| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 42 |
| Windscreen wiper does not clear the windscreen effectively | 29 |
| Nearside Front Coil spring fractured or broken (5.3.1 (b) (i)) | 24 |
| Offside Front Coil spring fractured or broken (5.3.1 (b) (i)) | 19 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 11 |
| Registration plate lamp issues | 11 |
| Offside Rear Direction indicator incorrect colour (4.4.3 (a)) | 9 |
| Nearside Rear Direction indicator incorrect colour (4.4.3 (a)) | 8 |
| Windscreen washer not working | 8 |
| Parking brake lever has excessive movement indicating incorrect adjustment (1.1.6 (c)) | 6 |
| Offside Front Inner Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 6 |
| Nearside Front Inner Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 6 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 5 |
| Offside Rear Direction indicator incorrect colour |4.4.3 |a|| | 5 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 5 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 5 |
| Nearside Front coil spring broken |2.4.C.1a| | 4 |
| Registration plate issues | 4 |
| Offside Front coil spring broken |2.4.C.1a| | 4 |
| Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 4 |
| Nearside Rear Coil spring fractured or broken (5.3.1 (b) (i)) | 4 |
| Nearside Rear Direction indicator incorrect colour |4.4.3 |a|| | 4 |
| Offside Rear Direction indicator incorrect colour |1.4.A.2f| | 3 |
| Nearside Rear Shock absorbers has a serious fluid leak | 3 |
| Offside Front Coil spring fractured or broken |5.3.1 |b| |i|| | 3 |
| Exhaust emissions exceed manufacturers specified limit (8.2.2.2 (a)) | 3 |
| Offside Front Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 3 |
| Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 3 |
| Nearside Front Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 3 |
| Nearside Front Suspension arm pin or bush excessively worn rear (5.3.4 (a) (i)) | 3 |
| Offside Front Suspension arm pin or bush excessively worn rear (5.3.4 (a) (i)) | 3 |
| Nearside Front Suspension arm pin or bush excessively worn rear bush (5.3.4 (a) (i)) | 3 |
| Nearside Rear Position lamp not working (4.2.1 (a) (ii)) | 3 |
| Offside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 2 |
| Offside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 2 |
| Offside Rear Position lamp not working (4.2.1 (a) (ii)) | 2 |
| Offside Stop lamp(s) not working (4.3.1 (a) (ii)) | 2 |
| Offside Front Inner Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 2 |
| Nearside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 2 |
| Offside Stop lamp not working |1.2.1b| | 2 |
| Nearside Front Position lamp not working |4.2.1 |a|| | 2 |
| Offside Rear fog lamp not working |1.3.2b| | 2 |
| Nearside Side repeater not working (4.4.1 (a) (ii)) | 2 |
| Nearside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 2 |
| Nearside Front Suspension arm pin or bush excessively worn |5.3.4 |a| |i|| | 2 |
| Offside Front Suspension arm pin or bush excessively worn |5.3.4 |a| |i|| | 2 |
| Nearside Rear Hydraulic brake calliper leaking (1.1.16 (b) (i)) | 2 |
| Offside Front Coil spring fractured or broken broken (5.3.1 (b) (i)) | 1 |
| Offside Track rod end ball joint worn to the extent there is a serious risk of detachment (2.1.3 (b) (ii)) | 1 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 1 |
| Nearside Rear Anti-roll bar linkage pin or bush likely to become detached (5.3.4 (a) (ii)) | 1 |
| Nearside Lower Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Lower Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Side repeater missing (4.4.1 (a) (ii)) | 1 |
| Rear parking brake recording little or no effort | 1 |
| Offside Rear Stop lamp not working |1.2.1b| | 1 |
| Front Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
| Front Exhaust system insecure Mount broken (6.1.2 (a)) | 1 |
| Offside Rear Anti-roll bar linkage insecurely attached (5.3.3 (a) (i)) | 1 |
| Offside Front front brake binding |3.7.B.1| | 1 |
| Offside Front Body has a sharp edge caused by damage |6.1.C.1| | 1 |
| Exhaust system insecure exhaust tail pipe corroded off & is insecure (6.1.2 (a)) | 1 |
| Suspension arm ball joint excessively worn o/s bottom ball joint (5.3.4 (a) (i)) | 1 |
| Nearside Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 1 |
| Offside Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 1 |
| Nearside Front coil spring broken bottom of spring likely to slip off of lower cup where broken |2.4.C.1a| | 1 |
| Offside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Offside Rear Direction indicator incorrect colour paint off of bulb (4.4.3 (a)) | 1 |
| Nearside Rear Direction indicator incorrect colour paint off of bulb (4.4.3 (a)) | 1 |
| Exhaust has a major leak of exhaust gases Middle silencer. (6.1.2 (a)) | 1 |
| Offside Front Suspension arm pin or bush likely to become detached rear bush |5.3.4 |a| |ii|| | 1 |
| Brake fluid significantly below minimum mark (1.1.10 (d) (ii)) | 1 |
| Offside Front Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 1 |
| Nearside Front Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Nearside Front Lower Suspension arm pin or bush excessively worn rear bush (5.3.4 (a) (i)) | 1 |
| Offside Front Lower Suspension arm pin or bush excessively worn rear bush (5.3.4 (a) (i)) | 1 |
| Offside Front Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Bonnet retaining device ineffective |8.4.2| | 1 |
| Central Front Vehicle structure strengthening plate or fastening so insecure that structural rigidity is seriously reduced Radiator mounting bracket excessively corroded. Likely to become detached. (6.1.1 (b) (ii)) | 1 |
| Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
| Front Headlamp levelling device inoperative |1.7.2| | 1 |
| Front Headlamp cleaning device inoperative |1.7.2| | 1 |
| Anti-lock braking system warning lamp indicates an ABS fault | 1 |
| Nearside Rear reflector defective or damaged by more than 50% of the reflecting surface (4.8.1 (a) (ii)) | 1 |
| Offside Inner Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Nearside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Nearside Front Coil spring fractured or broken Broken |5.3.1 |b| |i|| | 1 |
| Offside Front Coil spring fractured or broken Broken |5.3.1 |b| |i|| | 1 |
| Power steering inoperative and steering adversely affected (2.1.5 (c) (ii)) | 1 |
| Nearside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Front Exhaust system insecure pipe (6.1.2 (a)) | 1 |
| Offside Front Shock absorbers has a serious fluid leak | 1 |
| Offside Rear Stop lamp(s) light intensity significantly reduced (4.3.3 (a) (ii)) | 1 |
| Nearside Headlamp light intensity severely reduced (4.1.4 (a)) | 1 |
| Offside Rear Coil spring corroded so that its cross sectional area is reduced and seriously weakened (5.3.1 (b) (i)) | 1 |
| Nearside Rear Shock absorbers has negligible damping effect (5.3.2 (d)) | 1 |
| Offside Rear Shock absorbers has negligible damping effect (5.3.2 (d)) | 1 |
| Offside Front Track rod end loose |2.2.B.1d| | 1 |
| Nearside Inner Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 1 |
| Offside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Nearside Front Headlamp lens seriously defective sharp edge (4.1.1 (b) (ii)) | 1 |
| Offside Front Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Front passenger door cannot be opened from inside the vehicle |6.2.3 |a|| | 1 |
| Offside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| coil spring broken |2.4.C.1a| | 1 |
| Nearside Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Nearside Front Service brake excessively binding (1.2.1 (f)) | 1 |
| Power steering pipe/hose leaking (2.1.5 (a)) | 1 |
| Nearside Rear Anti-roll bar linkage fractured (5.3.3 (b) (ii)) | 1 |
| Offside Inner Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Offside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Offside Rear Hydraulic brake calliper leaking (1.1.16 (b) (i)) | 1 |
| Nearside Body has a sharp edge caused by damage side repeater lens |6.1.C.1| | 1 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Front Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc inner cv split |2.5.C.1a| | 1 |
| Rear All direction indicators incorrect colour (4.4.3 (a)) | 1 |
| Offside Rear Position lamp not working o/s/rear not working |4.2.1 |a|| | 1 |
| Headlamp aim projected beam image is obviously incorrect |4.1.2 |c|| | 1 |
| Offside Rear Seat belt adjustment fitting badly deteriorated OSR seat belt stalk faulty. |5.2.3| | 1 |
| Nearside Front Lower Suspension arm pin or bush excessively worn rear. (5.3.4 (a) (i)) | 1 |
| Offside Front Lower Suspension arm pin or bush excessively worn rear. (5.3.4 (a) (i)) | 1 |
| Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Rear Exhaust has a major leak of exhaust gases silencer (6.1.2 (a)) | 1 |
| Nearside Rear Suspension arm pin or bush excessively worn trailing arm bush (5.3.4 (a) (i)) | 1 |
| Offside Rear Suspension arm pin or bush excessively worn trailing arm bush (5.3.4 (a) (i)) | 1 |
| Offside Rear Shock absorbers has a serious fluid leak | 1 |
| Offside Rear Coil spring fractured or broken (5.3.1 (b) (i)) | 1 |
| Offside Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Nearside Rear Seat belt buckle not functioning as intended (7.1.2 (d)) | 1 |
| Offside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Inner Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Offside Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Offside Rear Upper Position lamp not working |4.2.1 |a|| | 1 |
| Exhaust has a major leak of exhaust gases Rear exhaust box holed and blowing. |6.1.2 |a|| | 1 |
| Nearside Front Inner Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 1 |
| Headlamp aim beam image kick up to the offside both sides |1.8| | 1 |
| Engine MIL inoperative or indicates a malfunction (8.2.2.2 (g)) | 1 |
| Nearside Front Lower Suspension arm pin or bush excessively worn Rear most bush (5.3.4 (a) (i)) | 1 |
| Nearside Steering locking device ineffective |2.1.3 |d|| | 1 |
| Offside Front Suspension arm pin or bush excessively worn rear bush (5.3.4 (a) (i)) | 1 |
| Nearside Front Inner Prop shaft joint constant velocity boot no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Offside Front Wheel bearing rough when rotated (5.1.3 (b) (i)) | 1 |
| Electronic stability control warning lamp indicates a fault (7.12 (e)) | 1 |
| Offside Rear Bumper insecure (6.1.4 (a) (i)) | 1 |
| Offside Front Bumper insecure (6.1.4 (a) (i)) | 1 |
| Brake hydraulic reservoir fluid level significantly below minimum level (1.1.10 (d) (ii)) | 1 |
| Offside Front Suspension arm pin or bush excessively worn LOWER ARM REAR BUSH (5.3.4 (a) (i)) | 1 |
| Offside Rear Anti-roll bar linkage likely to become detached Linkage broken (5.3.3 (a) (ii)) | 1 |
| Horn not working (7.7 (a)) | 1 |
| Nearside Front Headlamp levelling device inoperative (4.1.5 (a)) | 1 |
| Offside Front Side repeater not working (4.4.1 (a) (ii)) | 1 |
| Offside Front Suspension arm pin or bush excessively worn bottom arm (5.3.4 (a) (i)) | 1 |
| Offside Rear Anti-roll bar pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Rear Exhaust system insecure mount & heatshield (6.1.2 (a)) | 1 |
| Offside Rear Anti-roll bar linkage attachment bracket/mounting fractured (5.3.3 (b) (ii)) | 1 |
| Central Front Exhaust system insecure |6.1.2 |a|| | 1 |
| Nearside Front Lower Suspension arm pin or bush excessively worn |5.3.4 |a| |i|| | 1 |
| Offside Front Track rod end ball joint worn to the extent there is a serious risk of detachment (2.1.3 (b) (ii)) | 1 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Front Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Nearside Rear Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Offside Rear Rear position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Offside Rear Hydraulic brake cylinder leaking hydraulic fluid caliper |1.1.16 |b| |i|| | 1 |
| Central Rear Seat belt not functioning as intended (7.1.2 (c)) | 1 |
| Offside Front Drag link end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Nearside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Rear Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 1 |
| Upper Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Offside Front Anti-roll bar linkage fractured (5.3.3 (b) (ii)) | 1 |
| Nearside Front Road wheel fixing missing Wheel nut missing (5.2.1 (a) (i)) | 1 |
| Offside Front Road wheel fixing missing Wheel nut missing (5.2.1 (a) (i)) | 1 |
| Offside Front Suspension arm pin or bush excessively worn Rear bush (5.3.4 (a) (i)) | 1 |
| Offside Side repeater incorrect colour Not amber (4.4.3 (a)) | 1 |
| Offside Rear Direction indicator incorrect colour Not amber (4.4.3 (a)) | 1 |
| Nearside Front Lower Suspension arm pin or bush excessively worn Rear bush (5.3.4 (a) (i)) | 1 |
| Nearside Side repeater lens defective such that the emitted light is adversely affected (4.4.1 (b) (ii)) | 1 |
| Nearside Headlamp insecure (4.1.1 (c)) | 1 |
| Nearside Headlamp aim unable to be tested (4.1.2 (b)) | 1 |
| Nearside Front Body component damaged and likely to cause injury wing repeater lens (6.2.1 (a) (i)) | 1 |
| Nearside Front Lower Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Side repeater incorrect colour (4.4.3 (a)) | 1 |
| Nearside Front Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Service brake excessively fluctuating (1.2.1 (e)) | 1 |
| Nearside Front Service brake excessively fluctuating (1.2.1 (e)) | 1 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Nearside Front Coil spring fractured or broken |5.3.1 |b| |i|| | 1 |
| Offside Front Lower Suspension arm pin or bush excessively worn arm rear bush |5.3.4 |a| |i|| | 1 |
| Offside Rear Anti-roll bar attachment bracket/mounting fractured (5.3.3 (b) (ii)) | 1 |
| Nearside Front Inner Steering linkage ball joint has excessive play tie arm (2.1.3 (b) (i)) | 1 |
| Offside Headlamp insecure (4.1.1 (c)) | 1 |
| Reversing lamp inoperative (4.6.1 (a)) | 1 |
| Windscreen has damage | 1 |
| Offside Rear Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Rear Rear position lamp|s| insecure |1.1.A.3a| | 1 |