| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 13 |
| Registration plate lamp issues | 8 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 7 |
| Engine MIL inoperative or indicates a malfunction (8.2.2.2 (g)) | 5 |
| Brake pipe excessively corroded | 5 |
| Registration plate issues | 4 |
| Anti-lock braking system warning lamp indicates an ABS fault | 3 |
| Nearside Side repeater not working (4.4.1 (a) (ii)) | 3 |
| Windscreen wiper does not clear the windscreen effectively | 3 |
| Nearside Front Anti-roll bar linkage ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 2 |
| Nearside Front Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 2 |
| Electronic stability control warning lamp indicates a fault (7.12 (e)) | 2 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 2 |
| Windscreen washer not working | 2 |
| Exhaust diesel particulate filter shows evidence of tampering. (8.2.2.1 (c)) | 2 |
| Supplementary restraint system warning lamp indicates a fault (7.1.6 (a)) | 2 |
| Offside Front Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 2 |
| Front Service brake excessively fluctuating (1.2.1 (e)) | 2 |
| Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Offside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Nearside All outline marker lamps not working |4.2.1 |a|| | 1 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Nearside Front Subframe mounting prescribed area fractured significantly reducing structural strength |5.3.6 |a| |i|| | 1 |
| Offside Front Anti-roll bar linkage ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Side repeater excessively damaged so that it is not visible from a reasonable distance unti damage not reflecting light enough to be seen |1.4.A.2e| | 1 |
| Nearside Rear reflector missing |1.5.1a| | 1 |
| Offside Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Offside Front Lower Suspension component ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Exhaust emissions exceed manufacturers specified limit 0.60 plate limit (8.2.2.2 (a)) | 1 |
| Offside Front Position lamp not working |4.2.1 |a|| | 1 |
| Offside Rear Stop lamp not working |1.2.1b| | 1 |
| Nearside Front Inner Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 1 |
| Nearside Front Brake hose leaking on a hydraulic braking system (1.1.12 (c) (ii)) | 1 |
| Offside Front Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Brake performance not tested due to leaking brake hose (1.2.1 (g)) | 1 |
| Nearside Front Brake pipe connection leaking on a hydraulic braking system (1.1.11 (b) (ii)) | 1 |
| Rear Direction indicator incorrect colour both rears (4.4.3 (a)) | 1 |
| Offside Front Anti-roll bar pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Side repeater incorrect colour (4.4.3 (a)) | 1 |
| Rear Anti-roll bar pin or bush excessively worn all bushies (5.3.4 (a) (i)) | 1 |
| Electronic power steering warning lamp indicates a system malfunction (2.6 (a)) | 1 |
| Stop lamp(s) all not working (4.3.1 (a) (iii)) | 1 |
| Offside Front Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Offside Front Body component likely to become detached inner wheel arch liner (6.2.1 (a) (ii)) | 1 |
| Offside Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 1 |
| Offside Obligatory mirror does not provide a view to the rear |3.3 |c|| | 1 |
| Offside Bumper damaged and likely to cause injury when grazed or contacted |6.1.4 |a| |i|| | 1 |
| Nearside Front Upper Front position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Offside Outline marker lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Obligatory mirror does not provide a view to the rear (3.3 (c)) | 1 |
| Offside Headlamp aim projected beam image is obviously incorrect no pattern (4.1.2 (c)) | 1 |
| Offside Rear Outline marker lamp not working |4.2.1 |a|| | 1 |
| Offside Front Body panel damaged and likely to cause injury door mirror side repeater |6.2.1 |a| |i|| | 1 |
| Engine MIL inoperative or indicates a malfunction |8.2.2.2 |g|| | 1 |
| Brakes imbalanced across an axle | 1 |
| Offside Front Track rod end ball joint has excessive play |2.1.3 |b| |i|| | 1 |
| Offside Front Obligatory mirror insecure |3.3 |b| |ii|| | 1 |
| Bonnet primary retaining device ineffective bonnet wont open from release inside the vehicle |3.1 |c|| | 1 |
| Offside Body component damaged and likely to cause injury Repeater lamp. (6.2.1 (a) (i)) | 1 |
| Offside Rear Rear reflector missing (4.8.2 (a) (ii)) | 1 |
| Rear Anti-roll bar linkage pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Offside Front Lower Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Nearside Front Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Rear Hydraulic brake calliper leaking (1.1.16 (b) (i)) | 1 |
| Brake hose damaged | 1 |
| Exhaust emissions exceed manufacturers specified limit (8.2.2.2 (a)) | 1 |
| Engine MIL inoperative or indicates a malfunction |8.2.1.2 |h|| | 1 |
| Brake lever has abnormal movement of levers indicating excessive wear or maladjustment |1.1.15 |f|| | 1 |
| Nearside Rear Parking brake inoperative on one side |1.4.1 |a|| | 1 |
| Central Rear Oil leaking excessively from transmission DIFF |8.4.1 |a| |i|| | 1 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Front Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 1 |
| Exhaust emissions exceed manufacturer`s specified limit |8.2.2.2 |a|| | 1 |
| Nearside Rear Stop lamp not working |1.2.1b| | 1 |
| Offside Front Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Offside Side repeater not working (4.4.1 (a) (ii)) | 1 |
| Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Offside Front Service brake excessively fluctuating (1.2.1 (e)) | 1 |
| Nearside Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Offside Front Shock absorbers has a serious fluid leak | 1 |
| Nearside Front Brake hose twisted |found during steering lock to lock check| |2.2.D.2b| | 1 |
| Front Suspension arm pin or bush excessively worn Both sides (5.3.4 (a) (i)) | 1 |
| Nearside Rear Seat belt retracting mechanism defective 1st seat , 2nd seat and 3rd seat . |7.1.2 |e|| | 1 |
| Nearside Front Side repeater not working |1.4.A.2c| | 1 |
| Offside Front Brake hose excessively damaged |3.6.B.4d| | 1 |
| Nearside Front Lower Suspension arm pin or bush excessively worn |5.3.4 |a| |i|| | 1 |
| Offside Front Lower Suspension arm pin or bush excessively worn |5.3.4 |a| |i|| | 1 |
| Nearside Front Track rod end ball joint has excessive play |2.1.3 |b| |i|| | 1 |
| Nearside Front Upper Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Rear Upper Position lamp missing (4.2.1 (a) (ii)) | 1 |
| Offside Rear Upper Position lamp missing (4.2.1 (a) (ii)) | 1 |
| Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Brake pedal has insufficient reserve travel (1.1.2 (a)) | 1 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 1 |
| Offside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt |5.3.4 |b| |ii|| | 1 |
| Offside Rear Suspension unit damaged or deteriorated and function is seriously affected centre air bag not attached to rear axle. axle number 2 (5.3.5 (b) (ii)) | 1 |
| Front Windscreen washer jets misaligned and not providing sufficient fluid to the windscreen (3.5 (a)) | 1 |
| Nearside Front Inner Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced SILL JACKING POINT (6.1.1 (c) (i)) | 1 |
| Offside Rear All outline marker lamps not working (4.2.1 (a) (ii)) | 1 |
| Nearside Headlamp lens seriously defective (4.1.1 (b) (ii)) | 1 |
| Offside Headlamp lens seriously defective (4.1.1 (b) (ii)) | 1 |
| Nearside Front Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Front passenger door cannot be opened from outside the vehicle (6.2.3 (a)) | 1 |
| Rear Other passenger door cannot be opened from outside the vehicle (6.2.3 (a)) | 1 |