| Most common failures | No# failures |
|---|
| Brake pipe excessively corroded | 65 |
| Registration plate lamp issues | 39 |
| Headlamp aim out of alignment | 30 |
| Windscreen wiper does not clear the windscreen effectively | 30 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 18 |
| Rear brake application uneven | 18 |
| Rear brake binding | 18 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 16 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 14 |
| Rear parking brake recording little or no effort | 11 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 10 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 10 |
| Registration plate issues | 9 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 8 |
| Nearside Rear Leaf spring fractured |2.4.B.1a| | 8 |
| Parking brake: efficiency below requirements |3.7.B.7| | 8 |
| Brakes imbalanced across an axle | 7 |
| Exhaust system not adequately supported |7.1.1| | 7 |
| Horn not working |1.6.2a| | 7 |
| rear brakes release unevenly |3.7.B.4| | 5 |
| Front Exhaust system not adequately supported |7.1.1| | 5 |
| Front passenger seat cannot be secured in the upright position. |6.2.4| | 4 |
| Offside Rear Leaf spring fractured |2.4.B.1a| | 4 |
| Windscreen has damage | 4 |
| Centre Exhaust system not adequately supported |7.1.1| | 4 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 4 |
| Offside Side repeater not working |1.4.A.2c| | 4 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 4 |
| Exhaust has part of the system excessively deteriorated |7.1.1a| | 3 |
| Parking brake lever has no reserve travel |3.1.6b| | 3 |
| Offside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
| Front brake application uneven | 3 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 3 |
| Offside Rear Wheel nut|s| missing |4.2.A.1e| | 3 |
| Rear Exhaust has a part missing |7.1.1a| | 3 |
| Offside front brake binding |3.7.B.1| | 3 |
| Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 3 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 3 |
| Nearside Rear rear brake grabbing severely |3.7.A.5b| | 2 |
| Offside Rear Leaf spring cracked |2.4.B.1a| | 2 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 2 |
| Nearside Front passenger seat cannot be secured in the upright position. |6.2.4| | 2 |
| Nearside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 2 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 2 |
| Offside Front Seat belt damaged sufficient to obstruct correct operation of the belt |5.2.2a| | 2 |
| Offside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Offside Front brake disc excessively pitted |3.5.1h| | 2 |
| Nearside Rear wheel bearing has excessive play |2.6.2| | 2 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 2 |
| Nearside Front Passenger`s seat cannot be secured in the upright position. |6.2.A.2| | 2 |
| Spare wheel carrier insecure |6.4.2| | 2 |
| Offside Rear Rear position lamp|s| incomplete |1.1.4a| | 2 |
| Nearside Rear Direction indicator incorrect colour |1.4.A.2f| | 2 |
| Offside Rear Direction indicator incorrect colour |1.4.A.2f| | 2 |
| Brake pedal anti-slip provision missing |3.3.A.1b| | 2 |
| Offside Front wheel bearing has excessive play |2.5.A.3c| | 2 |
| Offside Rear Shock absorber has a serious fluid leak |2.7.3| | 2 |
| Nearside Rear position lamp|s| incomplete |1.1.4a| | 2 |
| Nearside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 2 |
| Exhaust tailpipe not capable of allowing the emission probe to be inserted |7.3.D.1| | 2 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 2 |
| Offside Rear fog lamp not working |1.3.2b| | 2 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Rear Mechanical brake component has restricted free movement | 2 |
| Nearside Rear Leaf spring cracked |2.4.B.1a| | 2 |
| Nearside front brake binding |3.7.B.1| | 2 |
| Offside Front Wheel nut|s| missing |4.2.A.1e| | 2 |
| Nearside Rear Leaf spring has a deteriorated shackle pin rubber bush resulting in excessive movement |2.4.B.2| | 2 |
| Nearside Front Wheel nut|s| loose |4.2.A.1e| | 2 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 2 |
| Front brake disc in such a condition that it is seriously weakened | 2 |
| Exhaust carbon monoxide content at idle exceeds default limits (8.2.1.2 (b)) | 2 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 2 |
| Nearside Front Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt (2.2.C.1c) | 2 |
| Offside Front Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt (2.2.C.1c) | 2 |
| Nearside Stop lamp not working |1.2.1b| | 1 |
| Offside Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 1 |
| Offside Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Fuel system component leaking |7.2.3| | 1 |
| Nearside Rear Direction indicator incomplete |1.5.A1b| | 1 |
| Nearside Rear Stop lamp not working |1.2.1b| | 1 |
| Nearside Rear Leaf spring has excessive wear in an anchor pin and/or bush |2.4.B.2| | 1 |
| Offside Rear rear brake juddering severely |3.7.A.5b| | 1 |
| Nearside Rear Body has a sharp edge caused by damage |6.1.C.1| | 1 |
| Headlamp switch faulty |1.7.1| | 1 |
| Offside Steering rack gaiter split |2.2.D.2d| | 1 |
| Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Rear An item not tested |Manual| | 1 |
| Offside Front Anti-roll bar linkage insecure |2.4.G.1| | 1 |
| Nearside Rear Exhaust mounting missing |7.1.1b| | 1 |
| front brake binding |3.7.B.1| | 1 |
| Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Fuel tank leaking |7.2.3| | 1 |
| Offside Rear wheel bearing has excessive play |2.6.2| | 1 |
| Offside Front Anti-roll bar attachment bracket/mounting insecure |2.4.G.1| | 1 |
| Nearside Front Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Front Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Nearside Front Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Front Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Nearside rear brakes release unevenly |3.7.B.4| | 1 |
| Nearside Rear Rear position lamp|s| incomplete |1.1.4a| | 1 |
| An item not tested |Manual| | 1 |
| Offside Front Headlamp not working on main beam |1.7.5a| | 1 |
| Nearside Rear Rear wheel bearing has excessive play |2.6.2| | 1 |
| Offside Rear Rear wheel bearing has excessive play |2.6.2| | 1 |
| Offside Front Wheel stud|s| missing |4.2.A.1e| | 1 |
| Offside Leaf spring fractured |2.4.B.1a| | 1 |
| Rear Exhaust mounting missing |7.1.1b| | 1 |
| Nearside Front Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
| Rear wheel bearing has excessive play |2.6.2| | 1 |
| Nearside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Brake hydraulic reservoir fluid level below minimum level |3.6.G.1b| | 1 |
| Nearside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Rear position lamp|s| insecure |1.1.A.3a| | 1 |
| Nearside Front Upper Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Lower Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Seat belt damaged sufficient to obstruct correct operation of the belt |5.2.2a| | 1 |
| Nearside Front Direction indicator incomplete |1.5.A1b| | 1 |
| Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Front Front position lamp|s| obviously incorrectly positioned |1.1.A.3a| | 1 |
| Nearside Rear Leaf spring damaged and permanently distorted |2.4.B.1a| | 1 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Front Side repeater not working |1.4.A.2c| | 1 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Rear Direction indicator excessively damaged so that it is not visible from a reasonable distance |1.4.A.2e| | 1 |
| Nearside Front Anti-roll bar linkage rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Rear reflector missing |1.5.1a| | 1 |
| Offside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Offside Front Anti-roll bar attachment bracket/mounting bolt missing |2.4.G.1| | 1 |
| Spare wheel insecure |6.4.2| | 1 |
| Nearside Rear reflector missing |1.5.1a| | 1 |
| Offside Front Brake pedal pad not secure to the pedal |3.3.A.1c| | 1 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Rear Shock absorber insecure |2.7.2b| | 1 |
| Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Centre Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Windscreen wiper blade insecure | 1 |
| Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Offside Stop lamp not working |1.2.1b| | 1 |
| Nearside Seat belt damaged sufficient to obstruct correct operation of the belt |5.2.2a| | 1 |
| Offside Front Seat belt damaged sufficient to significantly weakened the webbing |5.2.2a| | 1 |
| Nearside Front Headlamp not working on main beam |1.7.5a| | 1 |
| Rear Exhaust system not adequately supported |7.1.1| | 1 |
| Offside Front brake disc excessively scored |3.5.1h| | 1 |
| Nearside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Bootlid cannot be secured in the closed position |6.4.1| | 1 |
| Offside Rear reflector insecure |1.5.1a| | 1 |
| Nearside Front Anti-roll bar linkage fractured |2.4.G.1| | 1 |
| Offside Obligatory mirror missing |8.1.1| | 1 |
| Offside Rear Body has a sharp edge caused by damage |6.1.C.1| | 1 |
| Offside Rear Rear position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Nearside Rear Shock absorber has negligible damping effect |2.7.5| | 1 |
| Offside Rear Shock absorber has negligible damping effect |2.7.5| | 1 |
| rear brake grabbing severely |3.7.A.5b| | 1 |
| brake drum in such a condition that it is seriously weakened |3.5.1i| | 1 |
| Offside Rear Leaf spring has a deteriorated shackle pin rubber bush resulting in excessive movement |2.4.B.2| | 1 |
| Front Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Offside Rear fog lamp emits a light other than red |1.3.2e| | 1 |
| Front Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Nearside Rear Wheel stud|s| missing |4.2.A.1e| | 1 |
| Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Exhaust has a part missing |7.1.1a| | 1 |
| Nearside Rear fog lamp excessively deteriorated so that it is not visible from a reasonable distance |1.3.2d| | 1 |
| Emissions not tested |7.0| | 1 |
| Centre An item not tested |Manual| | 1 |
| Offside Rear position lamp|s| insecure |1.1.A.3a| | 1 |
| Nearside Stop lamp emits other than a steady red light |1.2.1e| | 1 |
| Nearside Rear position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Offside Front Steering component mounting prescribed area is excessively corroded |2.2.C.1h| | 1 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Rear Stop lamp not working |1.2.1b| | 1 |
| Nearside Rear Rear position lamp|s| insecure |1.1.A.3a| | 1 |
| Nearside Front Exhaust system not adequately supported |7.1.1| | 1 |
| Rear fog lamp lens defective such that emitted light is adversely affected |4.5.1 |b| |ii|| | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds default limits |8.2.1.2 |b|| | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively damaged significantly reducing structural strength spring mounting |5.3.6 |a| |i|| | 1 |
| Offside Rear Body panel corroded and likely to cause injury |6.2.1 |a| |i|| | 1 |
| Nearside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Front Upper Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Centre Statutory seat belt missing |5.1.1| | 1 |
| Nearside Rear passenger door cannot be opened from outside the vehicle |6.2.B.1c| | 1 |
| Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Front Seat belt retracting mechanism defective |5.2.5b| | 1 |
| Offside Headlamp aim not tested |1.8.A.1c| | 1 |
| Front passenger seat insecure |6.2.3| | 1 |
| Fuel hose leaking |7.2.3| | 1 |
| Offside Rear Brake cable has a seized clevis joint pivot |3.5.1c| | 1 |
| Nearside Front Wheel nut|s| missing |4.2.A.1e| | 1 |
| Offside Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
| Fuel system component insecure |7.2.1| | 1 |
| Nearside rear brake grabbing severely |3.7.A.5b| | 1 |
| Offside rear brake grabbing severely |3.7.A.5b| | 1 |
| Offside Front Anti-roll bar linkage fractured |2.4.G.1| | 1 |
| Nearside Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Nearside Front brake disc excessively pitted |3.5.1h| | 1 |
| Offside brake disc excessively pitted |3.5.1h| | 1 |
| Nearside Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Offside Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Nearside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Offside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Nearside Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Offside Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 1 |
| Offside Front Seat belt anchorage prescribed area strength or continuity significantly reduced (7.1.1 (a) (i)) | 1 |
| Nearside Rear Suspension spring mounting prescribed area excessively corroded significantly reducing structural strength outer sill area (5.3.6 (a) (i)) | 1 |
| Offside Rear Suspension spring mounting prescribed area excessively corroded significantly reducing structural strength outer sill area (5.3.6 (a) (i)) | 1 |
| Offside Rear Suspension spring mounting prescribed area excessively corroded significantly reducing structural strength inner sill area (5.3.6 (a) (i)) | 1 |
| Nearside Rear Suspension spring mounting prescribed area excessively corroded significantly reducing structural strength inner sill area (5.3.6 (a) (i)) | 1 |
| Offside Rear Suspension spring mounting prescribed area excessively corroded significantly reducing structural strength forward area (5.3.6 (a) (i)) | 1 |
| Nearside Rear Suspension spring mounting prescribed area excessively corroded significantly reducing structural strength rear area (5.3.6 (a) (i)) | 1 |
| Offside Rear Suspension spring mounting prescribed area excessively corroded significantly reducing structural strength rear area (5.3.6 (a) (i)) | 1 |
| Horn not working (7.7 (a) (ii)) | 1 |
| Rear Brake pipe at imminent risk of failure or fracture load valve to rear flexible (1.1.11 (a)) | 1 |
| Power steering component leaking (2.1.5 (a)) | 1 |
| Offside Front Cab or chassis has excessive corrosion, seriously affecting its strength within 30cm of a cab mounting underwing (6.2.2 (d) (i)) | 1 |
| Brake performance not tested Leaking brake fluid (1.2.1 (g)) | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds default limits (8.2.1.2 (b)) | 1 |
| Exhaust hydrocarbon content after 2nd fast idle exceeds default limits (8.2.1.2 (b)) | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds manufacturers specified limits (8.2.1.2 (a)) | 1 |
| Exhaust carbon monoxide content at idle exceeds manufacturers specified limits (8.2.1.2 (b)) | 1 |
| Offside Rear fog lamp missing (1.3.2a) | 1 |
| Centre Stop lamp not working (1.2.1b) | 1 |
| Central Exhaust has a major leak of exhaust gases flexi (6.1.2 (a)) | 1 |
| Nearside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt insecure (5.3.4 (b) (ii)) | 1 |
| Offside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt insecure (5.3.4 (b) (ii)) | 1 |
| Nearside Front Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Nearside Headlamp aim beam image obviously incorrect (1.8.A.1b) | 1 |
| Offside Headlamp aim beam image obviously incorrect (1.8.A.1b) | 1 |
| Trailer electrical socket (13 pin) not operating the trailer lamps as intended (1.9.4) | 1 |
| Nearside Front Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt (2.4.G.2) | 1 |
| Offside Front Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt (2.4.G.2) | 1 |
| Offside Front Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt (2.2.C.1c) | 1 |
| Nearside Front Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt (2.4.G.2) | 1 |
| Offside Front Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt (2.4.G.2) | 1 |
| Nearside Front Front suspension ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt (2.4.G.2) | 1 |
| Offside Front Front suspension ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt (2.4.G.2) | 1 |
| Offside Front position lamp(s) not working (1.1.A.3b) | 1 |
| Nearside Front Front suspension ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt bbj (2.4.G.2) | 1 |
| Offside Front Front suspension ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt bbj (2.4.G.2) | 1 |
| Central Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Offside Front Seat belt stitching badly frayed (5.2.2b) | 1 |
| Nearside Front Road wheel bead rim badly distorted (4.2.A.1a) | 1 |
| Nearside Steering rack gaiter split (2.2.D.2d) | 1 |
| Nearside Front Shock absorbers has a serious fluid leak | 1 |
| Rear fog lamp missing (1.3.2a) | 1 |
| Rear fog lamp switch missing (1.3.1a) | 1 |
| Offside Rear Suspension component mounting prescribed area is corroded to the extent that control of the vehicle is likely to be adversely affected (5.3.6 (a) (ii)) | 1 |
| Nearside Rear Suspension spring mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Offside Rear Suspension spring mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Offside Rear Outer Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Nearside Front Anti-roll bar pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Anti-roll bar pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced (6.1.1 (c) (i)) | 1 |
| Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Fuel cap/sealing device ineffective (6.1.3 (b) (i)) | 1 |
| Offside Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Anti-lock braking system warning lamp indicates an ABS fault | 1 |
| Offside Front Upper Anti-roll bar ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |