Most common failures | No# failures |
---|
Headlamp aim out of alignment | 21 |
Windscreen wiper does not clear the windscreen effectively | 12 |
Service brake: efficiency below requirements |3.7.B.7| | 11 |
Brakes imbalanced across an axle | 11 |
Brake pipe excessively corroded | 9 |
Nearside Headlamp not working on main beam |1.7.5a| | 7 |
Registration plate lamp issues | 7 |
Parking brake: efficiency below requirements |3.7.B.7| | 7 |
Rear brake binding | 6 |
Horn not working |1.6.2a| | 4 |
Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 4 |
Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 4 |
Nearside Headlamp not working on dipped beam |1.7.5a| | 4 |
Offside Headlamp not working on main beam |1.7.5a| | 3 |
Nearside Stop lamp not working |1.2.1b| | 3 |
Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
Battery insecure |1.9.1| | 3 |
Direction indicators flashing less than 60 times a minute |1.4.A.2g| | 2 |
Nearside Front Steering component mounting prescribed area is excessively corroded |2.2.C.1h| | 2 |
Nearside Front position lamp|s| not working |1.1.A.3b| | 2 |
Nearside Front Headlamp not working on dipped beam |1.7.5a| | 2 |
Nearside Front Direction indicators not working |1.4.A.2c| | 2 |
Offside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 2 |
Nearside Headlamp aim beam image kick up to the offside |1.8| | 2 |
Offside Headlamp aim beam image kick up to the offside |1.8| | 2 |
Nearside Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
Nearside Front Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
Nearside Front Ball joint has excessive play |2.2.B.1f| | 2 |
Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
Offside Front Service brake excessively binding (1.2.1 (f)) | 2 |
Headlamp not working on main beam |1.7.5a| | 2 |
Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
Rear parking brake recording little or no effort | 2 |
Offside Front Headlamp not working on dipped beam |1.7.5a| | 2 |
Offside Front position lamp|s| not working |1.1.A.3b| | 2 |
Exhaust system not adequately supported |7.1.1| | 2 |
Nearside Front Direction indicator not working |1.4.A.2c| | 2 |
Offside Headlamp not working on dipped beam |1.7.5a| | 2 |
Nearside Rear Stop lamp not working |1.2.1b| | 2 |
Driver`s door cannot be opened from outside the vehicle |6.2.B.1b| | 2 |
Centre Exhaust system not adequately supported |7.1.1| | 1 |
Offside Front Steering component mounting prescribed area is excessively corroded |2.2.C.1h| | 1 |
Service brake is causing the vehicle to swerve to the nearside |3.7.C.2| | 1 |
Offside Driver`s door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
Registration plate issues | 1 |
Fuel pipe leaking |7.2.3| | 1 |
Nearside Rear Suspension component mounting prescribed area is excessively corroded inner sill |2.4.A.3| | 1 |
Offside Front Shock absorber has an excessively worn bush |2.7.4| | 1 |
rear parking |secondary| brakes imbalanced | 1 |
Offside Stop lamp not working |1.2.1b| | 1 |
Offside Front Anti-roll bar attachment bracket/mounting corroded and its strength is seriously reduced |2.4.G.1| | 1 |
Rear Fuel pipe leaking |7.2.3| | 1 |
rear brakes release unevenly |3.7.B.4| | 1 |
Offside Outer Parking brake mechanism/associated mounting prescribed area is excessively corroded |3.1.9| | 1 |
Nearside Outer Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Nearside Outer Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Offside Outer Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Nearside Front Shock absorber insecure |2.7.2b| | 1 |
Offside Front Shock absorber insecure |2.7.2b| | 1 |
Nearside Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
Offside Vehicle structure has a modification which adversely affects braking or steering |6.1.A.1| | 1 |
Offside Brake pipe stretched |found during steering lock to lock check| |2.2.D.2b| | 1 |
Offside rear brake recording little or no effort |3.7.B.5a| | 1 |
Nearside Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
Offside Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
Nearside Front Passenger`s seat insecure |6.2.A.1| | 1 |
Nearside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Steering box has a significant oil leak |2.2.D.2e| | 1 |
Offside Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Nearside Rear Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
Offside Rear Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
Nearside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Outer Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
Offside Inner Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
Nearside Drag link end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
Offside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
Front Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
Steering box insecure |2.2.B.1a| | 1 |
Nearside Front Headlamp not working on main beam |1.7.5a| | 1 |
Parking brake lever has no reserve travel |3.1.6b| | 1 |
Tailgate cannot be secured in the closed position |6.4.1| | 1 |
Nearside Front Seat belt retracting mechanism defective |5.2.5b| | 1 |
Nearside Front Ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
Nearside Front Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Headlamp not working on dipped beam |1.7.5a| | 1 |
Nearside Headlamp insecure |1.7.3| | 1 |
Nearside front brake binding |3.7.B.1| | 1 |
Nearside Front Wheel insecure |4.2.A.1c| | 1 |
Offside Front Upper Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
Driver`s seat cannot be secured in the upright position. |6.2.A.2| | 1 |
Nearside Passenger`s seat cannot be secured in the upright position. |6.2.A.2| | 1 |
Nearside Front Seat belt damaged sufficient to obstruct correct operation of the belt |5.2.2a| | 1 |
Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
Position lamp switch faulty |1.1.A.1| | 1 |
Rear Exhaust system not adequately supported |7.1.1| | 1 |
Offside Front Seat belt retracting mechanism defective |5.2.5b| | 1 |
Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
Fuel system component leaking |7.2.3| | 1 |
Indicator tell tale inoperative |1.4.A.2a| | 1 |
Nearside Rear brake disc has restricted free movement |3.5.1j| | 1 |
Offside Rear brake disc has restricted free movement |3.5.1j| | 1 |
Steering box has relative movement between sector shaft and the drop arm |2.2.B.1b| | 1 |
Hazard warning tell tale not working correctly |1.4.B.1e| | 1 |
Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
Offside Front Brake hose connection leaking on a hydraulic braking system (1.1.12 (c) (ii)) | 1 |
Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings Bonnet mounts insecure |6.1.B.2| | 1 |
Offside front brake binding |3.7.B.1| | 1 |
Brake pedal reservoir fluid level decreases after several brake applications |3.3.C.1| | 1 |
Brake pedal creeps down while the pedal is held under pressure |3.3.B.1a| | 1 |
Nearside Rear brake disc contaminated by brake fluid |3.5.1h| | 1 |
Offside Rear brake disc contaminated by oil |3.5.1h| | 1 |
Front Exhaust system not adequately supported |7.1.1| | 1 |
Brake performance not tested |3.7.A.1| | 1 |
Nearside Front brake disc excessively pitted |3.5.1h| | 1 |
Offside Front brake disc excessively pitted |3.5.1h| | 1 |
Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
Offside Headlamp light intensity severely reduced (4.1.4 (a)) | 1 |
Nearside Front Direction indicator incorrect colour (4.4.3 (a)) | 1 |
Offside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
Nearside Front Steering component mounting prescribed area is corroded to the extent that control of the vehicle is likely to be adversely affected inner arch area (2.1.2 (e) (ii)) | 1 |
Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength crossmember (5.3.6 (a) (i)) | 1 |
Offside Front Steering linkage ball joint ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
Nearside Front Steering linkage ball joint ball joint dust cover insecure so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
Offside Front Upper Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
Offside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
Service brake efficiency less than 50% of the required value (1.2.2 (a) (ii)) | 1 |
Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 1 |
Nearside Rear reflector excessively damaged so that its function is impaired |1.5.1c| | 1 |
Offside Rear Panhard rod has excessive play in a pin/bush |2.4.G.2| | 1 |
Nearside Obligatory mirror seriously deteriorated, affecting the rear view |8.1.2a| | 1 |
Offside Obligatory mirror seriously deteriorated, affecting the rear view |8.1.2a| | 1 |
Nearside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings sill |6.1.B.2| | 1 |
Offside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings sill |6.1.B.2| | 1 |
Offside Front front brake binding |3.7.B.1| | 1 |
Offside Obligatory mirror missing |8.1.1| | 1 |
Nearside Front Battery insecure |1.9.1| | 1 |
Centre Front Vehicle structure has an inadequate repair, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Front Vehicle structure has an unsatisfactory modification, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Front Vehicle structure is cracked, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Exhaust emits clearly visible black smoke during acceleration |7.3.A.2c| | 1 |
Fuel hose leaking (7.2.3) | 1 |
Nearside Front Upper Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
Nearside Front front brake grabbing severely |3.7.A.2b| | 1 |
Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
Nearside Steering retaining device missing |2.2.C.1g| | 1 |
Nearside Front Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Nearside Front Brake hose excessively damaged |3.6.B.4d| | 1 |
Front Fuel hose leaking |7.2.3| | 1 |
Main beam `tell-tale` not working |1.7.4c| | 1 |
Nearside Front suspension has a suspension lower ball joint securing nut not locked |2.5.B.1a| | 1 |
Offside Front suspension has a suspension lower ball joint securing nut not locked |2.5.B.1a| | 1 |
Headlamp aim not tested |1.8.A.1c| | 1 |
Brake linkage has abnormal movement of levers indicating excessive wear |3.5.1f| | 1 |
Nearside Rear Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
Offside Rear Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Offside Rear Steering component mounting prescribed area is excessively corroded |2.2.C.1h| | 1 |
Offside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Nearside Front front brake juddering severely |3.7.A.2b| | 1 |
Offside Front front brake juddering severely |3.7.A.2b| | 1 |
Offside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
Nearside Front Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 1 |
Offside Front Headlamp not working on main beam |1.7.5a| | 1 |
Nearside Front Headlamp not in a clean condition affecting beam image |1.2.4a| | 1 |
Offside Rear Stop lamp not working |1.2.1b| | 1 |
Nearside Front Shock absorber has an excessively worn bush |2.7.4| | 1 |
Front Headlamp aim projected beam image is obviously incorrect both |4.1.2 |c|| | 1 |
Nearside Front Passenger`s seat backrest cannot be secured in the upright position. |6.2.6 |a| |i|| | 1 |
Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inside wheel arch |5.3.6 |a| |i|| | 1 |
Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength |5.3.6 |a| |i|| | 1 |
Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inside wheel arch |5.3.6 |a| |i|| | 1 |
Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength |5.3.6 |a| |i|| | 1 |
Offside Front Seat belt anchorage prescribed area is inadequately repaired |7.1.1 |a| |i|| | 1 |
Nearside Front Seat belt anchorage prescribed area is inadequately repaired |7.1.1 |a| |i|| | 1 |
Offside Front Seat belt anchorage prescribed area strength or continuity significantly reduced |7.1.1 |a| |i|| | 1 |
Offside Lower Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Inner Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Nearside Front Track rod end ball pin shank loose |2.2.B.1c| | 1 |
Nearside Front Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
Nearside Front Lower Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Nearside Front Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
Offside Front Direction indicator not working |1.4.A.2c| | 1 |
Nearside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Centre Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Front Upper Steering column flexible coupling is excessively deteriorated |2.1.5| | 1 |
Nearside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Front passenger door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
Driver`s seat insecure |6.2.A.1| | 1 |
Nearside Rear passenger seat cannot be secured in the upright position. |6.2.3| | 1 |
Nearside Upper Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Horn not working (7.7 (a)) | 1 |
Nearside Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
Offside Front Seat belt stitching badly frayed |5.2.2b| | 1 |
Offside Front Front wheel bearing rough when rotated |2.5.A.2| | 1 |
Nearside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Service brake: efficiency below requirements |3.7.C.1a| | 1 |