| Most common failures | No# failures |
|---|
| Brakes imbalanced across an axle | 6 |
| Headlamp aim out of alignment | 4 |
| Oil leaking excessively from engine (8.4.1 (a) (i)) | 3 |
| Registration plate lamp issues | 3 |
| Exhaust emissions hydrocarbon content excessive (8.2.1.2 (b)) | 3 |
| Rear Brake cable insecure | 3 |
| Brake pipe excessively corroded | 3 |
| Registration plate issues | 3 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 2 |
| Windscreen wiper does not clear the windscreen effectively | 2 |
| Horn not working |1.6.2a| | 2 |
| Exhaust emissions hydrocarbon content excessive |8.2.1.2 |b|| | 2 |
| Exhaust emissions carbon monoxide content excessive (8.2.1.2 (b)) | 2 |
| Windscreen washer not working | 1 |
| Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength |5.3.6 |a| |i|| | 1 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Rear fog lamp not working |4.5.1 |a| |ii|| | 1 |
| Nearside Steering rack gaiter missing or no longer prevents the ingress of dirt |2.1.3 |g| |ii|| | 1 |
| Offside Steering rack gaiter missing or no longer prevents the ingress of dirt |2.1.3 |g| |ii|| | 1 |
| Nearside Front Upper Seat belt anchorage loose |7.1.1 |b|| | 1 |
| Offside Front Seat belt anchorage prescribed area strength or continuity significantly reduced |7.1.1 |a| |i|| | 1 |
| Offside Rear Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front Upper Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Lower Fuel pipe insecure |6.1.3 |a| |i|| | 1 |
| Offside Front Upper Anti-roll bar linkage pin or bush likely to become detached adrift from housing (5.3.4 (a) (ii)) | 1 |
| Braking system leaking servo/pipe leaking behind dash (1.1.3 (d)) | 1 |
| Nearside Front Lower Anti-roll bar linkage pin or bush likely to become detached bush adrift by suspension arm (5.3.4 (a) (ii)) | 1 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 1 |
| Stop lamp(s) all not working (4.3.1 (a) (iii)) | 1 |
| Offside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Nearside Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Offside Front Anti-roll bar pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Windscreen wiper not working (3.4 (a)) | 1 |
| Parking (secondary brake) on a single line braking system imbalanced across an axle Axle 1 (1.3.1 (b) (i)) | 1 |
| Nearside Rear wheel bearing has excessive play |2.6.2| | 1 |
| Front suspension assembly component excessively worn. headstock bearings |9.2.5d| | 1 |
| Windscreen wiper not working (3.4 (a)) | 1 |
| Nearside Direction indicator not working front and rear (4.4.1 (a) (ii)) | 1 |
| Nearside Position lamp not working Front and rear (4.2.1 (a) (ii)) | 1 |
| Offside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Steering locking device missing Both rear hub nut split pins (2.1.3 (d)) | 1 |
| Offside Rear Road wheel fixing missing (5.2.1 (a) (i)) | 1 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 1 |
| Offside Front Speedometer cannot be illuminated. |6.7.3| | 1 |
| Central Front Braking system leaking |3.6.A.1| | 1 |
| Nearside Rear Brake hose inappropriately repaired |3.6.A.3| | 1 |
| Offside Rear Brake hose inappropriately repaired |3.6.A.3| | 1 |
| Offside Front Brake pipe inadequately supported |3.6.B.1| | 1 |
| Front Service brake excessively binding (1.2.1 (f)) | 1 |
| Central Front Brake performance not tested brake pipe burst whilst testing |3.7.A.1| | 1 |
| Offside Front Steering locking device missing |2.2.C.1g| | 1 |
| Central Front Horn not working |1.6.2a| | 1 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Front Headlamp not working on main beam |1.7.5a| | 1 |
| Offside Front front brake binding |3.7.B.1| | 1 |
| Rear brake binding | 1 |
| Nearside Front Upper Front suspension ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front Upper Front suspension ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Front Lower Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Offside Front Lower Shock absorber insecure bolt loose |2.7.2b| | 1 |
| Offside Rear Lower Shock absorber insecure wrong bolt fitted |2.7.2b| | 1 |
| Offside Rear Rear wheel bearing has excessive play |2.6.2| | 1 |
| Central Rear Fuel pipe leaking fuel pipe to pump leak |7.2.3| | 1 |
| Offside Rear Wheel bearing has excessive play (5.1.3 (a) (i)) | 1 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Headlamp not working on main beam |1.7.5a| | 1 |
| Rear fog lamp switch faulty |1.3.1a| | 1 |
| Brake cable has wires broken and is significantly weakened all 3 handbrake cables |3.5.1b| | 1 |
| Nearside Lower Front suspension ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Parking brake: efficiency below requirements |3.7.B.7| | 1 |
| Offside Front Anti-roll bar linkage pin or bush likely to become detached (5.3.4 (a) (ii)) | 1 |
| Exhaust emissions carbon monoxide content excessive |8.2.1.2 |b|| | 1 |
| Parking brake lever has excessive movement indicating incorrect adjustment |1.1.6 |c|| | 1 |
| Service brake efficiency below requirements |1.2.2 |a| |i|| | 1 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 1 |
| Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Nearside Front Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Nearside Front Direction indicator not working (4.4.1 (a) (ii)) | 1 |
| Nearside Windscreen washer jets misaligned and not providing sufficient fluid to the windscreen (3.5 (a)) | 1 |
| Speedometer cannot be illuminated (7.8 (c) (ii)) | 1 |
| Offside Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Nearside Front Seat belt buckle not functioning as intended (7.1.2 (d)) | 1 |