| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 5 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 4 |
| Brakes imbalanced across an axle | 4 |
| Rear fog lamp not working |1.3.2b| | 3 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits |8.2.1.2 |c|| | 3 |
| Rear brake binding | 2 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 2 |
| Nearside Side repeater not working |1.4.A.2c| | 2 |
| Offside Rear fog lamp not working |1.3.2b| | 2 |
| Registration plate lamp issues | 2 |
| Offside Rear fog lamp not working |4.5.1 |a| |ii|| | 2 |
| Rear parking brake recording little or no effort | 2 |
| Nearside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 2 |
| Nearside Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Offside Front Axle king pin has excessive play in pin and/or bush adversely affecting the steering |2.5.A.3a| | 1 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Nearside Rear wheel bearing rough when rotated |2.6.1| | 1 |
| Nearside Front Inner Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Front Inner Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Centre Rear engine mounting bracket damaged and likely to fail |6.1.D.1b| | 1 |
| Nearside Front Lower Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Inner Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Front Windscreen wiper not working |3.4 |a|| | 1 |
| Offside Parking brake inoperative on one side |1.4.1 |a|| | 1 |
| All direction indicators adversely affected by the operation of another lamp |4.4.3 |b|| | 1 |
| Parking brake efficiency less than 50% of the required value |1.4.2 |a| |ii|| | 1 |
| Offside Rear fog lamp obviously incorrectly positioned |1.3.2a| | 1 |
| Nearside Rear position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Offside Rear position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Nearside Stop lamp emits other than a steady red light |1.2.1e| | 1 |
| Offside Stop lamp emits other than a steady red light |1.2.1e| | 1 |
| Headlamp not in good working order |not working| |1.2.4a| | 1 |
| Rear fog lamp switch faulty |1.3.1a| | 1 |
| Offside Rear fog lamp switch missing |1.3.1a| | 1 |
| Offside Front Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Rear brake application uneven | 1 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 1 |
| Offside Vehicle structure has an inadequate repair, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Driver`s seat fore and aft adjustment mechanism not functioning as intended. |6.2.A.3| | 1 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Windscreen wiper does not clear the windscreen effectively | 1 |
| Nearside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Nearside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Axle king pin has excessive play in pin and/or bush adversely affecting the steering |2.5.A.3a| | 1 |
| Nearside Rear Lower Suspension arm corroded and seriously weakened |2.4.G.1| | 1 |
| Nearside Rear Shock absorber detached |2.7.2b| | 1 |
| Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Driver`s seat insecure |6.2.A.1| | 1 |
| Nearside Front Passenger`s seat insecure |6.2.A.1| | 1 |
| Nearside rear brake excessively fluctuating |3.7.B.3| | 1 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Battery insecure |1.9.1| | 1 |
| Nearside Stop lamp not working |1.2.1b| | 1 |
| Offside Stop lamp not working |1.2.1b| | 1 |
| Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Nearside Front Brake hose twisted |3.6.B.4c| | 1 |
| Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 1 |
| Parking brake: efficiency below requirements |3.7.B.7| | 1 |
| Offside Side repeater not working |4.4.1 |a| |ii|| | 1 |
| Nearside Headlamp aim projected beam image is obviously incorrect left hand drive headlamp fitted |4.1.2 |c|| | 1 |
| Offside Headlamp aim projected beam image is obviously incorrect left hand drive headlight fitted |4.1.2 |c|| | 1 |
| Nearside Rear Parking brake inoperative on one side |1.4.1 |a|| | 1 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds default limits |8.2.1.2 |b|| | 1 |
| Exhaust carbon monoxide content at idle exceeds default limits |8.2.1.2 |b|| | 1 |
| Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 1 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 1 |
| Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
| Offside Windscreen wiper not working |3.4 |a|| | 1 |
| Nearside Seat belt anchorage prescribed area strength or continuity significantly reduced |7.1.1 |a| |i|| | 1 |
| Offside front brake recording little or no effort |3.7.B.5a| | 1 |
| Nearside Side repeater not working (4.4.1 (a) (ii)) | 1 |
| Rear fog lamp obviously incorrectly positioned (4.5.4 (a)) | 1 |
| Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Nearside Front Suspension component pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Front Drivers seat insecure (6.2.5 (a) (ii)) | 1 |
| Nearside Front Seat belt anchorage prescribed area strength or continuity significantly reduced (7.1.1 (a) (i)) | 1 |
| Offside Front Seat belt anchorage prescribed area strength or continuity significantly reduced (7.1.1 (a) (i)) | 1 |
| Floor excessively deteriorated (6.2.4 (a) (i)) | 1 |
| Offside Side repeater not working (4.4.1 (a) (ii)) | 1 |
| Nearside Rear Outer Suspension component mounting prescribed area excessively corroded significantly reducing structural strength Sill (5.3.6 (a) (i)) | 1 |
| Offside Rear Suspension arm attachment bracket/mounting insecure bolts loose (5.3.3 (a) (i)) | 1 |
| Rear Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced (6.1.1 (c) (i)) | 1 |
| Nearside Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced (6.1.1 (c) (i)) | 1 |
| Offside Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced (6.1.1 (c) (i)) | 1 |
| Nearside Vehicle structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting (6.2.2 (d) (i)) | 1 |
| Nearside Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced (6.1.1 (c) (i)) | 1 |
| Front Wheel bearing has excessive play both (5.1.3 (a) (i)) | 1 |
| Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 1 |
| Nearside Front Track rod end ball joint dust cover insecure so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Offside Front Track rod end ball joint dust cover insecure so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Offside Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Offside Front Brake hose excessively damaged (1.1.12 (b) (ii)) | 1 |