| Most common failures | No# failures |
|---|
| Registration plate lamp issues | 41 |
| Headlamp aim out of alignment | 40 |
| Nearside Rear Coil spring fractured or broken (5.3.1 (b) (i)) | 22 |
| Anti-lock braking system warning lamp indicates an ABS fault | 20 |
| Offside Rear Coil spring fractured or broken (5.3.1 (b) (i)) | 18 |
| Windscreen wiper does not clear the windscreen effectively | 13 |
| Registration plate issues | 11 |
| Nearside Front Shock absorbers has a serious fluid leak | 10 |
| Offside Front Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 9 |
| Supplementary restraint system warning lamp indicates a fault (7.1.6 (a)) | 8 |
| Offside Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 7 |
| Nearside Front Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 6 |
| Nearside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 6 |
| Offside Front Shock absorbers has a serious fluid leak | 5 |
| Windscreen washer not working | 5 |
| Offside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 5 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 5 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 5 |
| Offside Rear Position lamp not working (4.2.1 (a) (ii)) | 4 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 4 |
| Nearside Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 4 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 4 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 4 |
| Electronic stability control warning lamp indicates a fault (7.12 (e)) | 3 |
| Offside Rear Coil spring fractured or broken |5.3.1 |b| |i|| | 3 |
| Offside Front Coil spring fractured or broken (5.3.1 (b) (i)) | 3 |
| Nearside Front Anti-roll bar pin or bush excessively worn (5.3.4 (a) (i)) | 2 |
| Offside Front Anti-roll bar pin or bush excessively worn (5.3.4 (a) (i)) | 2 |
| Nearside Front Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 2 |
| Offside Rear fog lamp not working (4.5.1 (a) (ii)) | 2 |
| Offside Rear Brake cable damaged (1.1.15 (a)) | 2 |
| Offside Rear coil spring broken |2.4.C.1a| | 2 |
| Nearside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 2 |
| Offside Front Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 2 |
| Offside Rear Rear reflector missing (4.8.2 (a) (ii)) | 2 |
| Nearside Rear Parking brake inoperative on one side (1.4.1 (a)) | 2 |
| Engine MIL inoperative or indicates a malfunction (8.2.2.2 (g)) | 2 |
| Offside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 2 |
| Offside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 2 |
| Nearside Front Coil spring fractured or broken (5.3.1 (b) (i)) | 2 |
| Nearside Front Inner Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 2 |
| Nearside Front Road wheel fixing missing (5.2.1 (a) (i)) | 2 |
| Offside Front Anti-roll bar linkage pin or bush excessively worn (5.3.4 (a) (i)) | 2 |
| Nearside Rear Other passenger door cannot be opened from outside the vehicle (6.2.3 (a)) | 2 |
| Offside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 2 |
| Offside Rear Seat belt buckle not functioning as intended (7.1.2 (d)) | 2 |
| Nearside Rear Wheel bearing rough when rotated (5.1.3 (b) (i)) | 2 |
| Nearside Headlamp not working on main beam (4.1.1 (a) (ii)) | 2 |
| Nearside Front Upper Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Front Windscreen washer jets misaligned and not providing sufficient fluid to the windscreen (3.5 (a)) | 1 |
| Offside Rear Coil spring mounting insecure (5.3.1 (a) (i)) | 1 |
| Offside Front Inner Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Nearside Front Anti-roll bar linkage pin or bush excessively worn |5.3.4 |a| |i|| | 1 |
| Offside Front Anti-roll bar linkage pin or bush excessively worn |5.3.4 |a| |i|| | 1 |
| Central Front Seat belt retracting mechanism defective (7.1.2 (e)) | 1 |
| Rear Rear fog lamp not working |1.3.2b| | 1 |
| Nearside Front Steering rack has relative movement to chassis/bodywork nearside of steering rack excessive play (2.1.2 (a) (ii)) | 1 |
| Nearside Front Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 1 |
| Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Trailer electrical socket (13 pin) not operating the trailer lamps as intended rear fog inop (4.10 (c) (i)) | 1 |
| Nearside Front Anti-roll bar pin or bush excessively worn d-bush (5.3.4 (a) (i)) | 1 |
| Offside Front Anti-roll bar pin or bush excessively worn d-bush (5.3.4 (a) (i)) | 1 |
| Offside Front Anti-roll bar linkage insecurely attached (5.3.3 (a) (i)) | 1 |
| Rear Brake cable damaged (1.1.15 (a)) | 1 |
| Brake performance unable to be tested (1.2.1 (g)) | 1 |
| Offside Rear Seat belt not functioning as intended Mechanism not allowing seat belt to be pulled out (7.1.2 (c)) | 1 |
| Nearside Front Lower Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Trailer electrical socket (13 pin) not operating the trailer lamps as intended fog light not working (4.10 (c) (i)) | 1 |
| Exhaust emissions exceed manufacturers specified limit (8.2.2.2 (a)) | 1 |
| Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Central Front Seat belt flexible stalk deteriorated likely to lead to failure under load |5.2.4a| | 1 |
| Central Rear Seat belt buckle damaged (7.1.2 (d)) | 1 |
| Nearside Front Upper Anti-roll bar ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Nearside Front Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 1 |
| Offside Front Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 1 |
| Brakes imbalanced across an axle | 1 |
| Nearside Front Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt |5.3.4 |b| |ii|| | 1 |
| Offside Front Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt |5.3.4 |b| |ii|| | 1 |
| Dipswitch operation does not extinguish all main beam headlamps leaving at least one pair of dipped beam headlamps |1.7.4b| | 1 |
| Oil leaking excessively from engine (8.4.1 (a) (i)) | 1 |
| Offside Front Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Nearside Rear Hydraulic brake calliper leaking |1.1.16 |b| |i|| | 1 |
| Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Offside Rear Upper Coil spring fractured or broken (5.3.1 (b) (i)) | 1 |
| Offside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Nearside Front Outer Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Nearside Rear Seat belt buckle not functioning as intended (7.1.2 (d)) | 1 |
| Exhaust system insecure Sleeve (6.1.2 (a)) | 1 |
| Offside Rear Brake hose bulging under pressure Rear hose (1.1.12 (d)) | 1 |
| Nearside Rear Seat belt buckle not functioning as intended PRS (7.1.2 (d)) | 1 |
| Battery insecure and likely to fall from carrier Leisure battery (4.13 (a) (ii)) | 1 |
| Nearside Rear Service brake excessively fluctuating (1.2.1 (e)) | 1 |
| Trailer electrical socket |13 pin| not operating the trailer lamps as intended |4.10 |c| |i|| | 1 |
| Central Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Nearside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Track rod end ball joint has excessive play |2.1.3 |b| |i|| | 1 |
| Offside Rear Wheel bearing rough when rotated (5.1.3 (b) (i)) | 1 |
| Offside Side repeater not working (4.4.1 (a) (ii)) | 1 |
| Offside Front Anti-roll bar pin or bush excessively worn D Bush (5.3.4 (a) (i)) | 1 |
| Rear Brake disc significantly and obviously worn Both N/s and O/s (1.1.14 (a) (i)) | 1 |
| Offside Front Macpherson strut insecure and impairing directional stability (5.3.3 (a) (ii)) | 1 |
| Offside Rear Valve stem seriously damaged (5.2.3 (j)) | 1 |
| Nearside Rear Valve stem seriously damaged (5.2.3 (j)) | 1 |
| Nearside Front Valve stem seriously damaged (5.2.3 (j)) | 1 |
| Nearside Rear Upper Shock absorbers has an excessively worn bush (5.3.2 (c)) | 1 |
| Nearside Front Anti-roll bar linkage pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Inner Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt insecure (6.1.7 (g) (ii)) | 1 |
| Offside Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Nearside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt split (6.1.7 (g) (ii)) | 1 |
| Offside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt split (6.1.7 (g) (ii)) | 1 |
| Nearside Front Lower Suspension component ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Front Upper Steering rack gaiter missing or no longer prevents the ingress of dirt insecure (2.1.3 (g) (ii)) | 1 |
| Offside Front Headlamp levelling device inoperative Unit attached to lower arm broken (4.1.5 (a)) | 1 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Brake disc in such a condition that it is seriously weakened both front |1.1.14 |a| |ii|| | 1 |
| Windscreen damaged and affecting the drivers view of the road (3.2 (a) (ii)) | 1 |
| Nearside Rear Rear position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Nearside Front Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Central Seat belt not functioning as intended (7.1.2 (c)) | 1 |
| Rear Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Offside Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Nearside Rear coil spring broken |2.4.C.1a| | 1 |
| Offside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Rear fog lamp not working |4.5.1 |a| |ii|| | 1 |
| Offside Front Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 1 |
| Offside Front Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Nearside Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 1 |
| Nearside Front Headlamp light source and lamp not compatible (4.1.4 (c)) | 1 |
| Offside Front Headlamp light source and lamp not compatible (4.1.4 (c)) | 1 |
| Front Headlamp cleaning device for LED or HID headlamp inoperative both missing (4.1.6 (a) (ii)) | 1 |
| Supplementary restraint system warning lamp indicates a fault air bag light on (7.1.6 (a)) | 1 |
| Offside Front Suspension arm pin or bush excessively worn rear (5.3.4 (a) (i)) | 1 |
| Nearside Front Suspension arm pin or bush excessively worn front bush (5.3.4 (a) (i)) | 1 |
| Offside Rear reflector excessively damaged so that its function is impaired |1.5.1c| | 1 |
| Offside Front Headlamp levelling device inoperative |4.1.5 |a|| | 1 |
| Offside Front Lower Headlamp levelling device inoperative senor arm broken off (4.1.5 (a)) | 1 |
| Offside Front Outer Drive shaft joint excessively worn (6.1.7 (c) (i)) | 1 |
| Driver`s seat insecure |6.2.5 |a| |ii|| | 1 |
| Nearside Front Anti-roll bar ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Nearside Rear Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
| Offside Rear Shock absorbers has a serious fluid leak | 1 |
| Offside Rear Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Windscreen has damage | 1 |
| Offside Front Brake hose excessively twisted (1.1.12 (b) (ii)) | 1 |
| Central Rear Seat belt buckle not functioning as intended (7.1.2 (d)) | 1 |
| Offside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Nearside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Central Rear Seat belt damaged (7.1.2 (b) (i)) | 1 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Central Rear Seat belt not functioning as intended not extracting (7.1.2 (c)) | 1 |
| Offside Rear Valve stem seriously damaged |4.1.D.1e| | 1 |
| Nearside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 1 |
| Nearside Front Road wheel fractured |4.2.B.1a| | 1 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Rear Rear fog lamp not working |4.5.1 |a| |ii|| | 1 |
| Nearside Rear Road wheel fixing missing (5.2.1 (a) (i)) | 1 |
| Central Rear Seat belt buckle damaged Central seat buckle in the middle row (7.1.2 (d)) | 1 |
| Nearside Front Anti-roll bar linkage ball joint likely to become detached (5.3.4 (a) (ii)) | 1 |
| Offside Obligatory mirror seriously damaged, affecting the rear view (3.3 (b) (ii)) | 1 |
| Offside Body component damaged and likely to cause injury obligatory mirror cover damaged (6.2.1 (a) (i)) | 1 |
| Front brake disc in such a condition that it is seriously weakened | 1 |
| Rear Brake lining|s| less than 1.5 mm thick |1.1.13 |a| |ii|| | 1 |
| Rear brake disc in such a condition that it is seriously weakened | 1 |
| Nearside Rear Rear reflector defective or damaged by more than 50% of the reflecting surface |4.8.1 |a| |ii|| | 1 |
| Offside Rear Rear reflector defective or damaged by more than 50% of the reflecting surface |4.8.1 |a| |ii|| | 1 |
| Nearside Outer Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Nearside Rear Track rod end ball joint has excessive play |2.1.3 |b| |i|| | 1 |
| Nearside Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Rear Brake cable damaged Both rear has wires broken (1.1.15 (a)) | 1 |
| Electronic stability control warning lamp indicates a fault |7.12 |e|| | 1 |
| Nearside Rear Direction indicator incorrect colour (4.4.3 (a)) | 1 |
| Central Fuel tank insecure (6.1.3 (a) (i)) | 1 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Seat belt not functioning as intended middle belt |7.1.2 |c|| | 1 |
| Offside Front Service brake excessively binding (1.2.1 (f)) | 1 |
| Nearside Rear Seat belt retracting mechanism defective possible carpet trapping (7.1.2 (e)) | 1 |
| Offside Rear Retractable step not operating correctly possible carpet trapping (9.7 (b)) | 1 |
| Nearside Front Brake insecure not secured into bracket (1.1.21 (c)) | 1 |
| Offside Rear Brake cable damaged cable corroded causing fraying (1.1.15 (a)) | 1 |
| Central Rear Parking brake lever inoperative adjuster nut corroded and slipping on threads (1.1.6 (d)) | 1 |
| Nearside Front Brake hose excessively twisted (1.1.12 (b) (ii)) | 1 |
| Dipswitch does not operate immediately when selected on main beam (4.1.3 (b)) | 1 |
| Nearside Rear Shock absorbers has negligible damping effect (5.3.2 (d)) | 1 |
| Offside Rear Shock absorbers has negligible damping effect (5.3.2 (d)) | 1 |
| Nearside Rear Position lamp not working |4.2.1 |a|| | 1 |
| Parking brake lever pivot worn to the extent that the brake may inadvertently release mounting bolt missing (1.1.6 (b) (ii)) | 1 |
| Exhaust on a vehicle fitted with a diesel particulate filter emits visible smoke of any colour (8.2.2.2 (d)) | 1 |
| Front Service brake excessively fluctuating (1.2.1 (e)) | 1 |
| Nearside Rear Seat belt locking mechanism does not secure or release buckle |5.2.5a| | 1 |
| Nearside Rear Front passenger door cannot be opened from outside the vehicle (6.2.3 (a)) | 1 |
| Battery insecure and likely to fall from carrier (4.13 (a) (ii)) | 1 |