| Most common failures | No# failures |
|---|
| Registration plate lamp issues | 155 |
| Headlamp aim out of alignment | 57 |
| Windscreen wiper does not clear the windscreen effectively | 26 |
| Offside Front coil spring broken |2.4.C.1a| | 17 |
| Registration plate issues | 14 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 13 |
| Nearside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 11 |
| Offside Front Coil spring fractured or broken (5.3.1 (b) (i)) | 11 |
| Brakes imbalanced across an axle | 11 |
| Nearside Front Coil spring fractured or broken (5.3.1 (b) (i)) | 10 |
| Offside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 10 |
| Parking brake: efficiency below requirements |3.7.B.7| | 10 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 10 |
| Nearside Front coil spring broken |2.4.C.1a| | 8 |
| Nearside Front Inner Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 8 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 8 |
| Rear parking brake recording little or no effort | 6 |
| Nearside Front Coil spring fractured or broken |5.3.1 |b| |i|| | 6 |
| Offside Rear Coil spring fractured or broken (5.3.1 (b) (i)) | 6 |
| Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 6 |
| Nearside Front Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 6 |
| Nearside Rear Direction indicator incorrect colour |1.4.A.2f| | 5 |
| Nearside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 5 |
| Offside Side repeater not working |1.4.A.2c| | 5 |
| Offside Front Coil spring fractured or broken |5.3.1 |b| |i|| | 5 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 5 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 5 |
| Windscreen washer not working | 5 |
| Offside Rear Direction indicator incorrect colour |1.4.A.2f| | 5 |
| Offside Front Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 5 |
| Offside Front Lower Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 4 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 4 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 4 |
| Nearside Steering rack gaiter insecure |2.2.D.2d| | 4 |
| Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 4 |
| Offside Front Inner Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 4 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds manufacturers specified limits (8.2.1.2 (a)) | 4 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 4 |
| Nearside Front Suspension arm pin or bush excessively worn rear bush (5.3.4 (a) (i)) | 4 |
| Nearside Rear Coil spring fractured or broken (5.3.1 (b) (i)) | 4 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 4 |
| Nearside Side repeater not working |1.4.A.2c| | 4 |
| Brake pipe excessively corroded | 4 |
| Parking brake lever has no reserve travel |3.1.6b| | 4 |
| Offside Front Inner Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 4 |
| rear parking |secondary| brakes imbalanced | 3 |
| Front Exhaust system insecure (6.1.2 (a)) | 3 |
| Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 3 |
| Nearside Side repeater not working (4.4.1 (a) (ii)) | 3 |
| Rear brake binding | 3 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 3 |
| Horn not working |1.6.2a| | 3 |
| Nearside Front Shock absorber has a serious fluid leak |2.7.3| | 3 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 3 |
| Offside Rear Anti-roll bar linkage pin or bush excessively worn (5.3.4 (a) (i)) | 3 |
| Rear brake disc in such a condition that it is seriously weakened | 3 |
| Offside Front Suspension arm pin or bush excessively worn rear bush (5.3.4 (a) (i)) | 3 |
| Nearside Front Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 3 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 3 |
| Offside Front Inner Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 3 |
| Electronic stability control warning lamp indicates a fault (7.12 (e)) | 3 |
| Windscreen has damage | 3 |
| Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 3 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 3 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 2 |
| Offside Rear Anti-roll bar linkage fractured (5.3.3 (b) (ii)) | 2 |
| Offside Front Road wheel fixing missing |5.2.1 |a| |i|| | 2 |
| Nearside Front Suspension arm rubber bush bonding deteriorated resulting in excessive movement |2.4.G.2| | 2 |
| Offside Parking brake inoperative on one side (1.4.1 (a)) | 2 |
| Horn not working |7.7 |a| |ii|| | 2 |
| Nearside Rear Rear wheel bearing rough when rotated |2.6.1| | 2 |
| Offside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 2 |
| Offside Front Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 2 |
| Nearside Front Anti-roll bar ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 2 |
| Offside Side repeater not working (4.4.1 (a) (ii)) | 2 |
| Supplementary restraint system warning lamp indicates a fault (7.1.6 (a)) | 2 |
| Exhaust carbon monoxide content at idle exceeds manufacturers specified limits (8.2.1.2 (b)) | 2 |
| Offside Front Suspension arm pin or bush excessively worn Rear bush (5.3.4 (a) (i)) | 2 |
| Nearside Front Lower Suspension arm pin or bush excessively worn |5.3.4 |a| |i|| | 2 |
| Offside Front Lower Suspension arm pin or bush excessively worn |5.3.4 |a| |i|| | 2 |
| Nearside Windscreen wiper not working (3.4 (a)) | 2 |
| Nearside Front Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 2 |
| Nearside Front Steering rack gaiter insecure |2.2.D.2d| | 2 |
| Nearside Rear Direction indicators incorrect colour |1.4.A.2f| | 2 |
| Nearside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 2 |
| Electronic stability system warning lamp indicates a fault |3.4.1c| | 2 |
| Brake pedal anti-slip provision missing |3.3.A.1b| | 2 |
| Fuel cap/sealing device ineffective (6.1.3 (b) (i)) | 2 |
| Nearside Front wheel bearing rough when rotated |2.5.A.2| | 2 |
| Nearside Rear Direction indicator incorrect colour (4.4.3 (a)) | 2 |
| Rear Exhaust has a major leak of exhaust gases |6.1.2 |a|| | 2 |
| Offside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 2 |
| Nearside Headlamp cleaning device inoperative |1.7.2| | 2 |
| Offside Headlamp cleaning device inoperative |1.7.2| | 2 |
| Offside Rear Shock absorber has a serious fluid leak |2.7.3| | 2 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 2 |
| Offside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 2 |
| Offside Front Side repeater not working |1.4.A.2c| | 2 |
| Offside Front Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 2 |
| Nearside Front Suspension arm pin or bush excessively worn |5.3.4 |a| |i|| | 2 |
| Offside Front Suspension arm pin or bush excessively worn |5.3.4 |a| |i|| | 2 |
| Nearside Front Inner Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 2 |
| Offside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 2 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 2 |
| Offside Front Anti-roll bar ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 2 |
| Nearside Rear Position lamp not working (4.2.1 (a) (ii)) | 2 |