Most common failures | No# failures |
---|
Headlamp aim out of alignment | 21 |
Registration plate issues | 17 |
Windscreen wiper does not clear the windscreen effectively | 14 |
Parking brake: efficiency below requirements |3.7.B.7| | 9 |
Registration plate lamp issues | 7 |
Horn not working |1.6.2a| | 6 |
Rear parking brake recording little or no effort | 5 |
Brakes imbalanced across an axle | 4 |
Nearside Headlamp aim beam image kick up to the offside |1.8| | 4 |
Nearside Headlamp not working on dipped beam |1.7.5a| | 4 |
Parking brake lever has no reserve travel |3.1.6b| | 4 |
Offside Headlamp aim beam image kick up to the offside |1.8| | 3 |
Front Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
Nearside Front Headlamp not working on dipped beam |1.7.5a| | 3 |
Offside Front coil spring incomplete |2.4.C.1a| | 3 |
Rear brake application uneven | 3 |
Rear Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
Brake hose excessively deteriorated | 2 |
Nearside Front Headlamp aim beam image kick up to the offside |1.8| | 2 |
Offside Front Headlamp aim beam image kick up to the offside |1.8| | 2 |
Power steering inoperative |2.3.3a| | 2 |
Brake hose damaged | 2 |
Offside Front position lamp|s| not working |1.1.A.3b| | 2 |
Offside Front constant velocity joint gaiter split |2.5.C.1a| | 2 |
Nearside Front coil spring incomplete |2.4.C.1a| | 2 |
Offside Headlamp not working on dipped beam |1.7.5a| | 2 |
Nearside Rear position lamp|s| not working |1.1.A.3b| | 2 |
Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 2 |
Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
Nearside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 2 |
Nearside Rear Shock absorber has a serious fluid leak |2.7.3| | 2 |
Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
Service brake: efficiency below requirements |3.7.B.7| | 2 |
Supplementary restraint system warning lamp indicates a fault (7.1.6 (a)) | 2 |
Nearside Front Headlamp aim so that beam "kick up" is not visible on the screen |4.1.2 |a|| | 2 |
Nearside Headlamp insecure |1.7.3| | 2 |
Nearside Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 1 |
Windscreen has a sticker or other obstruction encroaching by more than 10mm within zone `A` |8.3.1b| | 1 |
Front Brake lining|s| less than 1.5 mm thick |3.5.1g| | 1 |
Centre Front Horn not working |1.6.2a| | 1 |
Nearside Front Brake pipe inappropriately repaired |3.6.A.3| | 1 |
Steering column top mounting bracket insecure |2.1.2d| | 1 |
Steering column movement between the shaft and steering wheel |2.1.2b| | 1 |
Steering column locking device insecure |2.1.6| | 1 |
Offside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
Front brake application uneven | 1 |
Offside Front position lamp|s| obviously incorrectly positioned |1.1.A.3a| | 1 |
Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
Offside Headlamp insecure |1.7.3| | 1 |
Nearside Rear Stop lamp not working |1.2.1b| | 1 |
Nearside Rear Wheel bolt|s| missing |4.2.A.1e| | 1 |
Offside Rear fog lamp missing |1.3.2a| | 1 |
Offside Front Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 1 |
Offside Front Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
Nearside Front Direction indicator insecure |1.4.A.2b| | 1 |
Offside Front Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Nearside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
Front brake disc in such a condition that it is seriously weakened | 1 |
Offside Rear Shock absorber has an excessively worn shock absorber pivot |2.7.4| | 1 |
Front Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 1 |
Nearside Front Brake hose twisted |3.6.B.4c| | 1 |
Offside Rear Stop lamp not working |1.2.1b| | 1 |
Nearside Front coil spring cracked |2.4.C.1a| | 1 |
Nearside Shock absorber has a serious fluid leak |2.7.3| | 1 |
Offside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
Offside Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
Offside Front coil spring fractured |2.4.C.1a| | 1 |
Brake load sensing valve inoperative |3.6.E.3| | 1 |
Brake load sensing valve seized |3.6.E.3| | 1 |
Offside Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
Offside front brake juddering severely |3.7.A.2b| | 1 |
Offside Rear Brake cable has wires broken and is significantly weakened |3.5.1b| | 1 |
Nearside Front Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
Offside Front Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
Nearside Front Lower Front suspension ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Offside Front Lower Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 1 |
Nearside Stop lamp not working |1.2.1b| | 1 |
Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
Rear fog lamp not working |1.3.2b| | 1 |
Offside Front Upper Anti-roll bar linkage has excessive play in a ball joint and lower drop link |2.4.G.2| | 1 |
Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 1 |
Body has a projection caused by damage |6.1.C.1| | 1 |
Nearside Headlamp aim beam image kick up to the offside |1.6.B1| | 1 |
Offside Headlamp aim beam image kick up to the offside |1.6.B1| | 1 |
Offside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Spare wheel insecure |6.4.2| | 1 |
Brake hydraulic reservoir fluid level below minimum level |3.6.G.1b| | 1 |
Offside Lower Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
Centre Stop lamp not working |1.2.1b| | 1 |
Nearside Front Wheel bearing has excessive play (5.1.3 (a) (i)) | 1 |
Nearside Front Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
Front Exhaust has a major leak of exhaust gases gasket (6.1.2 (a)) | 1 |
Emissions not tested (8.2.1.2 (d)) | 1 |
Nearside Rear Service brake lagging in operation and offside rear (1.2.1 (d)) | 1 |
Nearside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
Nearside Front Shock absorber casing damaged externally so the unit does not function |2.7.2a| | 1 |
Nearside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 1 |
Nearside Rear Anti-roll bar pin or bush excessively worn |5.3.4 |a| |i|| | 1 |
Nearside Front Headlamp aim projected beam image is obviously incorrect |4.1.2 |c|| | 1 |
Offside Front Headlamp aim projected beam image is obviously incorrect |4.1.2 |c|| | 1 |
Offside Rear Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced outrigger excess corrosion |6.1.1 |c| |i|| | 1 |
Offside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
Nearside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings centre chassis |6.1.B.2| | 1 |
Offside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings centre chassis |6.1.B.2| | 1 |
Nearside Rear Parking brake lever has no reserve travel cable broken |3.1.6b| | 1 |
Nearside Front Integral body structure or chassis has excessive corrosion to the extent that overall security or stability of the body is impaired inner sill (6.2.2 (d) (ii)) | 1 |
Rear Integral body structure or chassis has excessive corrosion to the extent that overall security or stability of the body is impaired inner wheel arches both sides (6.2.2 (d) (ii)) | 1 |
Offside Rear Integral body structure or chassis has excessive corrosion to the extent that overall security or stability of the body is impaired inner sill (6.2.2 (d) (ii)) | 1 |
Rear Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced both sides bumper mounts (6.1.1 (c) (i)) | 1 |
Offside Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
Nearside Outer Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
Nearside Front Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 1 |
Offside Front Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 1 |
Nearside Headlamp aim not tested |1.8.A.1c| | 1 |
Emissions not tested |7.0| | 1 |
Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 1 |
Offside Front Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
Offside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
Offside Rear Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 1 |
Offside Rear Direction indicator adversely affected by the operation of another lamp |1.4.A.2h| | 1 |
Nearside Front Tie bar/rod has excessive play in a ball joint |2.4.G.2| | 1 |
Offside Front Tie bar/rod has excessive play in a ball joint |2.4.G.2| | 1 |
Offside Front Driver`s seat with a defective structure |6.2.5 |a| |i|| | 1 |
Offside Rear Direction indicator incorrect colour flashing white |4.4.3 |a|| | 1 |
Front Windscreen damaged and affecting the driver`s view of the road badly scored in drivers view |3.2 |a| |ii|| | 1 |
Front Sub-frame corroded and seriously weakened holed and corroded |5.3.3 |b| |i|| | 1 |
Offside Front Track rod end ball joint has excessive play |2.1.3 |b| |i|| | 1 |
Rear Exhaust system insecure hanger rubber insecure |6.1.2 |a|| | 1 |
Offside Front Headlamp aim so that beam "kick up" is not visible on the screen |4.1.2 |a|| | 1 |
Offside Front Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
Nearside Front Suspension arm rubber bush bonding deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Offside Front Suspension arm rubber bush bonding deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Nearside Rear Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Offside Rear Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Offside Rear fog lamp emits a light other than red |1.3.2e| | 1 |
Nearside Front position lamp|s| not working |1.1.A.3b| | 1 |
Offside Rear fog lamp not working |1.3.2b| | 1 |
Offside Front Lower Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
Nearside Front Lower Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
Nearside Front Steering rack gaiter split |2.2.D.2d| | 1 |
Nearside Front Lower Suspension arm ball joint excessively worn |5.3.4 |a| |i|| | 1 |
Passenger`s seat insecure |6.2.6 |a| |ii|| | 1 |
Offside Front Outer Track rod end ball joint has excessive play |2.1.3 |b| |i|| | 1 |
Exhaust system insecure (6.1.2 (a)) | 1 |
Nearside Front Seat belt retracting mechanism defective (7.1.2 (e)) | 1 |
An item not tested |Manual| | 1 |
Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 1 |
Nearside Front Outer Track rod end ball joint dust cover insecure so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
Nearside Front coil spring fractured |2.4.C.1a| | 1 |
Offside Rear Subframe mounting prescribed area excessively corroded significantly reducing structural strength inner sill to arch |5.3.6 |a| |i|| | 1 |
Offside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
Offside Front Coil spring fractured or broken (5.3.1 (b) (i)) | 1 |
Offside Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
Nearside Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
Offside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |