| Most common failures | No# failures |
|---|
| Brake pipe excessively corroded | 20 |
| Headlamp aim out of alignment | 16 |
| Windscreen wiper does not clear the windscreen effectively | 13 |
| Parking brake: efficiency below requirements |3.7.B.7| | 10 |
| Rear brake binding | 9 |
| Registration plate issues | 8 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 7 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 7 |
| Parking brake lever has no reserve travel |3.1.6b| | 6 |
| Brake hose excessively deteriorated | 6 |
| Nearside Side repeater not working |1.4.A.2c| | 5 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 5 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 5 |
| Brakes imbalanced across an axle | 4 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 4 |
| Offside Side repeater not working |1.4.A.2c| | 4 |
| Rear parking brake recording little or no effort | 4 |
| Offside Headlamp aim beam image kick up to the offside |1.8| | 3 |
| Nearside Stop lamp not working |1.2.1b| | 3 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 3 |
| Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 3 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 3 |
| Offside Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 3 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
| Nearside Headlamp aim beam image kick up to the offside |1.8| | 2 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Nearside Headlamp insecure |1.7.3| | 2 |
| Offside front brake binding |3.7.B.1| | 2 |
| Offside Rear fog lamp not working |1.3.2b| | 2 |
| Rear fog lamp tell tale not working |1.3.1b| | 2 |
| Nearside Front Shock absorber has a serious fluid leak |2.7.3| | 2 |
| Anti-lock braking system warning lamp indicates an ABS fault | 2 |
| Nearside Front Headlamp insecure |1.7.3| | 2 |
| Horn not working |1.6.2a| | 2 |
| Rear fog lamp not working |1.3.2b| | 2 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 2 |
| Nearside Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 2 |
| Registration plate lamp issues | 2 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds default limits (8.2.1.2 (b)) | 2 |
| Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 2 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 2 |
| Nearside Headlamp not working on main beam |1.7.5a| | 2 |
| Offside Stop lamp not working |1.2.1b| | 2 |
| Rear Mechanical brake component has restricted free movement | 2 |
| Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Offside Rear Position lamp not working Unit on drivers rear lower quarter inoperative (4.2.1 (a) (ii)) | 1 |
| Emissions not tested |7.0| | 1 |
| Nearside Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Offside Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Nearside Front Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Offside Front Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Offside Rear fog lamp insecure |1.3.2a| | 1 |
| Offside Side repeater incorrect colour |1.4.A.2f| | 1 |
| Offside Rear passenger door does not latch securely closed |6.2.B.1a| | 1 |
| Offside Rear Rear fog lamp missing |1.3.2a| | 1 |
| Nearside Rear Stop lamp not working |1.2.1b| | 1 |
| Nearside Rear Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Nearside Front Ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Exhaust emissions hydrocarbon content after 2nd fast idle excessive |7.3.D.3| | 1 |
| Offside Outer Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Rear brake disc excessively pitted |3.5.1h| | 1 |
| Nearside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Nearside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Rear brake disc in such a condition that it is seriously weakened | 1 |
| Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
| Nearside Front Anti-roll bar linkage ball joint dust cover missing (5.3.4 (b) (ii)) | 1 |
| Offside Front Anti-roll bar linkage ball joint dust cover missing (5.3.4 (b) (ii)) | 1 |
| Nearside Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Offside Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Front Anti-roll bar ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Seat belt retracting mechanism defective |5.2.5b| | 1 |
| An item not tested |Manual| | 1 |
| Nearside Front Brake load sensing valve linkage defective and function impaired |3.6.E.3| | 1 |
| Offside Front Brake load sensing valve linkage defective and function impaired |3.6.E.3| | 1 |
| Battery insecure refitted and secured |1.9.1| | 1 |
| Nearside Rear Electrical wiring inadequately supported |1.9.2a| | 1 |
| Offside Rear Electrical wiring inadequately supported |1.9.2a| | 1 |
| Rear fog lamp obviously incorrectly positioned |4.5.4 |a|| | 1 |
| Rear fog lamp not working |4.5.1 |a| |ii|| | 1 |
| Nearside Front Anti-roll bar linkage insecurely attached |5.3.3 |a| |i|| | 1 |
| Offside Front Anti-roll bar linkage insecurely attached |5.3.3 |a| |i|| | 1 |
| Nearside Rear Inner Anti-roll bar has excessive play in a pin/bush D bush |2.4.G.2| | 1 |
| Offside Rear Inner Anti-roll bar has excessive play in a pin/bush D bush |2.4.G.2| | 1 |
| Nearside Front Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Rear fog lamp switch insecure |1.3.1a| | 1 |
| Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 1 |
| Emissions not tested car over heating (8.2.1.2 (d)) | 1 |
| Offside Direction indicators flashing more than 120 times a minute |1.4.A.2g| | 1 |
| Direction indicators not working |1.4.A.2c| | 1 |
| Hazard warning lamps not flashing in phase, with ignition on |1.4.B.1f| | 1 |
| Hazard warning lamps not flashing in phase, with ignition off |1.4.B.1f| | 1 |
| Indicator tell tale inoperative |1.4.A.2a| | 1 |
| Hazard warning tell tale not working correctly |1.4.B.1e| | 1 |
| Brake cable has wires broken and is significantly weakened release cable |3.5.1b| | 1 |
| Hazard warning switch faulty |1.4.B.1d| | 1 |
| Nearside Front Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Offside Front Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Nearside Rear Seat belt locking mechanism does not secure or release center row |5.2.5a| | 1 |
| Offside Rear Seat belt locking mechanism does not secure or release center row |5.2.5a| | 1 |
| Nearside Front Braking system leaking |3.6.A.1| | 1 |
| Brake fluid warning lamp illuminated |3.6.G.2| | 1 |
| Nearside Front Brake pipe leaking |3.6.A.1| | 1 |
| Front brake excessively fluctuating | 1 |
| Front Steering damper leaking oil |2.2.C.1f| | 1 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 1 |
| Nearside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Offside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Nearside Front Steering system has excessive free play detected at the steering wheel |steering box fitted| |2.2.A.1a| | 1 |
| Offside Headlamp not working on main beam |1.7.5a| | 1 |
| Rear fog lamp insecure |1.3.2a| | 1 |
| Nearside front brake binding |3.7.B.1| | 1 |
| Centre Front Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Nearside Rear Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 1 |
| Nearside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Direction indicators flashing more than 120 times a minute |1.4.A.2g| | 1 |
| Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Offside Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
| Nearside Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
| Front Direction indicators incorrect colour |1.4.A.2f| | 1 |
| Nearside Front brake caliper has restricted free movement |3.5.1k| | 1 |
| Brake performance not tested |3.7.A.1| | 1 |
| Service brake: efficiency below requirements |3.7.B.7| | 1 |
| Windscreen washer not working | 1 |
| Offside Headlamp aim projected beam image is obviously incorrect |4.1.2 |c|| | 1 |
| Fuel cap/sealing device ineffective |6.1.3 |b| |i|| | 1 |
| Nearside Front Lower Suspension arm rubber bush bonding deteriorated resulting in excessive movement Rear bush |2.4.G.2| | 1 |
| Offside Front Lower Suspension arm rubber bush bonding deteriorated resulting in excessive movement Rear bush |2.4.G.2| | 1 |
| Offside Front front brake binding |3.7.B.1| | 1 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Mechanical brake component has restricted free movement | 1 |
| Battery insecure |1.9.1| | 1 |
| Nearside Rear Brake pipe inadequately clipped |3.6.B.1| | 1 |
| Front brake disc excessively pitted |3.5.1h| | 1 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front Steering pivot point has excessive play |2.2.B.1g| | 1 |
| Nearside Front Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
| Nearside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Centre Stop lamp not working |1.2.1b| | 1 |
| Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Nearside Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Windscreen has a sticker or other obstruction encroaching by more than 10mm within zone `A` |8.3.1b| | 1 |
| Rear fog lamp emits a light other than red |1.3.2e| | 1 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Fuel tank leaking (6.1.3 (b) (i)) | 1 |
| Offside Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Brake hose has insufficient room to move | 1 |