| Most common failures | No# failures |
|---|
| Brake pipe excessively corroded | 34 |
| Brake hose excessively deteriorated | 23 |
| Windscreen wiper does not clear the windscreen effectively | 14 |
| Headlamp aim out of alignment | 13 |
| Registration plate lamp issues | 9 |
| Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 8 |
| Parking brake: efficiency below requirements |3.7.B.7| | 7 |
| Service brake: efficiency below requirements |3.7.B.7| | 5 |
| Rear brake binding | 5 |
| Exhaust emissions hydrocarbon content excessive |7.3.B.1b| | 5 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 5 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 5 |
| Registration plate issues | 4 |
| Parking brake lever has no reserve travel |3.1.6b| | 4 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 4 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 4 |
| Nearside Steering rack gaiter split |2.2.D.2d| | 4 |
| Brakes imbalanced across an axle | 4 |
| Steering column top bearing excessively worn |2.1.2c| | 3 |
| Offside Front Upper Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 3 |
| Nearside Stop lamp not working |1.2.1b| | 3 |
| Offside Steering rack gaiter split |2.2.D.2d| | 3 |
| Rear parking brake recording little or no effort | 3 |
| Horn not working |1.6.2a| | 3 |
| Nearside Front Steering rack gaiter split |2.2.D.2d| | 2 |
| Nearside Front Service brake excessively binding (1.2.1 (f)) | 2 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 2 |
| Hazard warning lamps inoperative (4.4.1 (e)) | 2 |
| Windscreen washer not working | 2 |
| Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Horn not working (7.7 (a)) | 2 |
| Nearside Rear Coil spring fractured or broken (5.3.1 (b) (i)) | 2 |
| Exhaust system not adequately supported |7.1.1| | 2 |
| Nearside Front Wheel bearing rough when rotated (5.1.3 (b) (i)) | 2 |
| Nearside Front wheel bearing has excessive play |2.5.A.3c| | 2 |
| Brake pedal anti-slip provision incomplete |3.3.A.1b| | 2 |
| Nearside Front wheel bearing rough when rotated |2.5.A.2| | 2 |
| Offside Stop lamp not working |1.2.1b| | 2 |
| Rear brake application uneven | 2 |
| Nearside Front Upper Ball joint has excessive play |2.2.B.1f| | 2 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 2 |
| Offside Rear wheel bearing has excessive play |2.6.2| | 2 |
| Brake hose has insufficient room to move | 2 |
| Offside Rear coil spring incomplete |2.4.C.1a| | 2 |
| Offside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 2 |
| Nearside Front Steering locking device missing |2.2.C.1g| | 1 |
| Offside Front Steering locking device missing |2.2.C.1g| | 1 |
| Offside Front Steering rack gaiter split |2.2.D.2d| | 1 |
| Nearside Rear Wheel bearing rough when rotated (5.1.3 (b) (i)) | 1 |
| Offside Hazard warning lamps inoperative front and rear (4.4.1 (e)) | 1 |
| Nearside Rear Stop lamp(s) adversely affected by the operation of another lamp (4.3.3 (b)) | 1 |
| Offside Rear Inner Suspension component mounting prescribed area excessively corroded significantly reducing structural strength sill holed and corroded (5.3.6 (a) (i)) | 1 |
| Nearside Rear Inner Suspension component mounting prescribed area excessively corroded significantly reducing structural strength wheel arch holed and corroded (5.3.6 (a) (i)) | 1 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Nearside Front Wheel stud|s| missing |4.2.A.1e| | 1 |
| Front passenger door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
| Front passenger door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
| Exhaust has a part missing |7.1.1a| | 1 |
| Exhaust tailpipe not capable of allowing the emission probe to be inserted |7.3.B.1| | 1 |
| Offside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Track rod end ball joint has excessive play passenger front |2.2.B.1f| | 1 |
| Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt passenger front lower joint |2.4.G.2| | 1 |
| Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt drivers front lower arm |2.4.G.2| | 1 |
| Seat belt anchorage prescribed area is excessively corroded passenger side |5.2.6| | 1 |
| Seat belt anchorage prescribed area is excessively corroded drivers side |5.2.6| | 1 |
| Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings passenger inner and outer sills |6.1.B.2| | 1 |
| Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings drivers side inner and outer sills |6.1.B.2| | 1 |
| Vehicle structure has excessive corrosion which adversely affects braking or steering passenger front jacking point |6.1.A.1| | 1 |
| Vehicle structure has excessive corrosion which adversely affects braking or steering drivers front jacking point |6.1.A.1| | 1 |
| Vehicle structure has excessive corrosion which adversely affects braking or steering drivers side rear chassis to jacking point |6.1.A.1| | 1 |
| Brake performance not tested brake pipes rusty |3.7.A.1| | 1 |
| Nearside Front Seat belt insecurely fixed to the seat |5.2.1a| | 1 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Rear Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 1 |
| Nearside Front Inner Suspension component mounting prescribed area is excessively corroded wheel arch |2.4.A.3| | 1 |
| Nearside Front Inner Seat belt anchorage prescribed area is excessively corroded wheel arch |5.2.6| | 1 |
| Nearside Rear Inner Suspension component mounting prescribed area is excessively corroded wheel arch |2.4.A.3| | 1 |
| Nearside Rear Outer Suspension component mounting prescribed area is excessively corroded sill |2.4.A.3| | 1 |
| Offside Rear Inner Suspension component mounting prescribed area is excessively corroded wheel arch |2.4.A.3| | 1 |
| Nearside Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Offside Rear Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Brake pipe leaking on a hydraulic braking system front to rear from master cylinder to valve (1.1.11 (b) (ii)) | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner sill (5.3.6 (a) (i)) | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner sill (5.3.6 (a) (i)) | 1 |
| Offside Rear Suspension arm corroded and seriously weakened (5.3.3 (b) (i)) | 1 |
| Parking brake lever has excessive movement indicating incorrect adjustment (1.1.6 (c)) | 1 |
| Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Offside Obligatory mirror not clearly visible from the drivers seat or incapable of being adjusted to be clearly visible from the driver`s seat |8.1.1d| | 1 |
| Nearside Front Brake hose bulging under pressure |3.6.B.3| | 1 |
| Horn control missing |1.6.1| | 1 |
| Nearside Front Upper Suspension arm ball joint dust cover missing |2.4.G.2| | 1 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 1 |
| rear brake recording little or no effort |3.7.B.5a| | 1 |
| Brake pedal spongy |3.3.B.1b| | 1 |
| Front Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Offside Rear Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Offside Front Body has a sharp edge caused by damage |6.1.C.1| | 1 |
| Nearside Front Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Outer Front Lower Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Steering pivot point has excessive play upper steering bearing |2.2.B.1g| | 1 |
| Nearside Rear coil spring incomplete |2.4.C.1a| | 1 |
| Offside Rear coil spring fractured |2.4.C.1a| | 1 |
| Brake rod excessively damaged and seriously weakened |3.5.1e| | 1 |
| Nearside Outer Rear Drive shaft uj which forms part of the suspension has a loose flange bolt |2.4.G.4c| | 1 |
| Nearside Front Upper Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Front Anti-roll bar linkage missing |5.3.3 |a| |ii|| | 1 |
| Rear Inner Suspension component mounting prescribed area excessively corroded significantly reducing structural strength wheel arch |5.3.6 |a| |i|| | 1 |
| Rear Exhaust has a major leak of exhaust gases tail pipe |6.1.2 |a|| | 1 |
| Nearside Front Steering rack gaiter missing or no longer prevents the ingress of dirt |2.1.3 |g| |ii|| | 1 |
| Steering column top bearing excessively worn |2.2.2 |b|| | 1 |
| All direction indicators not working (4.4.1 (a) (ii)) | 1 |
| Offside Front Cab steps in such a condition that it is likely to cause injury corroded |6.2.8 |b|| | 1 |
| Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded inner and outer sill |2.4.A.3| | 1 |
| Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 1 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Outer Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Fuel hose leaking |7.2.3| | 1 |
| Nearside Outer Front Anti-roll bar linkage worn and seriously weakened |2.4.G.1| | 1 |
| Offside Outer Front Anti-roll bar linkage worn and seriously weakened |2.4.G.1| | 1 |
| Parking brake lever defective so that it cannot be satisfactorily operated |3.1.3c| | 1 |
| Nearside Front Brake pipe inadequately clipped |3.6.B.1| | 1 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Front Headlamp insecure |1.7.3| | 1 |
| Rear Exhaust has a part missing |7.1.1a| | 1 |
| Brake pedal has insufficient reserve movement |3.3.A.5| | 1 |
| Emissions not tested |7.3.A.1| | 1 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Front Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Nearside Front Body has a sharp edge caused by damage |6.1.C.1| | 1 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside front brake binding |3.7.B.1| | 1 |
| Nearside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Offside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Nearside Front Upper Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Rear position lamp|s| adversely affected by the operation of another lamp with indicator operated |1.1.A.3f| | 1 |
| Offside Rear coil spring broken |2.4.C.1a| | 1 |
| Offside Front brake disc excessively pitted |3.5.1h| | 1 |
| Exhaust emissions carbon monoxide content excessive (8.2.1.2 (b)) | 1 |
| Drivers seat insecure (6.2.5 (a) (ii)) | 1 |
| Nearside Front Steering rack gaiter split (2.2.D.2d) | 1 |
| Steering column top mounting bracket insecure (2.1.2d) | 1 |
| Drivers seat insecure (6.2.A.1) | 1 |
| Nearside Front Passengers seat insecure (6.2.A.1) | 1 |
| Offside Stop lamp not working (1.2.1b) | 1 |
| Nearside Stop lamp not working (1.2.1b) | 1 |
| Offside Rear fog lamp not working |1.3.2b| | 1 |
| Horn not working (7.7 (a) (ii)) | 1 |
| Offside Hazard warning lamps inoperative |1.4.B.1b| | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Nearside Rear Body component corroded and likely to cause injury (6.2.1 (a) (i)) | 1 |
| Offside Rear Body component corroded and likely to cause injury (6.2.1 (a) (i)) | 1 |
| Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Nearside Headlamp light intensity severely reduced (4.1.4 (a)) | 1 |
| Offside Front Seat belt retracting mechanism defective (7.1.2 (e)) | 1 |
| Brake master cylinder fluid level below minimum level |3.6.G.1e| | 1 |
| Offside Rear Braking system leaking |3.6.A.1| | 1 |
| Central Statutory seat belt missing |5.1.1| | 1 |
| Nearside Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 1 |
| Nearside Rear coil spring broken |2.4.C.1a| | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength sill |5.3.6 |a| |i|| | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength sill |5.3.6 |a| |i|| | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner sill |5.3.6 |a| |i|| | 1 |
| Horn not working |7.7 |a| |ii|| | 1 |
| Nearside Front Upper Suspension arm locating pin insecure |2.4.G.3a| | 1 |
| Nearside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Rear wheel bearing has excessive play |2.6.2| | 1 |
| Nearside Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
| Horn sounds harsh or grating |1.6.2e| | 1 |
| Offside front brake binding |3.7.B.1| | 1 |
| Offside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Rear Stop lamp|s| not working both |4.3.1 |a| |ii|| | 1 |
| Exhaust has a major leak of exhaust gases tail pipe broken off |6.1.2 |a|| | 1 |
| Offside Rear Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced inner box section |6.1.1 |c| |i|| | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner lower wheel arch |5.3.6 |a| |i|| | 1 |
| Nearside Front Wheel bearing has excessive play |5.1.3 |a| |i|| | 1 |
| Emissions not tested due to exhaust fault |8.2.1.2 |d|| | 1 |
| Rear fog lamp tell-tale not working |4.9.1 |a| |ii|| | 1 |
| Nearside Front Upper Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Rear rear brake excessively fluctuating |3.7.B.3| | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds manufacturers specified limits (8.2.1.2 (a)) | 1 |
| Exhaust hydrocarbon content after 2nd fast idle exceeds manufacturers specified limits (8.2.1.2 (a)) | 1 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 1 |
| Exhaust carbon monoxide content at idle exceeds manufacturers specified limits (8.2.1.2 (b)) | 1 |
| Nearside Rear Body has a projection caused by corrosion |6.1.C.1| | 1 |
| Offside Outer Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Rear Direction indicator not working |1.4.A.2c| | 1 |
| Nearside Rear Vehicle structure excessively corroded within 30cm of towbar mounting |6.6.6| | 1 |
| Rear wheel bearing has excessive play |2.6.2| | 1 |
| Nearside Rear Suspension arm corroded and seriously weakened (5.3.3 (b) (i)) | 1 |