| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 17 |
| Brakes imbalanced across an axle | 9 |
| Windscreen washer not working | 3 |
| Offside Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 2 |
| Anti-lock braking system warning lamp indicates an ABS fault | 2 |
| Service brake: efficiency below requirements |3.7.B.7| | 2 |
| Exhaust has a major leak of exhaust gases rear box / tail pipe (6.1.2 (a)) | 1 |
| Offside Front Suspension component leaking (5.3.5 (c)) | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength Air bag mounting plate (5.3.6 (a) (i)) | 1 |
| Front Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Rear Exhaust system insecure (6.1.2 (a)) | 1 |
| Nearside Side repeater not working (4.4.1 (a) (ii)) | 1 |
| Nearside Inner Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Suspension arm pin or bush excessively worn Front A Frame bush (5.3.4 (a) (i)) | 1 |
| Rear Boot lid likely to become detached (6.2.1 (a) (ii)) | 1 |
| Hazard warning lamps inoperative |1.4.B.1b| | 1 |
| Hazard warning tell tale not working correctly |1.4.B.1e| | 1 |
| Nearside Front Headlamp aim not tested (4.1.2 (b)) | 1 |
| Nearside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Nearside Front Side repeater not working (4.4.1 (a) (ii)) | 1 |
| Exhaust has a major leak of exhaust gases turbo pipe (6.1.2 (a)) | 1 |
| Nearside Rear Position lamp not working |4.2.1 |a|| | 1 |
| Nearside Front Position lamp not working |4.2.1 |a|| | 1 |
| Offside Rear Rear reflector missing |4.8.2 |a| |ii|| | 1 |
| Nearside Rear Direction indicator incorrect colour lens holed (4.4.3 (a)) | 1 |
| Fuel system component leaking link pipe from tank (6.1.3 (b) (i)) | 1 |
| Offside Front Outline marker lamp not working side marker (4.2.1 (a) (ii)) | 1 |
| Windscreen wiper not working (3.4 (a)) | 1 |
| Entrance/exit door remote control inoperative not operating |6.2.C.2| | 1 |
| Nearside Seat belt anchorage loose 2nd row (7.1.1 (b)) | 1 |
| Drivers seat fore and aft adjustment mechanism not functioning as intended. (6.2.5 (b) (i)) | 1 |
| Driving control not working or functioning such that safe operation of the vehicle is affected ignition switch faulty (6.2.7 (a) (ii)) | 1 |
| Seat belt missing DRIVERS SEAT BELT (7.1.2 (a)) | 1 |
| Offside Headlamp aim not tested (4.1.2 (b)) | 1 |
| Offside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Offside Headlamp insecure (4.1.1 (c)) | 1 |
| Offside Stop lamp not working |1.2.1b| | 1 |
| Offside Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Offside Front Headlamp not working on dipped beam osf headlight not working (4.1.1 (a) (ii)) | 1 |
| Rear fog lamp not working |1.3.2b| | 1 |
| Nearside Front Direction indicator not working |4.4.1 |a| |ii|| | 1 |
| Rear fog lamp not working |4.5.1 |a| |ii|| | 1 |
| Exhaust emissions exceed level of metered smoke for a turbo charged engine |8.2.2.2 |b|| | 1 |
| Nearside Headlamp insecure |1.7.3| | 1 |
| Nearside Front Direction indicator not working |1.4.A.2c| | 1 |
| Exhaust emits an excessive level of metered smoke for a turbo charged engine |7.4.B.3b| | 1 |
| Offside Front Braking system leaking tank or pipe (1.1.3 (d)) | 1 |
| Nearside Front Brake hose leaking on an air braking system (1.1.12 (c) (i)) | 1 |
| Stop lamp(s) all not working (4.3.1 (a) (iii)) | 1 |
| Steering box leaking to the extent that oil is dripping (2.1.1 (e) (ii)) | 1 |
| Nearside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner wheel arch area`s |5.3.6 |a| |i|| | 1 |
| Nearside Front Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting inner wheel arch area`s |6.2.2 |d| |i|| | 1 |
| Offside Front Track rod end ball joint has excessive play marked in yellow |2.1.3 |b| |i|| | 1 |
| Offside Front Steering component mounting prescribed area is excessively corroded |2.1.2 |e| |i|| | 1 |
| Offside Front Steering linkage insecure to the extent there is excessive movement at the mountings steering arm - marked in yellow |2.1.3 |a| |ii|| | 1 |
| Nearside Front Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 1 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 1 |
| Nearside Rear Braking system leaking with foot brake applied air leak at nearside rear (1.1.3 (d)) | 1 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 1 |
| Offside Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Nearside Front Axle king pin is loose in the axle beam (5.1.2 (d) (i)) | 1 |
| Offside Front Axle king pin is loose in the axle beam (5.1.2 (d) (i)) | 1 |
| Nearside Rear Air/vacuum reservoir insecurely mounted strap broken |3.6.A.2a| | 1 |
| Speedometer cannot be illuminated |7.8 |c| |ii|| | 1 |
| Nearside Rear Braking system leaking chamber area (1.1.3 (d)) | 1 |
| Nearside Front Steering component mounting prescribed area is excessively corroded crossmember (2.1.2 (e) (i)) | 1 |
| Offside Front Braking system leaking air leak at o/s/f modulator valve area |1.1.3 |d|| | 1 |
| Nearside Rear Lower Stop lamp not working |1.2.1b| | 1 |
| Offside Indicator tell tale inoperative |1.4.A.2a| | 1 |
| Offside Front Brake pipe likely to become detached or damaged (1.1.11 (d) (ii)) | 1 |
| Service brake efficiency less than 50% of the required value (1.2.2 (a) (ii)) | 1 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Offside Front Braking system leaking (1.1.3 (d)) | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |