| Most common failures | No# failures |
|---|
| Registration plate lamp issues | 27 |
| Headlamp aim out of alignment | 25 |
| Windscreen wiper does not clear the windscreen effectively | 19 |
| Horn not working (7.7 (a)) | 7 |
| Offside Rear Coil spring fractured or broken (5.3.1 (b) (i)) | 7 |
| Windscreen washer not working | 7 |
| Nearside Rear Coil spring fractured or broken (5.3.1 (b) (i)) | 7 |
| Brakes imbalanced across an axle | 7 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 7 |
| Parking brake: efficiency below requirements |3.7.B.7| | 6 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 6 |
| Brake pipe excessively corroded | 6 |
| Offside Rear fog lamp not working (4.5.1 (a) (ii)) | 5 |
| Rear fog lamp not working |1.3.2b| | 5 |
| Brake hose excessively deteriorated | 4 |
| Nearside Front Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 4 |
| Nearside Rear Position lamp not working (4.2.1 (a) (ii)) | 4 |
| Offside Front Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 4 |
| Rear parking brake recording little or no effort | 3 |
| Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 3 |
| Offside Headlamp aim beam image kick up to the offside |1.8| | 3 |
| Offside Front Direction indicator incorrect colour (4.4.3 (a)) | 3 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 3 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 3 |
| Brake pedal spongy |3.3.B.1b| | 3 |
| Rear Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 2 |
| Engine MIL inoperative or indicates a malfunction (8.2.2.2 (g)) | 2 |
| Anti-lock braking system warning lamp indicates an ABS fault | 2 |
| Nearside Front Service brake excessively binding (1.2.1 (f)) | 2 |
| Rear brake disc in such a condition that it is seriously weakened | 2 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 2 |
| Battery insecure and likely to cause a short circuit (4.13 (a) (ii)) | 2 |
| Offside Rear Position lamp not working (4.2.1 (a) (ii)) | 2 |
| Offside Front Shock absorbers has a serious fluid leak | 2 |
| Nearside Front Shock absorber has a serious fluid leak |2.7.3| | 2 |
| Offside Rear Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 2 |
| Nearside Front Shock absorbers has a serious fluid leak | 2 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 2 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 2 |
| Offside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 2 |
| Offside Rear coil spring broken |2.4.C.1a| | 2 |
| Nearside Headlamp aim beam image kick up to the offside |1.8| | 2 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 2 |
| Nearside Side repeater missing |1.4.A.2b| | 2 |
| Offside Rear Suspension has inadequate clearance with the bump stop |2.4.A.1a| | 2 |
| Windscreen has damage | 2 |
| Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 2 |
| Offside Stop lamp(s) not working (4.3.1 (a) (ii)) | 2 |
| Nearside Front Direction indicator incorrect colour (4.4.3 (a)) | 2 |
| Windscreen wiper not working (3.4 (a)) | 2 |
| Offside Front Service brake excessively binding (1.2.1 (f)) | 2 |
| Front brake disc in such a condition that it is seriously weakened | 2 |
| Steering box has excessive free play detected at the steering wheel (steering box fitted) (2.3 (a) (i)) | 2 |
| Registration plate issues | 2 |
| Nearside Front Upper Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 2 |
| Exhaust emissions carbon monoxide content excessive (8.2.1.2 (b)) | 2 |
| Rear fog lamp not working |4.5.1 |a| |ii|| | 2 |
| Nearside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Offside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Nearside Front Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Front Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Nearside Rear Wheel bearing rough when rotated (5.1.3 (b) (i)) | 1 |
| Offside Body component insecure mirror cover (6.2.1 (a) (i)) | 1 |
| Central Exhaust system insecure (6.1.2 (a)) | 1 |
| Offside Front Seat belt anchorage loose drivers seat insecure (7.1.1 (b)) | 1 |
| Stop lamp(s) all missing (4.3.1 (a) (iii)) | 1 |
| Nearside Rear Direction indicator adversely affected by the operation of another lamp (4.4.3 (b)) | 1 |
| Nearside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Front Integral body structure is fractured and structural rigidity is significantly reduced sill /jacking point (6.1.1 (a) (i)) | 1 |
| Nearside Front Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting floor holed (6.2.2 (d) (i)) | 1 |
| Nearside Front Seat belt installation has an anchorage without suitable reinforcement mount corroded under arch (10.1 (f)) | 1 |
| Nearside Headlamp aim projected beam image is obviously incorrect dips wrong way (4.1.2 (c)) | 1 |
| Offside Headlamp aim projected beam image is obviously incorrect dips wrong way (4.1.2 (c)) | 1 |
| Offside Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Offside Headlamp insecure (4.1.1 (c)) | 1 |
| Service brake lagging in operation (1.2.1 (d)) | 1 |
| Nearside Front Wheel bearing has excessive play (5.1.3 (a) (i)) | 1 |
| Rear Stop lamp(s) all not working (4.3.1 (a) (iii)) | 1 |
| Nearside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Offside Front Front drive shaft support bearing excessively worn |2.5.C.2c| | 1 |
| Nearside Rear coil spring broken |2.4.C.1a| | 1 |
| Nearside Front Wheel nut|s| missing |4.2.A.1e| | 1 |
| Offside Front Wheel nut|s| missing |4.2.A.1e| | 1 |
| Nearside Rear Wheel nut|s| missing |4.2.A.1e| | 1 |
| Offside Rear Wheel nut|s| missing |4.2.A.1e| | 1 |
| Rear fog lamp likely to become detached (4.5.1 (c) (ii)) | 1 |
| Headlamp aim projected beam image is obviously incorrect o/s and n/s |4.1.2 |c|| | 1 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 1 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 1 |
| Offside Side repeater missing |1.4.A.2b| | 1 |
| Nearside Front Suspension has inadequate clearance with the bump stop |2.4.A.1a| | 1 |
| Offside Front Suspension has inadequate clearance with the bump stop |2.4.A.1a| | 1 |
| Nearside Rear Suspension has inadequate clearance with the bump stop |2.4.A.1a| | 1 |
| Offside Side repeater not working |1.4.A.2c| | 1 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Offside Rear Service brake excessively binding |1.2.1 |f|| | 1 |
| Nearside Inner Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Nearside Rear Direction indicator incorrect colour (4.4.3 (a)) | 1 |
| Offside Rear Direction indicator incorrect colour (4.4.3 (a)) | 1 |
| Nearside Headlamp insecure (4.1.1 (c)) | 1 |
| Offside Rear Upper Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Offside Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
| Stop lamp(s) all not working (4.3.1 (a) (iii)) | 1 |
| Offside Rear Obligatory mirror seriously damaged, affecting the rear view (3.3 (b) (ii)) | 1 |
| Offside Rear Rear position lamp|s| incorrect colour damaged shows white light |1.1.A.3e| | 1 |
| Offside Side repeater not working (4.4.1 (a) (ii)) | 1 |
| Nearside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Electronic stability control warning lamp indicates a fault (7.12 (e)) | 1 |
| Bonnet cannot be secured in the closed position (3.1 (b) (i)) | 1 |
| Offside Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Nearside Front Road wheel fixing missing |5.2.1 |a| |i|| | 1 |
| Offside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Stop lamp(s) switch with a delay in operation (4.3.2 (a) (ii)) | 1 |
| Nearside Indicator switch inoperative (4.4.2 (a) (ii)) | 1 |
| Nearside Windscreen wiper not working (3.4 (a)) | 1 |
| Nearside Rear Direction indicator light intensity significantly reduced (4.4.3 (a)) | 1 |
| Offside Front Service brake lagging in operation (1.2.1 (d)) | 1 |
| All direction indicators incorrect colour (4.4.3 (a)) | 1 |
| Offside Front Lower Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Rear Position lamp showing white light to the rear (4.2.3 (a) (ii)) | 1 |
| Nearside Rear reflector defective or damaged by more than 50% of the reflecting surface (4.8.1 (a) (ii)) | 1 |
| Offside Rear Service brake lagging in operation (1.2.1 (d)) | 1 |
| All position lamps not working |1.1.A.3b| | 1 |
| Nearside Outer Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Nearside Stop lamp not working |1.2.1b| | 1 |
| Nearside Front Lower Suspension component ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Lower Suspension component ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 1 |
| Nearside Rear Brake disc significantly and obviously worn Causing low braking effort (1.1.14 (a) (i)) | 1 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Rear Shock absorbers has an excessively worn bush (5.3.2 (c)) | 1 |
| Offside Front Suspension arm pin or bush excessively worn lower arm front bush (5.3.4 (a) (i)) | 1 |
| Nearside Front Drivers door cannot be opened from outside the vehicle (6.2.3 (a)) | 1 |
| Front Inner Track rod end ball joint dust cover insecure so that it no longer prevents the ingress of dirt both (2.1.3 (g) (ii)) | 1 |
| Offside Battery insecure and likely to cause a short circuit (4.13 (a) (ii)) | 1 |
| Drivers door cannot be opened from outside the vehicle (6.2.3 (a)) | 1 |
| Emissions unable to be completed oil low (8.2.2.2 (e)) | 1 |
| Offside Rear Battery insecure |1.9.1| | 1 |
| Nearside Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Front Anti-roll bar ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Battery insecure |1.9.1| | 1 |
| Offside Front Brake hose bulging under pressure (1.1.12 (d)) | 1 |
| Exhaust system insecure (6.1.2 (a)) | 1 |
| Steering box has excessive free play detected at the steering wheel (steering box fitted) play in centre steering idler arm pin/bush (2.3 (a) (i)) | 1 |
| Nearside Front Seat belt anchorage loose (7.1.1 (b)) | 1 |
| Nearside Front Position lamp adversely affected by the operation of another lamp (4.2.3 (c)) | 1 |
| Offside Front Position lamp adversely affected by the operation of another lamp (4.2.3 (c)) | 1 |
| Offside Front Brake hose excessively twisted (1.1.12 (b) (ii)) | 1 |
| Direction indicators flashing more than 120 times a minute |1.4.A.2g| | 1 |
| Nearside Rear position lamp|s| adversely affected by the operation of another lamp brighter than off side |1.1.A.3f| | 1 |
| Nearside Rear Stop lamp adversely affected by the operation of another lamp very dim in operation - does not illuminate when position lamps on |1.2.1f| | 1 |
| Offside Front Brake hose twisted |found during steering lock to lock check| |2.2.D.2b| | 1 |
| Rear Seat belt missing |7.1.2 |a|| | 1 |
| Driver`s view of the road through the swept area of the windscreen materially affected by an obstruction |3.1 |a| |ii|| | 1 |
| Offside Front Direction indicator not working (4.4.1 (a) (ii)) | 1 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Emissions not tested Excessive exhaust leak. |7.3.A.1| | 1 |
| Rear Passenger`s seat insecure to body |6.2.A.1| | 1 |
| Front Lower Anti-roll bar attachment bracket/mounting insecure near side and off side to arm around bush |2.4.G.1| | 1 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive test not completed due to excessively high reading 10.5%co |7.3.D.3| | 1 |
| Nearside Rear reflector missing (4.8.2 (a) (ii)) | 1 |
| Nearside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Offside Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Steering rack has excessive free play detected at the steering wheel (steering rack fitted) steering rack idler has excessive free play and 200mm free play at steering wheel (2.3 (a) (i)) | 1 |
| Nearside Front Service brake excessively fluctuating (1.2.1 (e)) | 1 |
| Offside Rear Inner Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Offside Rear Outer Drive shaft securing bolt loose (6.1.7 (a) (i)) | 1 |
| Nearside Headlamp aim projected beam image is obviously incorrect Aim kickup in wrong direction (4.1.2 (c)) | 1 |
| Nearside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 1 |
| Axle king pin has excessive play in pin and/or bush adversely affecting the steering |2.5.A.3a| | 1 |
| Rear Reversing lamp inoperative x2 (4.6.1 (a)) | 1 |
| Brake fluid warning lamp inoperative |3.6.G.2| | 1 |
| Centre Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
| Rear brake application uneven | 1 |
| Steering system has excessive free play detected at the steering wheel |steering box fitted| |2.2.A.1a| | 1 |
| Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Central Front Upper Driver`s view of an obligatory external mirror materially affected by an obstruction |3.1 |a| |ii|| | 1 |
| Offside Front Lower Steering system excessively rough column |2.1.1 |a|| | 1 |
| Offside Front Steering column universal joint insecure to the extent there is excessive movement at the mountings excessive movement and knocking. |2.1.3 |a| |ii|| | 1 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 1 |
| Rear Service brake imbalanced across an axle |1.2.1 |b| |i|| | 1 |
| Nearside Front Wheel bearing has excessive play |5.1.3 |a| |i|| | 1 |
| Offside Front Wheel bearing has excessive play |5.1.3 |a| |i|| | 1 |
| Front Steering linkage ball joint has excessive play foremost linkage / tie rod ball joint |2.1.3 |b| |i|| | 1 |
| Front Steering linkage ball joint ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt foremost tie rod gaiter / dust cover |2.1.3 |g| |ii|| | 1 |
| Ball joint has excessive play |2.2.B.1f| | 1 |
| Steering column top bearing excessively worn (2.2.2 (b)) | 1 |
| Offside Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Offside Front Shock absorbers insecurely attached (5.3.2 (a) (i)) | 1 |
| Front Axle king pin has excessive play in pin and/or bush adversely affecting the steering both sides |2.5.A.3a| | 1 |
| Service brake: efficiency below requirements |3.7.B.7| | 1 |
| Rear Exhaust has a major leak of exhaust gases box holed (6.1.2 (a)) | 1 |
| Emissions not tested (8.2.1.2 (d)) | 1 |
| Exhaust has a major leak of exhaust gases tail pipe (6.1.2 (a)) | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds manufacturers specified limits (8.2.1.2 (a)) | 1 |
| Offside Obligatory mirror insecure (3.3 (b) (ii)) | 1 |
| Offside Rear fog lamp not working |1.3.2b| | 1 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 1 |
| Offside Rear fog lamp not working |4.5.1 |a| |ii|| | 1 |
| Rear Exhaust has a major leak of exhaust gases |6.1.2 |a|| | 1 |
| Rear Reversing lamp inoperative (4.6.1 (a)) | 1 |
| Offside Front Steering box has excessive free play detected at the steering wheel (steering box fitted) (2.3 (a) (i)) | 1 |
| Steering linkage insecure to the extent there is excessive movement at the mountings seized wont return from lock to lock |2.1.3 |a| |ii|| | 1 |
| Brake performance not tested brake pedal sticking |1.2.1 |g|| | 1 |
| Electronic braking system warning device inoperative brake lamp on dash |1.7 |a|| | 1 |
| Brake performance not tested |1.2.1 |g|| | 1 |
| Nearside Front Front passenger door cannot be opened from outside the vehicle (6.2.3 (a)) | 1 |
| Nearside Front Wheel bearing rough when rotated (5.1.3 (b) (i)) | 1 |
| Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Rear Brake hose porous both rear brake hoses splitting (1.1.12 (e)) | 1 |
| Headlamp aim projected beam image is obviously incorrect BOTH SIDES KICK UP TO WRONG SIDE (4.1.2 (c)) | 1 |
| Offside Front Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |