Most common failures | No# failures |
---|
Headlamp aim out of alignment | 21 |
Windscreen wiper does not clear the windscreen effectively | 13 |
Brakes imbalanced across an axle | 11 |
Rear brake binding | 11 |
Brake pipe excessively corroded | 8 |
Parking brake: efficiency below requirements |3.7.B.7| | 8 |
Offside Front position lamp|s| not working |1.1.A.3b| | 8 |
Parking brake: efficiency below requirements |3.7.C.1b| | 7 |
Registration plate lamp issues | 7 |
Nearside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 7 |
Rear Exhaust system not adequately supported |7.1.1| | 6 |
Nearside Front position lamp|s| not working |1.1.A.3b| | 6 |
Rear parking brake recording little or no effort | 5 |
Parking brake lever has no reserve travel |3.1.6b| | 5 |
Offside Stop lamp not working |1.2.1b| | 5 |
Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 5 |
Nearside Rear position lamp|s| not working |1.1.A.3b| | 5 |
Service brake: efficiency below requirements |3.7.B.7| | 4 |
Horn not working |1.6.2a| | 4 |
Offside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 4 |
Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 4 |
Nearside Headlamp not working on dipped beam |1.7.5a| | 4 |
Nearside Stop lamp not working |1.2.1b| | 4 |
Rear Exhaust has a major leak of exhaust gases |7.1.2| | 4 |
Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 4 |
Nearside Rear wheel bearing has excessive play |2.6.2| | 4 |
Nearside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 3 |
Rear Mechanical brake component has restricted free movement | 3 |
Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
Rear brake application uneven | 3 |
Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 2 |
Fuel tank leaking |7.2.3| | 2 |
Offside Front wheel bearing rough when rotated |2.5.A.2| | 2 |
Direction indicators not working |1.4.A.2c| | 2 |
Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 2 |
Exhaust system not adequately supported |7.1.1| | 2 |
Offside Rear Direction indicator not working |1.4.A.2c| | 2 |
Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
Offside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
Offside Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 2 |
Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
Mechanical brake component has restricted free movement | 2 |
Brake performance not tested |3.7.A.1| | 2 |
Offside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
Nearside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 2 |
Offside Front Brake master cylinder/servo mounting prescribed area is excessively corroded |3.6.C.3| | 2 |
Nearside front brake binding |3.7.B.1| | 2 |
Offside Headlamp not working on dipped beam |1.7.5a| | 2 |
Nearside Front Shock absorber has an excessively worn bush |2.7.4| | 2 |
Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 2 |
Offside Rear position lamp|s| not working |1.1.A.3b| | 2 |
Nearside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 2 |
Driver`s door cannot be opened from outside the vehicle |6.2.B.1b| | 2 |
Nearside Rear Direction indicator not working |1.4.A.2c| | 2 |
Offside Front Lower Body has a sharp edge caused by corrosion |6.1.C.1| | 2 |
Indicator switch faulty |1.4.A.1| | 2 |
Offside Rear wheel bearing has excessive play |2.6.2| | 2 |
Offside Front Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
Offside Front Front suspension has excessive play in a upper wishbone bearing |2.5.B.1a| | 1 |
Nearside Rear Braking system leaking |3.6.A.1| | 1 |
Nearside rear brake recording little or no effort |3.7.B.5a| | 1 |
Brake hose excessively deteriorated | 1 |
Brake pipe leaking |3.6.A.1| | 1 |
Brake pipe inadequately supported |3.6.B.1| | 1 |
Nearside Front Track rod end ball joint has excessive play both ball joints |2.2.B.1f| | 1 |
Offside Front Track rod end ball joint has excessive play both ball joints |2.2.B.1f| | 1 |
Offside Inner Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
Offside Outer Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
Offside Headlamp not working on main beam |1.7.5a| | 1 |
Offside Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Rear Service brake is causing the vehicle to swerve to the nearside |3.7.C.2| | 1 |
Offside Rear Brake pipe excessively damaged |3.6.B.2c| | 1 |
Nearside Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 1 |
Nearside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Inner Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Inner Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Inner Front Upper Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Front Upper Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Centre Rear Exhaust system not adequately supported |7.1.1| | 1 |
Offside Inner Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Outer Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 1 |
Nearside Front Passenger`s seat cannot be secured in the upright position. |6.2.A.2| | 1 |
Nearside Rear Suspension component mounting prescribed area is inadequately repaired |2.4.A.3| | 1 |
Offside Body has excessive displacement which may lead to loss of vehicle control |6.1.B.1a| | 1 |
Nearside Body has excessive displacement which may lead to loss of vehicle control |6.1.B.1a| | 1 |
Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Nearside Front Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
Offside Front Seat belt stitching badly frayed |5.2.2b| | 1 |
Offside Front Seat belt damaged sufficient to obstruct correct operation of the belt |5.2.2a| | 1 |
Windscreen has damage | 1 |
Nearside Front Shock absorber has negligible damping effect |2.7.5| | 1 |
Offside Front Shock absorber has negligible damping effect |2.7.5| | 1 |
Nearside Rear Shock absorber has negligible damping effect |2.7.5| | 1 |
Offside Rear Shock absorber has negligible damping effect |2.7.5| | 1 |
Brake pedal creeps down when held under pressure |3.3.B.1a| | 1 |
Nearside Brake pipe leaking |3.6.A.1| | 1 |
Offside Front Upper Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Headlamp insecure |1.7.3| | 1 |
Offside Rear Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Nearside Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 1 |
Nearside Headlamp not working on main beam |1.7.5a| | 1 |
Nearside Steering pivot point has excessive play |2.2.B.1g| | 1 |
Nearside Rear Suspension arm corroded and seriously weakened |2.4.G.1| | 1 |
Brake master cylinder/servo mounting prescribed area is excessively corroded |3.6.C.3| | 1 |
All position lamps not working |1.1.A.3b| | 1 |
Nearside Inner Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Offside Outer Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Nearside Rear Lower Trailing arm corroded and seriously weakened |2.4.G.1| | 1 |
Offside Rear Lower Trailing arm corroded and seriously weakened |2.4.G.1| | 1 |
Offside Rear Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
Registration plate issues | 1 |
Nearside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Nearside Headlamp aim beam image kick up to the offside |1.8| | 1 |
Nearside Front Front position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
Offside front brake binding |3.7.B.1| | 1 |
Offside Inner Front Brake actuating linkage mounting prescribed area is excessively corroded |3.3.A.2| | 1 |
Headlamp does not operate immediately when selected on main beam |1.7.4a| | 1 |
Offside Front Brake master cylinder/servo mounting prescribed area is excessively corroded inner wing |3.6.C.3| | 1 |
Dipswitch operation does not deflect all main beam headlamps to make them dipped beams |1.7.4b| | 1 |
Nearside Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Nearside Inner Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Nearside Outer Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Offside Stop lamp missing |1.2.1a| | 1 |
Nearside Front position lamp|s| incorrect colour |1.1.A.3e| | 1 |
Fuel system component leaking |7.2.3| | 1 |
Fuel system component insecure |7.2.1| | 1 |
Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
Nearside Rear brake drum contaminated by oil |3.5.1h| | 1 |
Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
Nearside Front Steering system has a road wheel fouling a part of the vehicle |2.2.D.2a| | 1 |
Offside Lower Brake hose twisted |found during steering lock to lock check| |2.2.D.2b| | 1 |
Offside Front Lower Braking system leaking |3.6.A.1| | 1 |
Offside Rear Lower Suspension arm corroded and seriously weakened |2.4.G.1| | 1 |
Nearside Rear Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
Offside Rear Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
Nearside Rear wheel cylinder leaking |3.6.A.1| | 1 |
Nearside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
Offside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
Nearside Braking system leaking |3.6.A.1| | 1 |
Offside Front Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength Sill, sill end, arch (5.3.6 (a) (i)) | 1 |
Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength Sill, sill end , arch (5.3.6 (a) (i)) | 1 |
Front passenger door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
Nearside Rear Shock absorber has an excessively worn bush |2.7.4| | 1 |
Offside Rear Lower Shock absorber has an excessively worn bush |2.7.4| | 1 |
Offside Front Braking system leaking |3.6.A.1| | 1 |
Nearside Front Braking system leaking |3.6.A.1| | 1 |
Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings floor |6.1.B.2| | 1 |
Nearside Front Front passenger door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
Brake hose has insufficient room to move | 1 |
Nearside Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
Offside Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
Offside Brake pipe leaking |3.6.A.1| | 1 |
Front Brake pipe inadequately clipped |3.6.B.1| | 1 |
Nearside Rear Trailing arm attachment bracket/mounting insecure |2.4.G.1| | 1 |
Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Front brake application uneven | 1 |
Offside rear brake recording little or no effort |3.7.B.5a| | 1 |
Nearside Front brake caliper leaking |3.6.A.1| | 1 |
Offside Front brake caliper leaking |3.6.A.1| | 1 |
Nearside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
Offside Outer Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Front Lower Shock absorber has an excessively worn bush |2.7.4| | 1 |
Offside Front Lower Shock absorber has an excessively worn bush |2.7.4| | 1 |
Offside Front brake disc excessively pitted |3.5.1h| | 1 |
Nearside Front brake disc excessively pitted |3.5.1h| | 1 |
Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
Nearside Front Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
Offside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Offside Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
Nearside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
Direction indicators flashing less than 60 times a minute |1.4.A.2g| | 1 |
Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Offside Rear Inner Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings WHEEL ARCH |6.1.B.2| | 1 |
Nearside Front Outer Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings SILL |6.1.B.2| | 1 |
Semaphore indicator switch faulty |1.4.C.1c| | 1 |
Brake pipe fouled by moving parts |3.6.B.2a| | 1 |
Nearside Headlamp insecure |1.7.3| | 1 |
Nearside Front Service brake grabbing severely |3.7.C.2| | 1 |
Nearside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings FLOOR |6.1.B.2| | 1 |
Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings FLOOR |6.1.B.2| | 1 |
Nearside Front Inner Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings WING
|6.1.B.2| | 1 |
Offside Front Ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
Nearside Front Brake hose leaking BOTH
|3.6.A.1| | 1 |
Body has a sharp edge caused by corrosion FRONT VALANCE |6.1.C.1| | 1 |
Nearside Front Direction indicator not working |1.4.A.2c| | 1 |
Offside Front Direction indicator not working |1.4.A.2c| | 1 |
Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Nearside Front Steering component mounting prescribed area is excessively corroded |2.2.C.1h| | 1 |
Offside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Nearside front brake juddering severely |3.7.A.2b| | 1 |
Indicator tell tale inoperative |1.4.A.2a| | 1 |
Inner Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
Nearside Outer Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Offside Outer Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Nearside Outer Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Offside Outer Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Steering column flexible coupling is excessively deteriorated |2.1.5| | 1 |
Exhaust mounting missing |7.1.1b| | 1 |
Offside Rear Upper Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
Nearside Front Headlamp aim beam image too far to the right |1.6.B4| | 1 |
Offside Front Headlamp aim beam image too far to the right |1.6.B4| | 1 |
Brake pedal pad not secure to the pedal |3.3.A.1c| | 1 |
Offside Rear Seat belt retracting mechanism defective |5.2.5b| | 1 |
Offside Front Coil spring fractured or broken |5.3.1 |b| |i|| | 1 |
Offside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt |5.3.4 |b| |ii|| | 1 |
Nearside Front Seat belt has a cut which has significantly weakened the webbing |5.2.2a| | 1 |
Offside rear brakes release unevenly |3.7.B.4| | 1 |