Most common failures | No# failures |
---|
Brakes imbalanced across an axle | 7 |
Headlamp aim out of alignment | 6 |
Service brake: efficiency below requirements |3.7.B.7| | 5 |
Brake hose has insufficient room to move | 5 |
Offside Front position lamp|s| not working |1.1.A.3b| | 4 |
Parking brake lever has no reserve travel |3.1.6b| | 4 |
Horn not working |1.6.2a| | 4 |
Rear brake application uneven | 3 |
Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 3 |
Nearside Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 3 |
Registration plate issues | 3 |
Parking brake: efficiency below requirements |3.7.B.7| | 3 |
Offside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 2 |
Front brake application uneven | 2 |
Nearside Headlamp not working on main beam |1.7.5a| | 2 |
Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
Driver`s seat fore and aft adjustment mechanism not functioning as intended. |6.2.A.3| | 2 |
Offside Rear position lamp|s| not working |1.1.A.3b| | 2 |
Registration plate lamp issues | 2 |
Nearside Front wheel bearing has excessive play |2.5.A.3c| | 2 |
Offside front brake binding |3.7.B.1| | 2 |
Bonnet cannot be secured in the closed position |8.4.1| | 2 |
Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 2 |
Offside Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 2 |
Brake hose excessively deteriorated | 2 |
Front Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 2 |
Nearside Front wheel bearing rough when rotated |2.5.A.2| | 2 |
Offside Front wheel bearing rough when rotated |2.5.A.2| | 2 |
Rear parking brake recording little or no effort | 2 |
Rear Stop lamp not working |1.2.1b| | 2 |
Offside Front Sub-frame corroded and seriously weakened |2.4.G.1| | 1 |
Nearside Front Brake hose twisted |found during steering lock to lock check| |2.2.D.2b| | 1 |
Offside Front Brake hose twisted |found during steering lock to lock check| |2.2.D.2b| | 1 |
Nearside Seat belt anchorage prescribed area is inadequately repaired |5.2.6| | 1 |
Offside Seat belt anchorage prescribed area is inadequately repaired |5.2.6| | 1 |
Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
Offside Rear Lower Suspension component mounting prescribed area is inadequately repaired |2.4.A.3| | 1 |
Offside Rear Upper Suspension component mounting prescribed area is inadequately repaired |2.4.A.3| | 1 |
Nearside Rear Lower Suspension component mounting prescribed area is inadequately repaired |2.4.A.3| | 1 |
Offside Rear Lower Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Brake pedal spongy |3.3.B.1b| | 1 |
Offside Headlamp not working on main beam |1.7.5a| | 1 |
Front Windscreen wiper not operating over a large enough area to give an adequate view |8.2.1c| | 1 |
Brake hose damaged | 1 |
Offside Front Anti-roll bar attachment bracket/mounting insecure |2.4.G.1| | 1 |
Nearside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Nearside Front Anti-roll bar attachment bracket/mounting insecure |2.4.G.1| | 1 |
Offside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
Offside Outer Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Nearside Outer Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Battery insecure |1.9.1| | 1 |
Hazard warning lamps not flashing in phase, with ignition on |1.4.B.1f| | 1 |
Hazard warning lamps not flashing in phase, with ignition off |1.4.B.1f| | 1 |
Hazard warning tell tale not working correctly |1.4.B.1e| | 1 |
Indicator tell tale inoperative |1.4.A.2a| | 1 |
Brake pedal has insufficient reserve movement |3.3.A.5| | 1 |
Offside Front Torsion bar deteriorated by corrosion so that its cross sectional area is reduced and seriously weakened |2.4.E.1b| | 1 |
Offside Inner Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
Offside Outer Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
Nearside Inner Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
Nearside Outer Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
Nearside Outer Rear Torsion bar attachment bracket corroded and seriously weakened |2.4.E.4c| | 1 |
Offside Outer Rear Torsion bar attachment bracket corroded and seriously weakened |2.4.E.4c| | 1 |
Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
Nearside Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
Offside Front Seat belt anchorage prescribed area is inadequately repaired |5.2.6| | 1 |
Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
Fuel cap/sealing device does not fasten securely by positive means |7.2.4b| | 1 |
Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Centre Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
Offside Front Vehicle structure is cracked, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 1 |
Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
Steering system has excessive free play detected at the steering wheel |steering box fitted| |2.2.A.1a| | 1 |
Steering system excessively tight |2.2.D.1| | 1 |
Driver`s seat insecure |6.2.A.1| | 1 |
Offside Front Seat belt damaged sufficient to significantly weakened the webbing |5.2.2a| | 1 |
Nearside Front Headlamp adversely affected by the operation of another lamp |1.7.5c| | 1 |
Windscreen wiper does not clear the windscreen effectively | 1 |
Towbar component insecure |6.6.1| | 1 |
Rear Anti-roll bar rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Offside Front Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
Offside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Steering column top bearing excessively worn |2.1.2c| | 1 |
Steering column flexible coupling is excessively deteriorated |2.1.5| | 1 |
Nearside front brake binding |3.7.B.1| | 1 |
Nearside Headlamp insecure |1.7.3| | 1 |
Offside Headlamp insecure |1.7.3| | 1 |
Offside front brake recording little or no effort |3.7.B.5a| | 1 |
Offside front parking brake recording little or no effort |3.7.B.6a| | 1 |
Nearside Front Vehicle structure is cracked, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Front Torque/reaction arm has excessive play in a pin/bush |2.4.G.2| | 1 |
Nearside Front Torque/reaction arm has excessive play in a pin/bush |2.4.G.2| | 1 |
Nearside Front Lower Shock absorber has an excessively worn bush |2.7.4| | 1 |
Offside Front Lower Shock absorber has an excessively worn bush |2.7.4| | 1 |
Parking brake lever ratchet mechanism is broken |3.1.5| | 1 |
Parking brake lever defective so that it cannot be satisfactorily operated |3.1.3c| | 1 |
Offside Stop lamp not working |1.2.1b| | 1 |
Offside Rear Direction indicator not working |1.4.A.2c| | 1 |
Front Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Offside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
Nearside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
Offside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
Offside Front Headlamp not working on main beam |1.7.5a| | 1 |
Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Nearside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
Nearside Obligatory mirror missing |8.1.1| | 1 |
Front Sub-frame corroded and seriously weakened |2.4.G.1| | 1 |
Offside Outer Rear Lower Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Headlamp not working on dipped beam |1.7.5a| | 1 |
Offside Obligatory mirror missing |8.1.1| | 1 |
Passenger`s seat insecure |6.2.A.1| | 1 |
Nearside Seat belt anchorage prescribed area is excessively corroded floor on seat mount |5.2.6| | 1 |
Front Suspension component mounting prescribed area is excessively corroded lower |2.4.A.3| | 1 |
Offside Lower Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Rear Upper Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Nearside Front Inner Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
Front Headlamp not working on dipped beam |1.7.5a| | 1 |
Front Front position lamp|s| not working |1.1.A.3b| | 1 |
Offside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
Front Steering component mounting prescribed area is excessively corroded |2.2.C.1h| | 1 |
Offside Direction indicator adversely affected by the operation of another lamp |1.4.A.2h| | 1 |
Nearside Rear Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
Offside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
Nearside Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 1 |
Offside Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 1 |
Offside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
Nearside Front Upper Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Nearside Front position lamp|s| not working |1.1.A.3b| | 1 |
Nearside Front Upper Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Offside Front Lower Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Rear brake binding | 1 |
Offside Driver`s door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
Nearside Front Anti-roll bar rubber mounting bonding deteriorated resulting in excessive movement |2.4.G.2| | 1 |