Most common failures | No# failures |
---|
Headlamp aim out of alignment | 51 |
Windscreen wiper does not clear the windscreen effectively | 34 |
Parking brake: efficiency below requirements |3.7.B.7| | 29 |
Rear parking brake recording little or no effort | 18 |
Brake pipe excessively corroded | 18 |
Registration plate lamp issues | 14 |
Brakes imbalanced across an axle | 13 |
Offside Headlamp not working on dipped beam |1.7.5a| | 13 |
Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 11 |
Nearside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 8 |
Exhaust has a major leak of exhaust gases |7.1.2| | 8 |
Offside Front position lamp|s| not working |1.1.A.3b| | 8 |
Rear brake binding | 8 |
Offside Front coil spring fractured |2.4.C.1a| | 6 |
Front Exhaust has a major leak of exhaust gases |7.1.2| | 6 |
Nearside Headlamp not working on dipped beam |1.7.5a| | 6 |
Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 5 |
Parking brake lever has no reserve travel |3.1.6b| | 5 |
Rear Exhaust has a major leak of exhaust gases |7.1.2| | 5 |
Offside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 5 |
Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 5 |
Offside Stop lamp not working |1.2.1b| | 5 |
Nearside Front Front position lamp|s| not working |1.1.A.3b| | 5 |
Nearside Front Front constant velocity joint gaiter split |2.5.C.1a| | 5 |
Horn not working |1.6.2a| | 4 |
Nearside Front coil spring fractured |2.4.C.1a| | 4 |
Centre Exhaust has a major leak of exhaust gases |7.1.2| | 4 |
Exhaust system not adequately supported |7.1.1| | 4 |
Front brake disc in such a condition that it is seriously weakened | 4 |
Nearside Front coil spring incomplete |2.4.C.1a| | 4 |
Offside Front Headlamp not working on dipped beam |1.7.5a| | 4 |
Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 4 |
Nearside Rear Stop lamp not working |1.2.1b| | 4 |
Offside Rear Direction indicator incorrect colour |1.4.A.2f| | 4 |
Offside Front coil spring incomplete |2.4.C.1a| | 4 |
Front brake application uneven | 4 |
Service brake: efficiency below requirements |3.7.B.7| | 4 |
Offside Headlamp aim beam image kick up to the offside |1.8| | 3 |
Registration plate issues | 3 |
Nearside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 3 |
Nearside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 3 |
Offside Rear fog lamp not working |1.3.2b| | 3 |
Nearside Front Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 3 |
Windscreen has damage | 3 |
Nearside Rear position lamp|s| not working |1.1.A.3b| | 3 |
Offside Side repeater incorrect colour |1.4.A.2f| | 3 |
Nearside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 3 |
Nearside Front position lamp|s| not working |1.1.A.3b| | 3 |
Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 3 |
Anti-lock braking system warning lamp indicates an ABS fault | 3 |
Offside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 3 |
Rear Rear fog lamp not working |1.3.2b| | 3 |
Emissions not tested |7.0| | 3 |
Offside Front Front position lamp|s| not working |1.1.A.3b| | 3 |
Nearside Stop lamp not working |1.2.1b| | 3 |
Nearside Headlamp insecure |1.7.3| | 3 |
Nearside Headlamp aim beam image kick up to the offside |1.8| | 2 |
Offside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 2 |
Nearside Front Headlamp not working on dipped beam |1.7.5a| | 2 |
Nearside Side repeater incorrect colour |1.4.A.2f| | 2 |
Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 2 |
Exhaust has part of the system excessively deteriorated |7.1.1a| | 2 |
Nearside Front Road wheel bead rim badly distorted |4.2.A.1a| | 2 |
Offside Front Road wheel bead rim badly distorted |4.2.A.1a| | 2 |
Offside Rear Road wheel bead rim badly distorted |4.2.A.1a| | 2 |
Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 2 |
Exhaust emissions hydrocarbon content after 2nd fast idle excessive |7.3.D.3| | 2 |
Nearside Front Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 2 |
Nearside Front Headlamp not working on main beam |1.7.5a| | 2 |
Nearside Front Direction indicator incorrect colour |1.4.A.2f| | 2 |
Nearside Front Shock absorber has a serious fluid leak |2.7.3| | 2 |
Offside Rear rear brake recording little or no effort |3.7.B.5a| | 2 |
Rear fog lamp not working |1.3.2b| | 2 |
Nearside Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 2 |
Offside Front Headlamp not working on main beam |1.7.5a| | 2 |
Offside Rear Rear wheel bearing rough when rotated |2.6.1| | 2 |
Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 2 |
Offside Rear Stop lamp not working |1.2.1b| | 2 |
Brake hydraulic reservoir fluid level below minimum level |3.6.G.1b| | 2 |
Rear brake disc in such a condition that it is seriously weakened | 2 |
Offside Front Seat belt damaged sufficient to obstruct correct operation of the belt |5.2.2a| | 2 |
Exhaust tailpipe not capable of allowing the emission probe to be inserted |7.3.D.1| | 2 |
Nearside Front constant velocity joint gaiter split |2.5.C.1a| | 2 |
Centre Rear Seat belt retracting mechanism defective |5.2.5b| | 2 |
Nearside Front Brake hose twisted |3.6.B.4c| | 2 |
Nearside Outer Front constant velocity joint gaiter split |2.5.C.1a| | 2 |
Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
Body insecure and dangerous to other road users |6.1.B.1b| | 1 |
Mechanical brake component has restricted free movement | 1 |
Headlamp aim beam image obviously incorrect Both Front |1.8.A.1b| | 1 |
Nearside Rear Direction indicators incorrect colour |1.4.A.2f| | 1 |
Offside Front Brake hose excessively damaged |3.6.B.4d| | 1 |
Front Upper Exhaust system not adequately supported |7.1.1| | 1 |
Direction indicator incorrect colour |1.4.A.2f| | 1 |
Nearside Rear brake caliper has restricted free movement |3.5.1k| | 1 |
Nearside Front Headlamp insecure |1.7.3| | 1 |
Nearside Front Front constant velocity joint is insecure |2.5.C.1b| | 1 |
Front Lower Anti-roll bar linkage ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt both sides |2.4.G.2| | 1 |
Offside Front Lower Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 1 |
Sub-frame has excessive play in a pin/bush both sides |2.4.G.2| | 1 |
Nearside Rear Road wheel bead rim badly distorted |4.2.A.1a| | 1 |
Nearside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings sill |6.1.B.2| | 1 |
Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Nearside Front Anti-roll bar linkage severely distorted |2.4.G.1| | 1 |
Offside Front Anti-roll bar linkage severely distorted |2.4.G.1| | 1 |
Rear Direction indicators incorrect colour |1.4.A.2f| | 1 |
Offside Front Front suspension has excessive movement at a suspension ball joint |2.5.A.1c| | 1 |
Front Tie bar/rod rubber bush bonding deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Nearside Rear Road wheel badly damaged |4.2.A.1a| | 1 |
Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
Nearside Outer Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
Offside Front Anti-roll bar has excessive play in a ball joint |2.4.G.2| | 1 |
Offside Front coil spring broken |2.4.C.1a| | 1 |
Offside Rear position lamp|s| not working |1.1.A.3b| | 1 |
Nearside Rear Direction indicator not working |1.4.A.2c| | 1 |
Offside Front Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
Nearside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
Offside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
Nearside Steering rack gaiter insecure |2.2.D.2d| | 1 |
Driver`s seat insecure |6.2.A.1| | 1 |
Offside Front Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 1 |
Nearside Steering rack gaiter split |2.2.D.2d| | 1 |
Offside Steering rack gaiter split |2.2.D.2d| | 1 |
Windscreen washer control is inaccessible to the driver |8.2.1a| | 1 |
Windscreen wiper control is inaccessible to the driver |8.2.1a| | 1 |
Nearside Headlamp aim not tested |1.8.A.1c| | 1 |
Offside Headlamp aim not tested |1.8.A.1c| | 1 |
Nearside Front Side repeater not working |1.4.A.2c| | 1 |
Offside Front Side repeater not working |1.4.A.2c| | 1 |
Nearside Front passenger door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
Nearside Outer Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
Horn not loud enough to be heard by another road user |1.6.2b| | 1 |
Power steering inoperative |2.3.3a| | 1 |
Nearside Outer Front Lower Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
Front passenger door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
Nearside Stop lamp excessively damaged so that it is not visible from a reasonable distance |1.2.1d| | 1 |
Centre Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
Position lamp switch faulty |1.1.A.1| | 1 |
Windscreen has a sticker or other obstruction encroaching by more than 10mm within zone `A` |8.3.1b| | 1 |
Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 1 |
Offside Rear Direction indicator not working |1.4.A.2c| | 1 |
Offside Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
Offside Rear Suspension weakened allowing body or other component to foul a road wheel or would do so if laden |2.4.A.1b| | 1 |
Offside Front Road wheel badly damaged |4.2.A.1a| | 1 |
Nearside Front Headlamp missing |1.7.3| | 1 |
Nearside Front Direction indicator not working |1.4.A.2c| | 1 |
Nearside rear brake recording little or no effort |3.7.B.5a| | 1 |
Nearside Front Lower Ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
Offside Front Lower Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Offside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Offside Rear Road wheel distorted |4.2.A.1a| | 1 |
Nearside Outer Front Front constant velocity joint is insecure |2.5.C.1b| | 1 |
Offside Front Windscreen wiper not operating over a large enough area to give an adequate view |8.2.1c| | 1 |
Offside Front brake disc excessively pitted |3.5.1h| | 1 |
Brake hose damaged | 1 |
Offside Front Direction indicator not working |1.4.A.2c| | 1 |
Brake pedal creeps down when held under pressure |3.3.B.1a| | 1 |
Brake load sensing valve seized |3.6.E.3| | 1 |
Offside Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
Offside Front All position lamps not working |1.1.A.3b| | 1 |
Offside Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 1 |
Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
Rear Stop lamp excessively damaged so that it is not visible from a reasonable distance |1.2.1d| | 1 |
Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
Nearside Front Subframe mounting prescribed area excessively corroded significantly reducing structural strength inner wing and jacking point area holed (5.3.6 (a) (i)) | 1 |
Offside Front Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced inner wing next to engine mounting (6.1.1 (c) (i)) | 1 |
Nearside Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
Nearside Front Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Front Battery insecure |1.9.1| | 1 |
Fuel tank leaking |7.2.3| | 1 |
Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Steering column flexible coupling has excessive play |2.1.5| | 1 |
Offside Rear Direction indicators not working |1.4.A.2c| | 1 |
Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
Windscreen wiper blade insecure | 1 |
Offside Front Front constant velocity joint gaiter insecure to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
Front suspension has excessive movement at a wishbone pin or bush |2.5.A.1c| | 1 |
Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 1 |
Nearside Front front brake binding |3.7.B.1| | 1 |
Offside Rear Rear position lamp|s| incorrect colour |1.1.A.3e| | 1 |
Offside Front Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
Front Windscreen wiper blade deteriorated |8.2.2| | 1 |
Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
Nearside Front Macpherson strut pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
Nearside Rear brake disc excessively scored |3.5.1h| | 1 |
Rear brake caliper has restricted free movement |3.5.1k| | 1 |
Nearside Front constant velocity joint gaiter insecurely mounted to its housing |2.5.C.1a| | 1 |
Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Nearside Front suspension has a suspension lower ball joint securing nut loose |2.5.B.1a| | 1 |
Nearside Front Brake hose twisted |found during steering lock to lock check| |2.2.D.2b| | 1 |
Rear fog lamp tell tale not working |1.3.1b| | 1 |
Front passenger seat insecure |6.2.3| | 1 |
Nearside Front Front wheel bearing rough when rotated |2.5.A.2| | 1 |
Front Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
Offside Rear Service brake application uneven across the axle |3.7.D.2b| | 1 |
Front passenger door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
Offside Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
Nearside Front Headlamp aim beam image kick up to the offside |1.8| | 1 |
Offside Front Headlamp aim beam image kick up to the offside |1.8| | 1 |
Offside Rear fog lamp missing |1.3.2a| | 1 |
Offside rear brake recording little or no effort |3.7.B.5a| | 1 |
Rear brake application uneven | 1 |
Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Rear brake disc contaminated by brake fluid |3.5.1h| | 1 |
Offside Front Front constant velocity joint is insecure |2.5.C.1b| | 1 |
Nearside Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 1 |
Offside Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
Offside Obligatory mirror insecure |8.1.1| | 1 |
Offside Steering rack gaiter insecure |2.2.D.2d| | 1 |
Nearside Rear Rear position lamp|s| excessively damaged so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
Nearside Front Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
Offside Lower Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
Offside Headlamp insecure |1.7.3| | 1 |
Nearside Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
Offside Front brake disc excessively scored |3.5.1h| | 1 |
Nearside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Offside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Nearside Front coil spring broken |2.4.C.1a| | 1 |
Nearside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
Nearside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Offside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Nearside Rear Shock absorber has an excessively worn bush |2.7.4| | 1 |
Headlamp aim beam image kick up to the offside |1.8| | 1 |
Nearside front brake juddering severely |3.7.A.2b| | 1 |
Offside front brake juddering severely |3.7.A.2b| | 1 |
Nearside Rear Rear position lamp|s| incomplete |1.1.4a| | 1 |
Offside Front Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
Offside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
Nearside Rear Brake cable has restricted free movement |3.5.1k| | 1 |
Offside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
Nearside Rear Trailing arm has excessive play in a pin/bush |2.4.G.2| | 1 |
Offside Rear Trailing arm has excessive play in a pin/bush |2.4.G.2| | 1 |
Offside Front Suspension arm has excessive play in a track control arm inner bush |2.5.B.2b| | 1 |
Headlamp aim not tested |1.8.A.1c| | 1 |
Seat belt retracting mechanism defective |5.2.5b| | 1 |
Nearside Headlamp not in good working order |not working| |1.2.4a| | 1 |
Centre Rear Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
Nearside Headlamp insecure (4.1.1 (c)) | 1 |
Nearside Parking brake inoperative on one side (1.4.1 (a)) | 1 |
Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 1 |
Nearside Front Brake pipe leaking on a hydraulic braking system (1.1.11 (b) (ii)) | 1 |
Braking system leaking |3.6.A.1| | 1 |
Parking brake efficiency below requirements (1.4.2 (a) (i)) | 1 |
Front brake disc excessively scored |3.5.1h| | 1 |
Nearside Front Lower Ball joint has excessive play |2.2.B.1f| | 1 |
Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
Nearside Rear Rear wheel bearing rough when rotated |2.6.1| | 1 |
Battery insecure |1.9.1| | 1 |
Driver`s door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
Offside Front Lower Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Offside Headlamp not working on main beam |1.7.5a| | 1 |
Rear Mechanical brake component has restricted free movement | 1 |
Offside Front Braking system leaking brake pipe burst |3.6.A.1| | 1 |
Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
Front brake disc excessively pitted |3.5.1h| | 1 |
Rear An item not tested |Manual| | 1 |
Rear wheel bearing rough when rotated |2.6.1| | 1 |