insecure rear hanger (6.1.2 (a)) | 1 |
Nearside Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced (6.1.1 (c) (i)) | 1 |
Central Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced cross member (6.1.1 (c) (i)) | 1 |
Nearside Rear Stop lamp|s| showing white light to the rear |4.3.3 |a| |ii|| | 1 |
Nearside Rear Shock absorbers has a serious fluid leak | 1 |
Offside Rear Shock absorbers has a serious fluid leak | 1 |
Boot lid damaged and likely to cause injury |6.2.1 |a| |i|| | 1 |
Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength |5.3.6 |a| |i|| | 1 |
Nearside Service brake is causing the vehicle to swerve to the offside |1.2.1 |b| |i|| | 1 |
Nearside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Nearside Rear Leaf spring shackle pin or bush excessively worn rear (5.3.4 (a) (i)) | 1 |
Offside Rear Leaf spring shackle pin or bush excessively worn rear (5.3.4 (a) (i)) | 1 |
Offside Rear Suspension spring mounting prescribed area is excessively corroded by rear leaf spring mount |2.4.A.3| | 1 |
Offside Inner Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced body mounting (6.1.1 (c) (i)) | 1 |
Nearside Front Lower Shock absorber has an excessively worn shock absorber pivot |2.7.4| | 1 |
Offside Rear Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting (6.2.2 (d) (i)) | 1 |
Nearside Rear Cab or chassis has excessive corrosion, seriously affecting its strength within 30cm of a cab mounting (6.2.2 (d) (i)) | 1 |
Offside Front Floor excessively deteriorated (6.2.4 (a) (i)) | 1 |
Service brake efficiency below requirements (1.2.2 (a) (i)) | 1 |
Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Nearside Front Lower Shock absorber has an excessively worn bush |2.7.4| | 1 |
Offside Front Lower Shock absorber has an excessively worn bush |2.7.4| | 1 |
Offside Rear Stop lamp not working |1.2.1b| | 1 |
Nearside Front Steering lock stop damaged |2.2.D.2c| | 1 |
Offside Front Steering lock stop damaged |2.2.D.2c| | 1 |
Nearside Front Steering system has a road wheel fouling a part of the vehicle |2.2.D.2a| | 1 |
Nearside Front Driver`s seat insecure |6.2.A.1| | 1 |
Nearside Rear position lamp|s| incomplete |1.1.4a| | 1 |
Nearside Steering lock stop fractured and unserviceable |2.2.C.1d| | 1 |
Nearside Rear Stop lamp not working |1.2.1b| | 1 |
Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
Nearside Headlamp not working on dipped beam |1.7.5a| | 1 |
Nearside Ball joint has excessive play |2.2.B.1f| | 1 |
Nearside Front Steering lock stop damaged and unserviceable |2.2.C.1d| | 1 |
Nearside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
Nearside Front Upper Shock absorber detached |2.7.2b| | 1 |
Nearside Front Inner Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
Offside Front Upper Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
Offside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
Nearside Front Power steering pipe|s| or hose|s| leaking |2.3.3b| | 1 |
Nearside Front Suspension arm attachment bracket/mounting insecure |2.4.G.1| | 1 |
Nearside Ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
Exhaust tailpipe not capable of allowing the emission probe to be inserted |7.4.B.1| | 1 |
Offside Rear Lower Leaf spring eye defective |shackle| |2.4.B.1b| | 1 |
Towbar locking device inadequate |6.6.3b| | 1 |
Power steering pipe|s| or hose|s| leaking from a joint |2.3.3b| | 1 |
Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 1 |
Steering system excessively rough |2.2.D.1| | 1 |
Nearside Front Body has a sharp edge caused by damage wheel arch missing |6.1.C.1| | 1 |
Fuel system component leaking fuel lines alongside tank |7.2.3| | 1 |
Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
Offside Front Lower Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
Nearside Rear Suspension spring mounting prescribed area is excessively corroded rear crossmember |2.4.A.3| | 1 |
Offside Rear Suspension spring mounting prescribed area is excessively corroded rear crossmember |2.4.A.3| | 1 |
Centre Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings centre cross member near fuel tank mounting |6.1.B.2| | 1 |
Rear brake application uneven | 1 |
Offside Rear reflector excessively damaged so that its function is impaired |1.5.1c| | 1 |
Offside Inner Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings sill |6.1.B.2| | 1 |
Nearside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings cross member |6.1.B.2| | 1 |
Offside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings cross member |6.1.B.2| | 1 |
Rear fog lamp emits a light other than red |1.3.2e| | 1 |
Offside Rear position lamp|s| excessively damaged so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
Speedometer cannot be illuminated. |6.7.3| | 1 |
Front Exhaust system not adequately supported |7.1.1| | 1 |
Exhaust emits excessive smoke or vapour of any colour |7.4.B.4| | 1 |
Rear Brake cable has a seized clevis joint pivot s |3.5.1c| | 1 |
Offside Rear Rear reflector excessively damaged so that its function is impaired |1.5.1c| | 1 |
Offside Rear rear brake excessively fluctuating |3.7.B.3| | 1 |
Nearside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
Offside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
Nearside Front Exhaust system not adequately supported |7.1.1| | 1 |
Nearside Rear Exhaust system not adequately supported |7.1.1| | 1 |
Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
Offside Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting Hole in chassis marked with yellow chalk (6.2.2 (d) (i)) | 1 |
Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
Offside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
Rear fog lamp adversely affected by the operation of another lamp REAR FOG NOT WORKING, REVERSE LIGHT COMES ON WHEN REAR FOG SELECTED (4.5.4 (b)) | 1 |
Headlamp aim not tested (4.1.2 (b)) | 1 |
Battery insecure and likely to cause a short circuit (4.13 (a) (ii)) | 1 |
Nearside Front Suspension arm ball joint excessively worn lower swivel (5.3.4 (a) (i)) | 1 |
Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Offside Rear fog lamp not working |1.3.2b| | 1 |
Centre Exhaust system not adequately supported |7.1.1| | 1 |
Windscreen wiper blade insecure | 1 |