| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 9 |
| Windscreen washer not working | 8 |
| Brakes imbalanced across an axle | 5 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 3 |
| Brake hose excessively deteriorated | 3 |
| Registration plate lamp issues | 2 |
| Central Air/vacuum reservoir inadequately mounted offside chassis rail corroded to excess near air tank mounting (1.1.9 (c)) | 2 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength chassis rail/chassis to body mount near shocker mounting (5.3.6 (a) (i)) | 2 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength chassis/chassis to body mount near shocker mounting (5.3.6 (a) (i)) | 2 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 2 |
| Hazard warning lamps inoperative (4.4.1 (e)) | 2 |
| Offside Rear Suspension bellows leaking (5.3.5 (c)) | 2 |
| Offside Rear Outline marker lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Rear Suspension component fractured upper tie bar/compression strut (5.3.3 (b) (ii)) | 1 |
| Brake warning device not identifying low pressure (1.1.4 (a) (ii)) | 1 |
| Offside Front Suspension component leaking (5.3.5 (c)) | 1 |
| Nearside Rear Brake slack adjuster incorrectly adjusted (1.1.18 (a)) | 1 |
| Nearside Front All direction indicators not working |4.4.1 |a| |ii|| | 1 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Offside Rear Suspension bellows leaking Air (5.3.5 (c)) | 1 |
| Offside Rear Service brake has no recorded effort at a wheel (1.2.1 (a) (ii)) | 1 |
| Offside Rear Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Offside Front Position lamp not working |4.2.1 |a|| | 1 |
| Offside Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced (6.1.1 (c) (i)) | 1 |
| Nearside Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced (6.1.1 (c) (i)) | 1 |
| Nearside Rear Inner Seat belt webbing significantly weakened (7.1.2 (b) (ii)) | 1 |
| Nearside Inner Steering linkage ball joint has excessive play track rod end (2.1.3 (b) (i)) | 1 |
| Nearside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Nearside Headlamp aim not tested (4.1.2 (b)) | 1 |
| Offside Windscreen wiper not working (3.4 (a)) | 1 |
| Offside Body has an unsafe modification (6.2.1 (d) (i)) | 1 |
| Steering arm deformed to the extent that steering is affected (2.1.3 (c) (ii)) | 1 |
| Rear fog lamp missing (4.5.1 (a) (ii)) | 1 |
| Offside Front Seat belt missing (7.1.2 (a)) | 1 |
| Nearside Rear Air/vacuum reservoir insecure rear 1 of 2 straps corroded through |1.1.9 |c|| | 1 |
| Offside Front Headlamp insecure |4.1.1 |c|| | 1 |
| Offside Headlamp aim not tested |4.1.2 |b|| | 1 |
| Nearside Front Bumper damaged and likely to cause injury when grazed or contacted |6.1.4 |a| |i|| | 1 |
| Offside Front Bumper damaged and likely to cause injury when grazed or contacted |6.1.4 |a| |i|| | 1 |
| Nearside Rear Bumper damaged and likely to cause injury when grazed or contacted |6.1.4 |a| |i|| | 1 |
| Offside Front Braking system leaking under vehicle |1.1.3 |d|| | 1 |
| Offside Rear Braking system leaking under vehicle |1.1.3 |d|| | 1 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 1 |
| Offside Obligatory mirror seriously damaged, affecting the rear view (3.3 (b) (ii)) | 1 |
| Nearside Rear Position lamp not working |4.2.1 |a|| | 1 |
| Offside Rear Position lamp not working |4.2.1 |a|| | 1 |
| Offside Front Upper Shock absorber detached |2.7.2b| | 1 |
| Offside Front Outer Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Vehicle structure is fractured and structural rigidity is significantly reduced Crossmember in front of front axle (6.1.1 (a) (i)) | 1 |
| Offside Rear Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced Axle subframe on rear section o/s below shock absorber (6.1.1 (c) (i)) | 1 |
| Nearside Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced Chassis outrigger corrode in front of rear axle subframe (6.1.1 (c) (i)) | 1 |
| Rear Braking system leaking Air leak over rear axle causing rapid loss of air with engine off (1.1.3 (d)) | 1 |
| Nearside Front Headlamp insecure (4.1.1 (c)) | 1 |
| Rear Bumper damaged and likely to cause injury when grazed or contacted corroded and holed top (6.1.4 (a) (i)) | 1 |
| Nearside Rear Subframe mounting prescribed area excessively corroded significantly reducing structural strength under rear air bag rear face corroded and holed (5.3.6 (a) (i)) | 1 |
| Horn not working |7.7 |a| |ii|| | 1 |
| Nearside Rear Brake pipe leaking on an air braking system above axle (1.1.11 (b) (i)) | 1 |
| Exhaust emits excessive smoke or vapour likely to obscure the vision of other road users (8.2.2.2 (c)) | 1 |
| Offside Rear Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Nearside Rear Seat belt retracting mechanism defective |5.2.5b| | 1 |
| Nearside Direction indicators flashing more than 120 times a minute |1.4.A.2g| | 1 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Nearside Rear Electrical wiring damaged and bare wires exposed |1.9.2c| | 1 |
| Air suspension leaking |2.4.D.2| | 1 |
| Rear brake binding | 1 |
| rear brakes release unevenly |3.7.B.4| | 1 |
| Front Brake warning device defective AIR GAUGE FAULT |no 1| |3.3.E.1b| | 1 |
| Rear Braking system leaking (1.1.3 (d)) | 1 |
| Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Nearside Upper Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Nearside Rear Upper Position lamp with a multiple light source more than 1/2 not functioning (4.2.1 (a) (ii)) | 1 |
| Offside Front Brake pipe likely to become detached or damaged Air pipe insecure (1.1.11 (d) (ii)) | 1 |
| Nearside Front Leaf spring to axle fixing bolt missing Rear bolt missing (5.3.1 (a) (i)) | 1 |
| Offside Rear Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced Crossmember at front of rear axle (6.1.1 (c) (i)) | 1 |
| Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced Both rear sidemembers at front of rear axle (6.1.1 (c) (i)) | 1 |
| Nearside Rear Passengers seat insecure mounting bolt missing (seat with belts attached) (6.2.6 (a) (ii)) | 1 |
| Offside Rear Emergency exit door cannot be opened from outside the vehicle seized handle (9.1.2 (a)) | 1 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Rear Drag link end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Nearside Rear Service brake effort inadequate at a wheel (1.2.1 (a) (i)) | 1 |
| Offside Rear Service brake effort inadequate at a wheel (1.2.1 (a) (i)) | 1 |
| Central Front Hydraulic fluid leaking excessively |8.4.1 |a| |i|| | 1 |
| Nearside Rear Direction indicator not working (4.4.1 (a) (ii)) | 1 |
| Offside Front Inner Headlamp not working on dipped beam INOP (4.1.1 (a) (ii)) | 1 |
| Offside Front Lower Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Nearside Front Steering locking device ineffective BOTH TRACK ROD CASTLE NUT SPLIT PINS NOT LOCKING THROUGH NUTS (2.1.3 (d)) | 1 |
| Nearside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Offside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Offside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Rear Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced at wheel arch (6.1.1 (c) (i)) | 1 |
| Nearside Front Outer Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| front brake recording little or no effort |3.7.B.5a| | 1 |
| Service brake: efficiency below requirements |3.7.B.7| | 1 |