| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 26 |
| Windscreen wiper does not clear the windscreen effectively | 26 |
| Registration plate lamp issues | 21 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 9 |
| Horn not working (7.7 (a)) | 7 |
| Registration plate issues | 6 |
| Windscreen washer not working | 6 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 6 |
| Engine MIL inoperative or indicates a malfunction (8.2.2.2 (g)) | 5 |
| Brake pedal spongy |3.3.B.1b| | 5 |
| Brake hose excessively deteriorated | 5 |
| Brake pipe excessively corroded | 5 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 4 |
| Brake pedal has insufficient reserve movement |3.3.A.5| | 4 |
| Parking brake: efficiency below requirements |3.7.B.7| | 4 |
| Anti-lock braking system warning lamp indicates an ABS fault | 4 |
| Rear fog lamp not working |1.3.2b| | 4 |
| Brakes imbalanced across an axle | 3 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 3 |
| Nearside Front Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 3 |
| Nearside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 3 |
| Offside Rear fog lamp not working (4.5.1 (a) (ii)) | 3 |
| Nearside Front Inner Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 3 |
| Offside Front Shock absorbers has a serious fluid leak | 3 |
| Nearside Front Lower Suspension component ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 3 |
| Offside Front Lower Suspension component ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 3 |
| Brake pedal has insufficient reserve travel (1.1.2 (a)) | 2 |
| Offside Headlamp not working on main beam (4.1.1 (a) (ii)) | 2 |
| Offside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 2 |
| Offside Front Upper Vehicle structure is cracked, seriously affecting its strength within 30cm of the body mountings by sub-frame mount point |6.1.B.2| | 2 |
| Rear parking brake recording little or no effort | 2 |
| Offside Front Lower Anti-roll bar attachment bracket/mounting insecure to suspension arm |2.4.G.1| | 2 |
| Nearside Rear Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 2 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 2 |
| Nearside Front Direction indicator not working (4.4.1 (a) (ii)) | 2 |
| Brake master cylinder leaking (1.1.10 (b) (ii)) | 2 |
| Offside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 2 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 2 |
| Exhaust emissions carbon monoxide content excessive (8.2.1.2 (b)) | 2 |
| Exhaust carbon monoxide content at idle exceeds default limits (8.2.1.2 (b)) | 2 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds manufacturers specified limits (8.2.1.2 (a)) | 2 |
| Offside Front Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 2 |
| Nearside Front Headlamp not working on main beam (4.1.1 (a) (ii)) | 2 |
| Nearside Front Wheel bearing rough when rotated (5.1.3 (b) (i)) | 2 |
| Horn sounds harsh or grating |1.6.2e| | 2 |
| Offside Rear fog lamp not working |1.3.2b| | 2 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 2 |
| Nearside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 2 |
| Exhaust emissions hydrocarbon content excessive (8.2.1.2 (b)) | 2 |
| Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 2 |
| Offside Stop lamp not working |1.2.1b| | 2 |
| Offside Rear Battery insecure and likely to cause a short circuit (4.13 (a) (ii)) | 2 |
| Electronic stability control warning lamp indicates a fault (7.12 (e)) | 2 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 2 |
| Offside Rear Direction indicator not working (4.4.1 (a) (ii)) | 1 |
| Front Service brake effort inadequate at a wheel (1.2.1 (a) (i)) | 1 |
| Nearside Front Suspension arm ball joint dust cover no longer prevents the ingress of dirt Bottom ball joint |5.3.4 |b| |ii|| | 1 |
| Offside Front Suspension arm ball joint dust cover no longer prevents the ingress of dirt Bottom ball joint |5.3.4 |b| |ii|| | 1 |
| Offside Front Service brake excessively binding (1.2.1 (f)) | 1 |
| Rear coil spring broken both sides |2.4.C.1a| | 1 |
| Front Suspension arm rubber mounting deteriorated resulting in excessive movement both sides rear bushes |2.4.G.2| | 1 |
| Offside Front Upper Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Nearside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Front Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Nearside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Nearside Rear Coil spring mounting corroded and seriously weakened (5.3.1 (b) (i)) | 1 |
| Drivers seat fore and aft adjustment mechanism not functioning as intended. (6.2.5 (b) (i)) | 1 |
| Steering box has excessive free play detected at the steering wheel (steering box fitted) play centre steering idler arm pin/bush (2.3 (a) (i)) | 1 |
| Nearside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Windscreen in an unacceptable condition (3.2 (c) (i)) | 1 |
| Nearside Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
| Hydraulic brake cylinder leaking hydraulic fluid level sensor area on master cylinder |1.1.16 |b| |i|| | 1 |
| Brake pedal has insufficient reserve travel |1.1.2 |a|| | 1 |
| Nearside Rear Parking (secondary brake) on a single line braking system has inadequate effort at a wheel (1.3.1 (a) (i)) | 1 |
| Parking brake lever has excessive movement indicating incorrect adjustment (1.1.6 (c)) | 1 |
| Hazard warning tell tale not working correctly on switch |1.4.B.1e| | 1 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 1 |
| Exhaust emissions hydrocarbon content after 2nd fast idle excessive |7.3.D.3| | 1 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 1 |
| Offside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Rear brake binding | 1 |
| Offside Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Offside Body component damaged and likely to cause injury middle door handle broken causing sharp edge (6.2.1 (a) (i)) | 1 |
| Front Brake pedal has insufficient reserve travel (1.1.2 (a)) | 1 |
| Rear Parking brake lever has excessive movement indicating incorrect adjustment (1.1.6 (c)) | 1 |
| Nearside Front Brake hose bulging under pressure (1.1.12 (d)) | 1 |
| Engine MIL inoperative or indicates a malfunction |8.2.1.2 |h|| | 1 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Front Inner Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Offside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Front Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Rear Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Nearside Undertray likely to become detached (6.2.1 (a) (ii)) | 1 |
| Passenger`s seat cannot be secured in the upright position. |6.2.A.2| | 1 |
| Battery insecure |1.9.1| | 1 |
| Rear fog lamp excessively deteriorated so that it is not visible from a reasonable distance both dim |1.3.2d| | 1 |
| Offside Front Steering rack gaiter split |2.2.D.2d| | 1 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front Anti-roll bar linkage fractured |2.4.G.1| | 1 |
| Nearside Front Lower Shock absorbers insecurely attached (5.3.2 (a) (i)) | 1 |
| Offside Front Steering column attachment defective (2.2.2 (d) (i)) | 1 |
| Offside Front Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Speedometer cannot be illuminated (7.8 (c) (ii)) | 1 |
| Horn sound not in accordance with requirements goes off by itself while testing vehicle (7.7 (c)) | 1 |
| Offside Front Wheel bearing so rough it is likely to overheat or break up (5.1.3 (b) (ii)) | 1 |
| Nearside Rear Seat belt missing (7.1.2 (a)) | 1 |
| Offside Front Wheel bearing has excessive play (5.1.3 (a) (i)) | 1 |
| Exhaust hydrocarbon content after 2nd fast idle exceeds manufacturers specified limits (8.2.1.2 (a)) | 1 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 1 |
| Offside Rear Wheel bearing play so excessive it is likely to break up (5.1.3 (a) (ii)) | 1 |
| Offside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Exhaust tailpipe not capable of allowing the emission probe to be inserted |7.3.D.1| | 1 |
| Rear fog lamp tell-tale not working (4.9.1 (a) (ii)) | 1 |
| Drag link end ball pin shank loose |2.2.B.1c| | 1 |
| Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Rear Stop lamp not working |1.2.1b| | 1 |
| Offside Rear Stop lamp not working |1.2.1b| | 1 |
| Centre Rear Stop lamp not working |1.2.1b| | 1 |
| Nearside Rear Wheel bearing play so excessive it is likely to break up (5.1.3 (a) (ii)) | 1 |
| Nearside Front Shock absorbers has a serious fluid leak | 1 |
| Nearside Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Offside Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Nearside Front Steering retaining device missing |2.2.C.1g| | 1 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 1 |
| Front Valve stem seriously damaged both sides (5.2.3 (j)) | 1 |
| Nearside Front Lower Suspension arm pin or bush excessively worn rear |5.3.4 |a| |i|| | 1 |
| Offside Front Lower Suspension arm pin or bush excessively worn rear |5.3.4 |a| |i|| | 1 |
| Offside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Offside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Nearside Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Offside Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Nearside Front Inner Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Nearside Rear Wheel bearing has excessive play (5.1.3 (a) (i)) | 1 |
| Offside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Front Direction indicator incorrect colour (4.4.3 (a)) | 1 |
| Nearside Rear Direction indicator incorrect colour (4.4.3 (a)) | 1 |
| Offside Rear Direction indicator incorrect colour (4.4.3 (a)) | 1 |
| Nearside Rear Position lamp showing white light to the rear (4.2.3 (a) (ii)) | 1 |
| Nearside Stop lamp not working |1.2.1b| | 1 |
| Nearside Front Inner Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Offside Front Inner Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Offside Rear Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Steering box has excessive free play detected at the steering wheel to the extent that safe steering is affected (steering box fitted) (2.3 (a) (ii)) | 1 |
| Central Front Steering box has excessive movement between sector shaft and the drop arm (2.1.3 (a) (ii)) | 1 |
| Nearside Rear Battery insecure and likely to cause a short circuit (4.13 (a) (ii)) | 1 |
| Offside Front Service brake grabbing severely (1.2.1 (c)) | 1 |
| Offside Front Service brake lagging in operation (1.2.1 (d)) | 1 |
| Offside Front Direction indicator incorrect colour (4.4.3 (a)) | 1 |
| Steering column attachment defective upper and lower mountings insecure (2.2.2 (d) (i)) | 1 |
| Parking brake lever defective so that it cannot be satisfactorily operated (1.1.6 (d)) | 1 |
| Nearside Front Seat belt not functioning as intended Will not pull out. (7.1.2 (c)) | 1 |
| Nearside Rear Stop lamp(s) adversely affected by the operation of another lamp (4.3.3 (b)) | 1 |
| Offside Rear Stop lamp(s) adversely affected by the operation of another lamp (4.3.3 (b)) | 1 |
| Front Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 1 |
| Nearside Front Suspension arm pin or bush excessively worn rear bush split (5.3.4 (a) (i)) | 1 |
| Offside Front Suspension arm pin or bush excessively worn rear bush split (5.3.4 (a) (i)) | 1 |
| Battery insecure and likely to cause a short circuit under bonnet (4.13 (a) (ii)) | 1 |
| Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
| Steering column fractured and unserviceable |2.2.C.1d| | 1 |
| Rear brake application uneven | 1 |
| Horn not working |1.6.2a| | 1 |
| Nearside Rear Shock absorbers has a serious fluid leak | 1 |
| Nearside Front Inner Anti-roll bar pin or bush excessively worn D/Bush (5.3.4 (a) (i)) | 1 |
| Offside Front Inner Anti-roll bar pin or bush excessively worn D/Bush (5.3.4 (a) (i)) | 1 |
| Offside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Front Upper Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Nearside Front Anti-roll bar pin or bush excessively worn d bush (5.3.4 (a) (i)) | 1 |
| Offside Front Anti-roll bar pin or bush excessively worn d bush (5.3.4 (a) (i)) | 1 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Rear Statutory seat belt missing |5.1.1| | 1 |
| Offside Rear Statutory seat belt missing |5.1.1| | 1 |
| Nearside Front Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Rear fog lamp switch missing |1.3.1a| | 1 |
| Rear fog lamp missing |1.3.2a| | 1 |
| Emissions not tested |7.3.A.1| | 1 |
| Offside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Nearside Front Seat belt not functioning as intended (7.1.2 (c)) | 1 |
| Nearside Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Steering component mounting prescribed area is excessively corroded By steering box mounting (2.1.2 (e) (i)) | 1 |
| Brake hose has insufficient room to move | 1 |
| Upper Steering column top bearing excessively worn |2.1.2c| | 1 |
| Nearside Rear Outer Drive shaft which forms part of the suspension coupling gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.4.G.4e| | 1 |
| Reversing lamp inoperative |4.6.1 |a|| | 1 |
| Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Emissions not tested (8.2.2.2 (e)) | 1 |
| Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Rear Rear fog lamp not working |4.5.1 |a| |ii|| | 1 |
| Nearside Front Lower Suspension component pin or bush excessively worn Lower suspension bush (5.3.4 (a) (i)) | 1 |
| Nearside Front Upper Suspension component pin or bush excessively worn Suspension bush (5.3.4 (a) (i)) | 1 |
| Offside Front Lower Suspension component pin or bush excessively worn Suspension bush (5.3.4 (a) (i)) | 1 |
| Nearside Front Brake pipe leaking on a hydraulic braking system (1.1.11 (b) (ii)) | 1 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 1 |
| Offside Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 1 |
| Steering box has excessive free play detected at the steering wheel to the extent that safe steering is affected |steering box fitted| |2.3 |a| |ii|| | 1 |
| Offside Front Axle king pin is loose in the axle beam |5.1.2 |d| |i|| | 1 |
| Nearside Front Axle king pin is loose in the axle beam |5.1.2 |d| |i|| | 1 |
| Offside Front Seat belt anchorage prescribed area strength or continuity significantly reduced corroded |7.1.1 |a| |i|| | 1 |
| Rear Exhaust has a major leak of exhaust gases box holed |6.1.2 |a|| | 1 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits |8.2.1.2 |c|| | 1 |
| Main beam `tell-tale` not working |1.7.4c| | 1 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Front Headlamp not working on main beam |1.7.5a| | 1 |
| Offside Front Headlamp not working on main beam |1.7.5a| | 1 |
| Rear fog lamp not working |4.5.1 |a| |ii|| | 1 |
| Offside Rear Service brake excessively binding |1.2.1 |f|| | 1 |
| Emissions not tested due to engine missfire |7.3.A.1| | 1 |
| Offside Rear Fuel cap/sealing device sealing washer deteriorated |7.2.4c| | 1 |
| Nearside Rear Fuel cap/sealing device sealing washer deteriorated |7.2.4c| | 1 |
| Steering column movement between the shaft and steering wheel |2.1.2b| | 1 |
| Brake master cylinder leaking |1.1.10 |b| |ii|| | 1 |
| Central Front Hydraulic brake cylinder leaking hydraulic fluid (1.1.16 (b) (i)) | 1 |
| Fuel cap/sealing device sealing washer deteriorated |7.2.4c| | 1 |
| Nearside Front Anti-roll bar pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Side repeater not working (4.4.1 (a) (ii)) | 1 |
| Horn not working (7.7 (a) (ii)) | 1 |
| Bonnet cannot be secured in the closed position (3.1 (b) (i)) | 1 |
| Front Brake lever has insufficient reserve travel handbrake (1.1.2 (a)) | 1 |
| Nearside Front Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Front Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |