| Most common failures | No# failures |
|---|
| Registration plate lamp issues | 13 |
| Headlamp aim out of alignment | 12 |
| Rear brake binding | 9 |
| Parking brake: efficiency below requirements |3.7.B.7| | 8 |
| Brakes imbalanced across an axle | 7 |
| Rear parking brake recording little or no effort | 6 |
| Service brake: efficiency below requirements |3.7.B.7| | 5 |
| Nearside Headlamp not working on main beam |1.7.5a| | 5 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 5 |
| Offside Headlamp not working on main beam |1.7.5a| | 4 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 4 |
| Horn not working |1.6.2a| | 3 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 3 |
| Registration plate issues | 3 |
| Windscreen wiper does not clear the windscreen effectively | 3 |
| Windscreen washer not working | 3 |
| Nearside Stop lamp not working |1.2.1b| | 3 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 3 |
| Front passenger door cannot be opened from inside the vehicle |6.2.B.1b| | 2 |
| Direction indicators not working |1.4.A.2c| | 2 |
| Nearside Rear Direction indicator not working |1.4.A.2c| | 2 |
| Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| All position lamps not working |1.1.A.3b| | 2 |
| Windscreen washer control missing |8.2.1a| | 2 |
| Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 2 |
| Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 2 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Nearside front brake binding |3.7.B.1| | 2 |
| Offside Stop lamp not working |1.2.1b| | 2 |
| Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Front Headlamp does not operate immediately when selected on main beam |1.7.4a| | 1 |
| Offside Front Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 1 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 1 |
| Front passenger door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
| Nearside Lower Front suspension ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Front Statutory seat belt missing |5.1.1| | 1 |
| Offside Front Statutory seat belt missing |5.1.1| | 1 |
| Battery insecure |1.9.1| | 1 |
| Nearside Front Lower Suspension arm locating pin locking device missing |2.4.G.3b| | 1 |
| Nearside Front Direction indicator not working |4.4.1 |a| |ii|| | 1 |
| Offside Rear Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
| Nearside Front Windscreen wiper blade missing |3.4 |b| |ii|| | 1 |
| Nearside Fuel pipe insecure |6.1.3 |a| |i|| | 1 |
| Offside Front Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced |6.1.1 |c| |i|| | 1 |
| Nearside Outer Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting Sill corroded, |6.2.2 |d| |i|| | 1 |
| Offside Front Obligatory mirror missing |3.3 |a|| | 1 |
| Offside Front Lower Anti-roll bar linkage insecurely attached |5.3.3 |a| |i|| | 1 |
| Offside Rear Lower Suspension rod pin or bush excessively worn Front bush |5.3.4 |a| |i|| | 1 |
| Nearside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt |5.3.4 |b| |ii|| | 1 |
| Service brake efficiency less than 50% of the required value |1.2.2 |a| |ii|| | 1 |
| Parking brake efficiency less than 50% of the required value |1.4.2 |a| |ii|| | 1 |
| Nearside Front Upper Suspension arm locating pin locking device not properly locked |2.4.G.3b| | 1 |
| Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Front Lower Shock absorber detached |2.7.2b| | 1 |
| Rear Trailing arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Steering column top mounting bracket insecure |2.1.2d| | 1 |
| Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Inner Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
| Hazard warning tell tale not working correctly |1.4.B.1e| | 1 |
| Indicator tell tale inoperative only works for one flash left or right |1.4.A.2a| | 1 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Nearside Front Shock absorber insecure |2.7.2b| | 1 |
| Nearside Front Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
| Offside Front Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
| Nearside Rear Wheel bearing play so excessive it is likely to break up |5.1.3 |a| |ii|| | 1 |
| Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
| Offside Rear Wheel nut|s| loose |4.2.A.1e| | 1 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Inner Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Outer Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 1 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Headlamp not working on main beam |1.7.5a| | 1 |
| Horn not working (7.7 (a) (ii)) | 1 |
| Nearside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Rear Suspension arm corroded and seriously weakened |2.4.G.1| | 1 |
| Offside Rear Suspension arm corroded and seriously weakened |2.4.G.1| | 1 |
| Nearside Anti-roll bar which is adjustable, locking device missing |2.4.G.1| | 1 |
| Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Nearside front brake juddering severely |3.7.A.2b| | 1 |
| Position lamp switch faulty |1.1.A.1| | 1 |
| Nearside Body has a sharp edge caused by damage |6.1.C.1| | 1 |
| Headlamp switch faulty |1.7.1| | 1 |
| Nearside Front Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Dipswitch operation does not deflect all main beam headlamps to make them dipped beams (4.1.3 (b)) | 1 |
| Stop lamp(s) all not working (4.3.1 (a) (iii)) | 1 |
| rear brake recording little or no effort |3.7.B.5a| | 1 |
| Offside Front Service brake lagging in operation (1.2.1 (d)) | 1 |
| Offside Front Service brake excessively binding (1.2.1 (f)) | 1 |
| Offside Rear Upper Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Offside Front Upper Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Rear Lower Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Rear Suspension arm attachment bracket/mounting corroded and its strength is seriously reduced |2.4.G.1| | 1 |
| Nearside Rear Suspension arm attachment bracket/mounting corroded and its strength is seriously reduced |2.4.G.1| | 1 |
| Nearside Front Anti-roll bar attachment bracket/mounting corroded and its strength is seriously reduced |2.4.G.1| | 1 |
| Offside Front Anti-roll bar attachment bracket/mounting corroded and its strength is seriously reduced |2.4.G.1| | 1 |
| Nearside Front Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
| Offside Front Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
| Offside front brake binding |3.7.B.1| | 1 |
| Rear Exhaust system not adequately supported hanging rubber mounting broken |7.1.1| | 1 |
| Fuel cap/sealing device does not fasten securely by positive means |7.2.4b| | 1 |
| Offside Front Track rod end ball joint has excessive play inner and outer (2.1.3 (b) (i)) | 1 |
| Nearside Front Track rod end ball joint has excessive play outer (2.1.3 (b) (i)) | 1 |
| Offside Front Driver`s door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
| Nearside Front Inner Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Headlamp not in good working order |not working| |1.2.4a| | 1 |
| Direction indicators not in good working order |function impaired| |1.5.A1b| | 1 |
| Nearside Front Brake pipe inadequately supported |3.6.B.1| | 1 |
| Brake performance not tested |3.7.A.1| | 1 |
| Nearside Inner Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings Sill |6.1.B.2| | 1 |
| Rear Stop lamp not working |1.2.1b| | 1 |
| Brake hose damaged | 1 |
| Offside Front Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 1 |
| Offside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Front Lower Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |