| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 6 |
| Registration plate lamp issues | 3 |
| Nearside Steering rack gaiter split |2.2.D.2d| | 2 |
| Registration plate issues | 2 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 2 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 2 |
| Brake pedal has insufficient reserve travel (1.1.2 (a)) | 1 |
| Nearside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength floor (5.3.6 (a) (i)) | 1 |
| Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength floor (5.3.6 (a) (i)) | 1 |
| Nearside Rear Suspension component pin or bush excessively worn radius arm (5.3.4 (a) (i)) | 1 |
| Nearside Front Service brake effort inadequate at a wheel (1.2.1 (a) (i)) | 1 |
| Offside Front Service brake effort inadequate at a wheel (1.2.1 (a) (i)) | 1 |
| Steering wheel has movement relative to the column indicating looseness (2.2.1 (a) (i)) | 1 |
| Nearside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Exhaust emissions hydrocarbon content after 2nd fast idle excessive |7.3.D.3| | 1 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 1 |
| Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 1 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 1 |
| Offside Steering rack gaiter split |2.2.D.2d| | 1 |
| Nearside Front Suspension has inadequate clearance with the bump stop |2.4.A.1a| | 1 |
| Nearside Headlamp insecure |1.7.3| | 1 |
| Offside Headlamp insecure |1.7.3| | 1 |
| Nearside Track rod end ball joint has excessive play inner |2.2.B.1f| | 1 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Nearside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Offside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Stop lamp(s) all not working (4.3.1 (a) (iii)) | 1 |
| Windscreen washer jets misaligned and not providing sufficient fluid to the windscreen (3.5 (a)) | 1 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Offside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Offside Front Body mounting fixings insecure such that stability is seriously impaired rear subframe mount (6.2.2 (c) (ii)) | 1 |
| Service brake: efficiency below requirements |3.7.B.7| | 1 |
| Vehicle Identification Number not permanently displayed |6.3.5.a| | 1 |
| Driver`s seat insecure |6.2.A.1| | 1 |
| Front passenger seat insecure |6.2.3| | 1 |
| Driver`s door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
| Front passenger door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
| Front Bonded suspension unit bonding failed and part of unit is likely to become displaced |2.4.F.2| | 1 |
| Brake hydraulic reservoir fluid level below minimum level |3.6.G.1b| | 1 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Offside Front Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
| Offside Front Torque/reaction arm has a deteriorated synthetic bush resulting in excessive movement |2.4.G.2| | 1 |
| Wheel insecure |4.2.A.1c| | 1 |
| Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Centre Exhaust system not adequately supported |7.1.1| | 1 |
| Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Front Fuel pipe leaking |7.2.3| | 1 |
| Front front brake binding |3.7.B.1| | 1 |
| Rear front parking brake recording little or no effort |3.7.B.6a| | 1 |
| Front brake application uneven | 1 |
| Exhaust emits excessive dense blue smoke during acceleration |7.3.A.2c| | 1 |
| Offside Rear fog lamp flickers when tapped lightly by hand |1.1.6d| | 1 |
| Steering rack insecure |2.2.B.1a| | 1 |
| Nearside Seat belt anchorage prescribed area is inadequately repaired |5.2.6| | 1 |
| Vehicle Identification Number has more than one different number displayed |6.3.5.b| | 1 |
| Nearside Vehicle structure or chassis has excessive corrosion to the extent that overall security or stability of the body is impaired center chill (6.2.2 (d) (ii)) | 1 |
| Offside Vehicle structure or chassis has excessive corrosion to the extent that overall security or stability of the body is impaired center chill (6.2.2 (d) (ii)) | 1 |
| Emissions unable to be completed (8.2.1.2 (d)) | 1 |
| Exhaust has a major leak of exhaust gases front down pipe (6.1.2 (a)) | 1 |
| Nearside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Offside Headlamp not working on main beam |1.7.5a| | 1 |
| Offside Stop lamp not working |1.2.1b| | 1 |
| Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Offside Rear fog lamp not working |1.3.2b| | 1 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Nearside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Service brake: efficiency below requirements |3.7.C.1a| | 1 |
| Nearside Front Direction indicator not working |1.4.A.2c| | 1 |