| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 17 |
| Parking brake: efficiency below requirements |3.7.B.7| | 16 |
| Rear parking brake recording little or no effort | 10 |
| Windscreen wiper does not clear the windscreen effectively | 9 |
| Registration plate lamp issues | 8 |
| Brake pipe excessively corroded | 7 |
| Brakes imbalanced across an axle | 6 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 5 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 5 |
| Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 5 |
| Brake hose excessively deteriorated | 5 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 4 |
| Brake hose damaged | 3 |
| Exhaust catalytic converter missing where one was fitted as standard |7.1.3| | 3 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 3 |
| Nearside Steering rack gaiter split |2.2.D.2d| | 3 |
| Nearside Stop lamp not working |1.2.1b| | 3 |
| Offside Front Inner Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 3 |
| Nearside Front Inner Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 3 |
| Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 2 |
| Offside Rear rear brake recording little or no effort |3.7.B.5a| | 2 |
| Exhaust emissions hydrocarbon content after 2nd fast idle excessive |7.3.D.3| | 2 |
| Offside Stop lamp not working |1.2.1b| | 2 |
| Nearside Side repeater not working |1.4.A.2c| | 2 |
| Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 2 |
| Hazard warning switch inoperative (4.4.2 (a) (ii)) | 2 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 2 |
| Supplementary restraint system warning lamp indicates a fault (7.1.6 (a)) | 2 |
| Windscreen washer not working | 2 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength Inner wheel arch (5.3.6 (a) (i)) | 2 |
| Offside Rear wheel bearing rough when rotated |2.6.1| | 2 |
| Rear Brake cable insecure | 2 |
| Front brake disc in such a condition that it is seriously weakened | 2 |
| Emissions not tested |8.2.1.2 |d|| | 1 |
| Exhaust has a major leak of exhaust gases |6.1.2 |a|| | 1 |
| Offside Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Rear fog lamp switch inoperative (4.5.3 (a)) | 1 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Rear brake disc in such a condition that it is seriously weakened | 1 |
| Rear fog lamp obviously incorrectly positioned |1.3.2a| | 1 |
| Offside Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Centre Rear Brake pipe leaking |3.6.A.1| | 1 |
| Front Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 1 |
| Offside Front Coil spring fractured or broken (5.3.1 (b) (i)) | 1 |
| Offside Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Nearside Front coil spring fractured |2.4.C.1a| | 1 |
| Offside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded floor |2.4.A.3| | 1 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive due to cat missing |7.3.D.3| | 1 |
| Exhaust emissions hydrocarbon content after 2nd fast idle excessive due to cat missing |7.3.D.3| | 1 |
| Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Parking brake lever has excessive movement indicating incorrect adjustment (1.1.6 (c)) | 1 |
| Exhaust emits excessive dense blue smoke during acceleration (8.2.1.2 (g)) | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds default limits (8.2.1.2 (b)) | 1 |
| Exhaust catalytic converter missing where one was fitted as standard (8.2.1.1 (a)) | 1 |
| Nearside Rear Wheel bearing rough when rotated (5.1.3 (b) (i)) | 1 |
| Nearside Front Seat belt retracting mechanism defective |5.2.5b| | 1 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Seat belt anchorage prescribed area is excessively corroded floor pan |5.2.6| | 1 |
| Nearside Seat belt anchorage prescribed area is excessively corroded floor |5.2.6| | 1 |
| Nearside Front Track rod end loose |2.2.B.1d| | 1 |
| Mechanical brake component has restricted free movement | 1 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside Inner Front Suspension arm has excessive play in a track control arm inner bush |2.5.B.2b| | 1 |
| Nearside Outer Front Suspension arm has excessive play in a track control arm inner bush |2.5.B.2b| | 1 |
| Centre Exhaust mounting missing |7.1.1b| | 1 |
| Rear Exhaust has a part missing |7.1.1a| | 1 |
| Offside Rear Service brake has no recorded effort at a wheel (1.2.1 (a) (ii)) | 1 |
| Nearside Rear Service brake has no recorded effort at a wheel (1.2.1 (a) (ii)) | 1 |
| Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Offside Front Side repeater not working |1.4.A.2c| | 1 |
| Nearside Front Side repeater not working |1.4.A.2c| | 1 |
| Front position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Nearside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Offside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Hazard warning lamps inoperative (4.4.1 (e)) | 1 |
| Nearside Front Headlamp levelling device inoperative (4.1.5 (a)) | 1 |
| Offside Front Headlamp levelling device inoperative (4.1.5 (a)) | 1 |
| Nearside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt insecure (6.1.7 (g) (ii)) | 1 |
| Offside Front Outer Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Nearside Front Service brake excessively binding (1.2.1 (f)) | 1 |
| Offside Front Service brake excessively binding (1.2.1 (f)) | 1 |
| Nearside Front Headlamp aim not tested (4.1.2 (b)) | 1 |
| Offside Front Headlamp aim not tested (4.1.2 (b)) | 1 |
| Offside Rear Direction indicator not working (4.4.1 (a) (ii)) | 1 |
| Offside Rear Rear fog lamp adversely affected by the operation of another lamp (4.5.4 (b)) | 1 |
| Front Direction indicator incorrect colour both sides, (4.4.3 (a)) | 1 |
| Rear Boot lid cannot be secured in the closed position (6.2.1 (e)) | 1 |
| Nearside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Front Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 1 |
| Rear Rear fog lamp does not emit a steady red light |1.3.2e| | 1 |
| Nearside Rear Wheel stud|s| missing |4.2.A.1e| | 1 |
| Offside Rear Wheel stud|s| missing |4.2.A.1e| | 1 |
| Nearside Front brake disc excessively pitted |3.5.1h| | 1 |
| Nearside Front brake disc excessively scored |3.5.1h| | 1 |
| Offside Front brake disc excessively pitted |3.5.1h| | 1 |
| Offside Front brake disc excessively scored |3.5.1h| | 1 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Steering rack gaiter split |2.2.D.2d| | 1 |
| Brake load sensing valve seized |3.6.E.3| | 1 |
| Nearside Rear Radius arm has excessive play in a pin/bearing |2.4.G.2| | 1 |
| Nearside Front Seat belt anchorage prescribed area strength or continuity significantly reduced inner cill and floor |7.1.1 |a| |i|| | 1 |
| Offside Front Seat belt anchorage prescribed area strength or continuity significantly reduced inner cill and floor |7.1.1 |a| |i|| | 1 |
| Front passenger door cannot be opened from outside the vehicle (6.2.3 (a)) | 1 |
| Nearside Front Direction indicator not working |1.4.A.2c| | 1 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Front Inner Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Parking brake: efficiency below requirements |3.7.D.4| | 1 |
| Offside Parking brake is not capable of being maintained in operation by direct mechanical action only |3.1.2| | 1 |
| Nearside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Nearside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner sill (5.3.6 (a) (i)) | 1 |
| Brake load sensing valve linkage defective and function impaired lever siezed (1.1.17 (a)) | 1 |
| Rear Brake disc significantly and obviously worn inner face corroded (1.1.14 (a) (i)) | 1 |
| Nearside Rear brake disc excessively pitted |3.5.1h| | 1 |
| Offside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Nearside Rear wheel bearing rough when rotated |2.6.1| | 1 |
| Centre Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Outer Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Outer Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Inner Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Offside Inner Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
| Nearside Front Outer Front constant velocity joint gaiter insecure to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Offside Front Inner Suspension arm attachment bracket/mounting corroded and its strength is seriously reduced |2.4.G.1| | 1 |
| Offside Rear brake caliper has restricted free movement |3.5.1k| | 1 |
| Offside Front Direction indicators not working |1.4.A.2c| | 1 |
| Passenger`s airbag obviously defective |5.4.1| | 1 |
| Driver`s airbag obviously defective |5.4.1| | 1 |
| Nearside Outer Front constant velocity joint is insecure |2.5.C.1b| | 1 |
| Offside Outer Front constant velocity joint gaiter insecure to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Offside Rear wheel bearing has excessive play |2.6.2| | 1 |
| Front Service brake application uneven across the axle |3.7.D.2b| | 1 |
| Rear Service brake application uneven across the axle |3.7.D.2b| | 1 |
| Offside Rear Road wheel bead rim badly distorted |4.2.A.1a| | 1 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Front Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Front Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Driver`s door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
| Offside Front Brake hose excessively damaged |3.6.B.4d| | 1 |
| Nearside Front Direction indicator not working (4.4.1 (a) (ii)) | 1 |
| Offside Front Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |