| Most common failures | No# failures |
|---|
| Registration plate lamp issues | 15 |
| Brake pipe excessively corroded | 11 |
| Headlamp aim out of alignment | 8 |
| Windscreen wiper does not clear the windscreen effectively | 6 |
| Brake hose excessively deteriorated | 3 |
| Anti-lock braking system warning lamp indicates an ABS fault | 3 |
| Offside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 3 |
| Brakes imbalanced across an axle | 3 |
| Rear parking brake recording little or no effort | 2 |
| Electronic stability control warning lamp indicates a fault (7.12 (e)) | 2 |
| Nearside Rear Rear reflector missing |1.5.1a| | 2 |
| Nearside Front Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 2 |
| Offside Front Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 2 |
| Nearside Obligatory mirror not clearly visible from the drivers seat or incapable of being adjusted to be clearly visible from the driver`s seat |8.1.1d| | 2 |
| Horn not working |1.6.2a| | 2 |
| Exhaust emits an excessive level of metered smoke for a turbo charged engine |7.4.B.3b| | 1 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
| Nearside Rear Coil spring fractured or broken (5.3.1 (b) (i)) | 1 |
| Nearside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Offside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 1 |
| Rear fog lamp not working |1.3.2b| | 1 |
| Electronic stability system warning lamp indicates a fault |3.4.1c| | 1 |
| Offside Front Lower Ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Nearside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength Outer sill (5.3.6 (a) (i)) | 1 |
| Offside Rear Position lamp not working |4.2.1 |a|| | 1 |
| Offside Inner Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced sill |6.1.1 |c| |i|| | 1 |
| Offside Seat belt anchorage prescribed area is excessively corroded sill |5.2.6| | 1 |
| Parking brake: efficiency below requirements |3.7.B.7| | 1 |
| Offside Front Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Front Inner Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Offside Front Drag link end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 1 |
| Offside Stop lamp not working |1.2.1b| | 1 |
| Brake warning device not working correctly |3.3.D.3a| | 1 |
| Offside Front Lower Front suspension ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Front Lower Suspension arm pin or bush excessively worn rear bush (5.3.4 (a) (i)) | 1 |
| Offside Front Lower Suspension arm pin or bush excessively worn rear bush (5.3.4 (a) (i)) | 1 |
| Offside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Nearside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Front Anti-roll bar linkage ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front Anti-roll bar linkage ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Bonnet retaining device ineffective |8.4.2| | 1 |
| Horn not working (7.7 (a) (ii)) | 1 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 1 |
| Brake servo defective or ineffective (1.1.10 (a) (i)) | 1 |
| Nearside Rear Stop lamp not working |1.2.1b| | 1 |
| Offside Rear Stop lamp not working |1.2.1b| | 1 |
| Nearside Front Lower Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front Lower Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Front Anti-roll bar has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Front Anti-roll bar has excessive play in a ball joint |2.4.G.2| | 1 |
| Exhaust emissions exceed manufacturer`s specified limit Limit of 0.80 |8.2.2.2 |a|| | 1 |
| Other passenger door does not latch securely closed Sliding door |6.2.3 |a|| | 1 |
| Nearside Front Suspension arm pin or bush excessively worn Rear bush |5.3.4 |a| |i|| | 1 |
| Offside Front Suspension arm pin or bush excessively worn Rear bush |5.3.4 |a| |i|| | 1 |
| Nearside Front Anti-roll bar pin or bush excessively worn D rubber |5.3.4 |a| |i|| | 1 |
| Offside Front Anti-roll bar pin or bush excessively worn D rubber |5.3.4 |a| |i|| | 1 |
| Central Front Brake cable damaged to rear (1.1.15 (a)) | 1 |
| Rear brake disc in such a condition that it is seriously weakened | 1 |
| Front Anti-roll bar linkage rubber bush deteriorated resulting in excessive movement x2 |2.4.G.2| | 1 |
| Front brake excessively fluctuating | 1 |
| Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Offside Front Service brake excessively fluctuating (1.2.1 (e)) | 1 |
| Nearside Rear Service brake excessively fluctuating (1.2.1 (e)) | 1 |
| Offside Rear Service brake excessively fluctuating (1.2.1 (e)) | 1 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Nearside Rear wheel bearing has excessive play |2.6.2| | 1 |
| Nearside Front Lower Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Lower Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Inner Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Nearside Front Upper Anti-roll bar linkage insecure |2.4.G.1| | 1 |
| Nearside Front Upper Anti-roll bar ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front Upper Anti-roll bar has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Windscreen in an unacceptable condition heavily damaged within swept area |3.2 |c| |i|| | 1 |
| Windscreen washer not working | 1 |
| Nearside Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
| Nearside Rear Wheel bearing rough when rotated |5.1.3 |b| |i|| | 1 |
| Nearside Front Anti-roll bar linkage ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Nearside Parking brake inoperative on one side |1.4.1 |a|| | 1 |
| Parking brake efficiency less than 50% of the required value |1.4.2 |a| |ii|| | 1 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Rear Wheel nut|s| missing |4.2.A.1e| | 1 |
| Offside Front Wheel nut|s| missing |4.2.A.1e| | 1 |
| Nearside Rear wheel bearing rough when rotated |2.6.1| | 1 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Front Glazing/screen/partition cracked or damaged which presents a danger to any person on the vehicle. |6.9.3| | 1 |
| Offside Front Obligatory mirror missing |8.1.1| | 1 |
| Offside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Front Obligatory mirror seriously damaged, affecting the rear view (3.3 (b) (ii)) | 1 |
| Battery insecure and likely to fall from carrier (4.13 (a) (ii)) | 1 |
| Nearside Front Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting (6.2.2 (d) (i)) | 1 |
| Offside Front Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting (6.2.2 (d) (i)) | 1 |
| Offside Rear Brake hose damaged and likely to fail insecure (1.1.12 (a)) | 1 |
| Front Windscreen wiper not working (3.4 (a)) | 1 |
| Nearside Front Front constant velocity joint is insecure |2.5.C.1b| | 1 |
| Nearside Rear Air suspension bellows leaking |2.4.D.3| | 1 |
| Rear Exhaust has a mounting that does not fully support the exhaust system |6.3.1b| | 1 |
| Nearside Inner Front Entrance/exit door emergency control inoperative |6.2.C.2| | 1 |
| Nearside Outer Front Entrance/exit door emergency control inoperative |6.2.C.2| | 1 |
| Rear Rear reflector missing |1.5.1a| | 1 |