Most common failures | No# failures |
---|
Parking brake: efficiency below requirements |3.7.B.7| | 15 |
Headlamp aim out of alignment | 15 |
Rear parking brake recording little or no effort | 11 |
Brakes imbalanced across an axle | 9 |
Registration plate lamp issues | 9 |
Registration plate issues | 8 |
Service brake: efficiency below requirements |3.7.B.7| | 7 |
Nearside Front position lamp|s| not working |1.1.A.3b| | 5 |
Offside Front wheel bearing rough when rotated |2.5.A.2| | 5 |
Front brake application uneven | 4 |
Nearside Front wheel bearing rough when rotated |2.5.A.2| | 4 |
Parking brake: efficiency below requirements |3.7.C.1b| | 4 |
Offside Stop lamp not working |1.2.1b| | 4 |
Parking brake lever has no reserve travel |3.1.6b| | 4 |
Windscreen wiper does not clear the windscreen effectively | 4 |
Brake pipe excessively corroded | 3 |
Offside Front position lamp|s| not working |1.1.A.3b| | 3 |
Horn not working |1.6.2a| | 3 |
Centre Steering pivot point has excessive play |2.2.B.1g| | 2 |
Brake hose has insufficient room to move | 2 |
Offside Headlamp aim beam image kick up to the offside |1.8| | 2 |
Steering system fouling |2.2.D.2a| | 2 |
Service brake: efficiency below requirements |3.7.C.1a| | 2 |
Service brake is causing the vehicle to swerve to the nearside |3.7.C.2| | 2 |
Windscreen washer control missing |8.2.1a| | 2 |
Stop lamp not working |1.2.1b| | 2 |
Offside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
Nearside Front Front wheel bearing rough when rotated |2.5.A.2| | 2 |
Offside Rear position lamp|s| not working |1.1.A.3b| | 2 |
Brake hose excessively deteriorated | 2 |
Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 2 |
Rear Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
Front Windscreen wiper not operating automatically when switched on |8.2.1b| | 2 |
Offside Front Front wheel bearing rough when rotated |2.5.A.2| | 2 |
Battery insecure |1.9.1| | 2 |
Horn emits two or more alternating tones |1.6.2d| | 2 |
Nearside Rear Torsion bar insecure at an end fixing suspension torsion bar retainer cap 1x bolt sheared off |2.4.E.2| | 1 |
Offside Rear Torsion bar insecure at an end fixing suspension torsion bar retainer cap 1x bolt missing |2.4.E.2| | 1 |
Offside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
Indicator switch insecure |1.4.A.1| | 1 |
Nearside Rear Brake pipe inadequately supported |3.6.B.1| | 1 |
Offside Rear Brake pipe fouled by moving parts |3.6.B.2a| | 1 |
Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
Offside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
Offside Rear brake drum contaminated by oil |3.5.1h| | 1 |
Nearside Rear brake drum contaminated by oil |3.5.1h| | 1 |
Centre Front Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
Offside Headlamp not working on main beam |1.7.5a| | 1 |
Front Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
Nearside Headlamp not working on main beam |1.7.5a| | 1 |
Offside Front Upper Torsion bar excessive play at an end fixing |2.4.E.2| | 1 |
Service brake is causing the steering wheel to severely pull one way |3.7.C.2| | 1 |
Nearside Front Front passenger door hinge insecure lower and upper hinge due to corrosion |6.2.B.2| | 1 |
Nearside Front Front passenger door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
Nearside Front Lower Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
Nearside Front Upper Front suspension ball joint dust cover insecure so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Offside Front Upper Front suspension ball joint dust cover insecure so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Offside Front Shock absorber has an excessively worn bush |2.7.4| | 1 |
Nearside Rear Rear wheel bearing has excessive play |2.6.2| | 1 |
Nearside Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
Offside Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
Offside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
Nearside Front Brake pipe inadequately supported |3.6.B.1| | 1 |
Intermediate drop arm insecure |2.2.B.1a| | 1 |
Braking system leaking main brake pipe |3.6.A.1| | 1 |
Offside Rear Brake pipe twisted |found during steering lock to lock check| |2.2.D.2b| | 1 |
Nearside Rear Brake pipe inadequately clipped |3.6.B.1| | 1 |
Nearside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Front Macpherson strut insecure |2.4.G.1| | 1 |
Front All position lamps not working |1.1.A.3b| | 1 |
Nearside Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
Offside Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
Offside Obligatory mirror does not provide a view to the rear |8.1.2b| | 1 |
Offside Rear Shock absorber insecure |2.7.2b| | 1 |
Rear brake application uneven | 1 |
Nearside Headlamp aim beam image kick up to the offside |1.8| | 1 |
Nearside Rear Braking system leaking |3.6.A.1| | 1 |
Windscreen washer not working | 1 |
Offside Front Windscreen washer jets misaligned and not providing sufficient fluid to the windscreen |3.5 |a|| | 1 |
Nearside Front Position lamp not working |4.2.1 |a| |ii|| | 1 |
Offside Front Position lamp not working |4.2.1 |a| |ii|| | 1 |
Front passenger door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
Nearside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
Nearside Front Brake hose excessively damaged |3.6.B.4d| | 1 |
Offside Front Brake hose excessively damaged |3.6.B.4d| | 1 |
Parking brake operation is causing the vehicle to swerve to the nearside |3.7.C.3a| | 1 |
Offside Front Headlamp not working on main beam |1.7.5a| | 1 |
Nearside Front Lower Stub axle has excessive vertical movement between stub axle and axle beam |2.5.A.1a| | 1 |
Nearside Front Upper Stub axle has excessive vertical movement between stub axle and axle beam |2.5.A.1a| | 1 |
Rear Service brake grabbing severely binding n/s o/s |3.7.C.2| | 1 |
Nearside Headlamp not working on dipped beam |1.7.5a| | 1 |
Steering box has relative movement between sector shaft and the drop arm |2.2.B.1b| | 1 |
Steering system has excessive free play detected at the steering wheel |steering box fitted| |2.2.A.1a| | 1 |
front brakes release unevenly |3.7.B.4| | 1 |
Offside Rear Direction indicators not working |1.4.A.2c| | 1 |
Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
Offside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
Nearside Windscreen wiper blade missing |8.2.2| | 1 |
Offside Windscreen wiper blade missing |8.2.2| | 1 |
Nearside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
Nearside Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 1 |
Nearside Rear Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
Nearside Rear Direction indicator adversely affected by the operation of another lamp |1.4.A.2h| | 1 |
Headlamp not working on main beam |4.1.1 |a| |ii|| | 1 |
Headlamp aim so that beam "kick up" is not visible on the screen |4.1.2 |a|| | 1 |
Nearside Front Brake pipe likely to become detached or damaged |1.1.11 |d| |ii|| | 1 |
Nearside Rear Brake pipe likely to become detached or damaged |1.1.11 |d| |ii|| | 1 |
Electrical wiring likely to touch hot or rotating parts wiring rubbing against steering components |4.11 |a| |iii|| | 1 |
Stop lamp not working both |1.2.1b| | 1 |
Fuel cap/sealing device sealing washer missing |7.2.4c| | 1 |
Nearside Obligatory mirror missing |8.1.1| | 1 |
Offside Rear Wheel insecure |4.2.A.1c| | 1 |
Nearside Front Axle king pin has excessive play in pin and/or bush adversely affecting the steering |2.5.A.3a| | 1 |
Offside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
Nearside Upper Torque/reaction arm has excessive play in a pin/bush |2.4.G.2| | 1 |
Offside Front Upper Torque/reaction arm has excessive play in a pin/bush |2.4.G.2| | 1 |
Nearside Front Lower Torque/reaction arm has excessive play in a pin/bush |2.4.G.2| | 1 |
Offside Front Lower Torque/reaction arm has excessive play in a pin/bush |2.4.G.2| | 1 |
Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
Nearside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
Nearside Front Suspension component pin or bush excessively worn king pin bush |5.3.4 |a| |i|| | 1 |
Nearside Front Upper Axle king pin has excessive play in pin and/or bush adversely affecting the steering |2.5.A.3a| | 1 |
Offside Front Upper Axle king pin has excessive play in pin and/or bush adversely affecting the steering |2.5.A.3a| | 1 |
Offside Front Lower Axle king pin has excessive play in pin and/or bush adversely affecting the steering |2.5.A.3a| | 1 |
Offside Rear Wheel fitment excessively worn between the wheel and hub spigot mounting |4.2.B.5| | 1 |
Stop lamp(s) all not working (4.3.1 (a) (iii)) | 1 |
Front Fluid suspension has no suspension movement |2.4.D.5| | 1 |
Rear Fluid suspension has no suspension movement |2.4.D.5| | 1 |
Offside Front Upper Shock absorber has an excessively worn bush |2.7.4| | 1 |
Offside Front Lower Shock absorber has an excessively worn bush |2.7.4| | 1 |
Nearside Front Upper Shock absorber has an excessively worn shock absorber pivot |2.7.4| | 1 |
Nearside Front Lower Shock absorber has an excessively worn shock absorber pivot |2.7.4| | 1 |
Rear Exhaust has a part missing |7.1.1a| | 1 |
Offside rear brake recording little or no effort |3.7.B.5a| | 1 |
Offside Rear Wheel bolt|s| loose |4.2.A.1e| | 1 |
Nearside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
Rear Fuel pipe leaking |7.2.3| | 1 |
Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength chassis outrigger |5.3.6 |a| |i|| | 1 |
Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner sill |5.3.6 |a| |i|| | 1 |
Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength chassis |5.3.6 |a| |i|| | 1 |
Nearside Front Steering component mounting prescribed area is excessively corroded chassis |2.2.C.1h| | 1 |
Nearside Front Steering component mounting prescribed area is excessively corroded floor |2.2.C.1h| | 1 |
Nearside Front Steering component mounting prescribed area is excessively corroded valance |2.2.C.1h| | 1 |
Nearside Front Steering component mounting prescribed area is excessively corroded door step |2.2.C.1h| | 1 |
Nearside Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
Mechanical brake component has restricted free movement | 1 |
Brake hose damaged | 1 |
Nearside Front Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 1 |
Offside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
Nearside Rear position lamp|s| not working |1.1.A.3b| | 1 |
Steering column top mounting bracket insecure |2.1.2d| | 1 |
Nearside Front Direction indicator not working |1.4.A.2c| | 1 |
Nearside Steering locking device insecure |2.2.C.1g| | 1 |
Offside Rear wheel bearing rough when rotated |2.6.1| | 1 |
Service brake is causing the vehicle to swerve to the offside |3.7.C.2| | 1 |
Horn is a siren |1.6.2c| | 1 |
Offside Rear Brake pipe kinked |3.6.B.2b| | 1 |
Nearside Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
Offside Front Body has a sharp edge caused by damage |6.1.C.1| | 1 |
Nearside Front wheel cylinder leaking |3.6.A.1| | 1 |
Front Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
Nearside Front Shock absorber has negligible damping effect |2.7.5| | 1 |
Offside Front Shock absorber has negligible damping effect |2.7.5| | 1 |
Offside Front Service brake grabbing severely |3.7.C.2| | 1 |
Brake performance not tested |3.7.A.1| | 1 |
Offside Rear Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
Nearside Stop lamp not working |1.2.1b| | 1 |
Offside Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Rear position lamp|s| has less than 50% of the light sources illuminating |1.1.A.3b| | 1 |
Nearside Inner Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Nearside Outer Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |