| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 28 |
| Registration plate lamp issues | 19 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 12 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 12 |
| Windscreen wiper does not clear the windscreen effectively | 10 |
| Horn not working |1.6.2a| | 9 |
| Brake pipe excessively corroded | 9 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 7 |
| Offside Stop lamp not working |1.2.1b| | 5 |
| Brake hose excessively deteriorated | 4 |
| Registration plate issues | 4 |
| Offside Rear coil spring incomplete |2.4.C.1a| | 3 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
| Emissions not tested |7.0| | 3 |
| Brakes imbalanced across an axle | 3 |
| Service brake: efficiency below requirements |3.7.B.7| | 3 |
| Exhaust emissions hydrocarbon content after 2nd fast idle excessive |7.3.D.3| | 3 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 3 |
| Stop lamp not working |1.2.1b| | 2 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 2 |
| Exhaust emissions hydrocarbon content excessive |7.3.B.1b| | 2 |
| Nearside Front Valve stem seriously damaged |4.1.D.1e| | 2 |
| Driver`s door cannot be opened from inside the vehicle |6.2.B.1b| | 2 |
| Offside Rear fog lamp not working |1.3.2b| | 2 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Battery insecure |1.9.1| | 2 |
| Emissions not tested (8.2.1.2 (d)) | 2 |
| Front position lamp|s| not working |1.1.A.3b| | 2 |
| Offside Front Headlamp not working on main beam |1.7.5a| | 2 |
| Offside Rear brake disc excessively pitted |3.5.1h| | 2 |
| Offside Rear coil spring broken |2.4.C.1a| | 2 |
| Offside Front Windscreen wiper blade deteriorated |8.2.2| | 2 |
| Windscreen has damage | 2 |
| Offside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 2 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 2 |
| Windscreen washer not working | 2 |
| Brake load sensing valve linkage seized |3.6.E.3| | 1 |
| Offside Obligatory mirror missing |8.1.1| | 1 |
| Offside Rear position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| passenger door does not latch securely closed |6.2.B.1a| | 1 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Front Exhaust mounting missing |7.1.1b| | 1 |
| Nearside passenger door does not latch securely closed sliding door |6.2.B.1a| | 1 |
| Nearside Rear Brake hose twisted |3.6.B.4c| | 1 |
| Nearside Front Subframe mounting prescribed area is excessively corroded inner wheel arch on underside of vehicle |2.4.A.3| | 1 |
| Nearside Front Subframe mounting prescribed area is excessively corroded inner wheel arch , beneath battery from inside engine bay |2.4.A.3| | 1 |
| Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 1 |
| Rear brake binding | 1 |
| Rear Statutory seat belt missing |5.1.1| | 1 |
| Nearside Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 1 |
| Exhaust hydrocarbon content after 2nd fast idle exceeds manufacturers specified limits (8.2.1.2 (a)) | 1 |
| Offside Brake cable has wires broken and is significantly weakened |3.5.1b| | 1 |
| Horn sound not in accordance with requirements (7.7 (c)) | 1 |
| Offside Rear Rear fog lamp light intensity significantly reduced (4.5.4 (a)) | 1 |
| Horn sound not in accordance with requirements sound too weak. (7.7 (c)) | 1 |
| Fuel tank insecure |7.2.1| | 1 |
| Nearside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Anti-roll bar has excessive play in a pin/bearing |2.4.G.2| | 1 |
| Rear fog lamp not working |1.3.2b| | 1 |
| Rear Exhaust has a part missing |7.1.1a| | 1 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Steering wheel has movement relative to the column indicating looseness (2.2.1 (a) (i)) | 1 |
| Nearside Front Direction indicator incorrect colour (4.4.3 (a)) | 1 |
| Offside Front Direction indicator incorrect colour (4.4.3 (a)) | 1 |
| Nearside Rear coil spring incomplete |2.4.C.1a| | 1 |
| Nearside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Offside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Rear brake application uneven | 1 |
| Brake cable damaged |1.1.15 |a|| | 1 |
| Horn not working (7.7 (a)) | 1 |
| Rear Brake load sensing valve linkage seized |3.6.E.3| | 1 |
| Nearside Front Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Nearside Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Horn not working |7.7 |a| |ii|| | 1 |
| Exhaust has a major leak of exhaust gases At manifold |6.1.2 |a|| | 1 |
| Exhaust has a major leak of exhaust gases At CAT |6.1.2 |a|| | 1 |
| Central Exhaust system insecure |6.1.2 |a|| | 1 |
| Brake lining|s| wear indicator illuminated |1.1.13 |a| |i|| | 1 |
| Emissions not tested |8.2.1.2 |d|| | 1 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Driver`s door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
| Exhaust has a major leak of exhaust gases @ CAT |7.1.2| | 1 |
| Offside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside Front Seat belt insecurely fixed to the vehicles structure |5.2.1a| | 1 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 1 |
| Rear fog lamp switch faulty |1.3.1a| | 1 |
| Offside Front Lower Front suspension ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Front Lower Front suspension ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Rear Brake cable has wires broken and is significantly weakened |3.5.1b| | 1 |
| Offside Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Front Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Front Brake cable has wires broken and is significantly weakened |3.5.1b| | 1 |
| Nearside Front brake caliper has restricted free movement |3.5.1k| | 1 |
| Offside Front Obligatory mirror seriously deteriorated, affecting the rear view |8.1.2a| | 1 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Front Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Offside Front Anti-roll bar linkage pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Front Suspension component ball joint dust cover no longer prevents the ingress of dirt |5.3.4 |b| |ii|| | 1 |
| Exhaust emissions hydrocarbon content excessive |8.2.1.2 |b|| | 1 |
| Offside Rear coil spring fractured |2.4.C.1a| | 1 |
| Exhaust hydrocarbon content after 2nd fast idle exceeds default limits (8.2.1.2 (b)) | 1 |
| Exhaust carbon monoxide content at idle exceeds manufacturers specified limits (8.2.1.2 (b)) | 1 |
| Offside Front Upper Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Exhaust carbon monoxide content at idle exceeds default limits (8.2.1.2 (b)) | 1 |
| Oil leaking excessively from engine (8.4.1 (a) (i)) | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds default limits (8.2.1.2 (b)) | 1 |
| Nearside Front Upper Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds manufacturers specified limits (8.2.1.2 (a)) | 1 |
| Nearside Front Headlamp insecure (4.1.1 (c)) | 1 |
| Offside Rear Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Offside Rear Stop lamp excessively deteriorated so that it is not visible from a reasonable distance |1.2.1d| | 1 |
| Offside Front Front position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Nearside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Offside Rear Direction indicator not working |1.4.A.2c| | 1 |
| Electrical wiring damaged, likely to cause a short Wires tied back near the gas tank under the rear of the vehicle |1.9.2b| | 1 |
| Electrical wiring deteriorated and bare wires exposed Wires tied back near the gas tank under the rear of the vehicle |1.9.2c| | 1 |
| Nearside Drivers view of the road through the swept area of the windscreen significantly affected by an obstruction stickers (3.1 (a) (ii)) | 1 |
| Nearside Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Nearside Front Lower Suspension component ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Nearside Front Lower Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Lower Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Emissions not tested exhaust insecure |7.3.A.1| | 1 |
| Power steering component|s| leaking |2.3.3b| | 1 |
| Nearside Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Offside Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Nearside Headlamp insecure |1.7.3| | 1 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Front Suspension arm rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Brake pedal anti-slip provision incomplete |3.3.A.1b| | 1 |
| Nearside Front Valve stem seriously damaged (5.2.3 (j)) | 1 |
| Offside Front Valve stem seriously damaged (5.2.3 (j)) | 1 |
| Nearside Rear Valve stem seriously damaged (5.2.3 (j)) | 1 |
| Offside Rear Valve stem seriously damaged (5.2.3 (j)) | 1 |
| Front Position lamp switch does not operate in accordance with the requirements on side light position headligth comes on (4.2.2 (a)) | 1 |
| Offside Front Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Nearside Front Headlamp not working on main beam |1.7.5a| | 1 |
| Nearside Rear Rear wheel bearing has excessive play |2.6.2| | 1 |
| Steering column top bearing excessively worn |2.1.2c| | 1 |
| Rear Mechanical brake component has restricted free movement | 1 |
| Nearside Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Stop lamp(s) all not working (4.3.1 (a) (iii)) | 1 |
| Nearside Front Direction indicator obscured more than 50% |1.4.A.2d| | 1 |
| Exhaust emissions likely to be affected by an induction leak (8.2.1.1 (b)) | 1 |