| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 49 |
| Windscreen wiper does not clear the windscreen effectively | 21 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 9 |
| Rear fog lamp not working |1.3.2b| | 8 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 8 |
| Windscreen washer not working | 6 |
| Brake pipe excessively corroded | 5 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 5 |
| Brake pedal spongy |3.3.B.1b| | 4 |
| Parking brake: efficiency below requirements |3.7.B.7| | 4 |
| Offside Rear fog lamp not working |1.3.2b| | 4 |
| Nearside Rear Fuel cap/sealing device sealing washer deteriorated |7.2.4c| | 3 |
| Brakes imbalanced across an axle | 3 |
| Offside Rear Battery insecure |1.9.1| | 3 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 3 |
| Offside Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 3 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
| Registration plate lamp issues | 3 |
| Registration plate issues | 3 |
| Fuel cap/sealing device ineffective (6.1.3 (b) (i)) | 2 |
| Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 2 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 2 |
| Offside Front Obligatory mirror insecure |8.1.1| | 2 |
| Rear Passenger`s seat insecure |6.2.A.1| | 2 |
| Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 2 |
| Front Drivers view of the road through the swept area of the windscreen significantly affected by an obstruction sticker (3.1 (a) (ii)) | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Offside Front Lower Axle king pin has excessive play in pin and/or bush adversely affecting the steering |2.5.A.3a| | 1 |
| Brake pedal has insufficient reserve movement |3.3.A.5| | 1 |
| Offside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Nearside Windscreen wiper blade missing (3.4 (b) (ii)) | 1 |
| Offside Windscreen wiper blade missing (3.4 (b) (ii)) | 1 |
| Offside Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Offside Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Offside Windscreen wiper not working (3.4 (a)) | 1 |
| Offside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 1 |
| Front Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Steering column flexible coupling is excessively deteriorated marked in yellow crayon (2.2.2 (c)) | 1 |
| Nearside Front Wheel bearing has excessive play (5.1.3 (a) (i)) | 1 |
| Offside Front Wheel bearing has excessive play (5.1.3 (a) (i)) | 1 |
| Nearside Side repeater lens defective such that the emitted light is adversely affected (4.4.1 (b) (ii)) | 1 |
| Passenger`s seat insecure Middle Row |6.2.A.1| | 1 |
| Nearside Front Direction indicator incorrect colour (4.4.3 (a)) | 1 |
| Offside Front Direction indicator incorrect colour (4.4.3 (a)) | 1 |
| Horn not working (7.7 (a) (ii)) | 1 |
| Exhaust emissions hydrocarbon content after 2nd fast idle excessive |7.3.D.3| | 1 |
| Brake hose damaged | 1 |
| Brake performance unable to be tested due to condition of flexi b/pipe (1.2.1 (g)) | 1 |
| Front Service brake excessively binding nearside and offside (1.2.1 (f)) | 1 |
| Offside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Front front brake binding nearside + offside |3.7.B.1| | 1 |
| Nearside Front Service brake excessively binding (1.2.1 (f)) | 1 |
| Offside rear brake excessively fluctuating |3.7.B.3| | 1 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Battery insecure and likely to fall from carrier corroded (4.13 (a) (ii)) | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner sill (5.3.6 (a) (i)) | 1 |
| Central Drag link end ball joint has excessive play Ball joint connected to steering box (2.1.3 (b) (i)) | 1 |
| Lower Steering column universal joint insecure (2.1.3 (a) (i)) | 1 |
| Offside Rear fog lamp not working |4.5.1 |a| |ii|| | 1 |
| Nearside Rear Statutory seat belt missing |5.1.1| | 1 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 1 |
| Rear Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Emissions not tested (8.2.1.2 (d)) | 1 |
| Offside Rear Battery insecure in engine bay |1.9.1| | 1 |
| Ball joint has excessive play steering arm knuckle to rack |2.2.B.1f| | 1 |
| Front Steering column universal joint has excessive play from transfer box to rack |2.1.5| | 1 |
| Offside Windscreen wiper not operating over a large enough area to give an adequate view |8.2.1c| | 1 |
| Windscreen wiper not operating over a large enough area to give an adequate view |8.2.1c| | 1 |
| Nearside Fuel cap/sealing device ineffective |6.1.3 |b| |i|| | 1 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits |8.2.1.2 |c|| | 1 |
| Exhaust emissions likely to be affected by an exhaust leak |8.2.1.1 |b|| | 1 |
| Nearside Fuel cap/sealing device ineffective (6.1.3 (b) (i)) | 1 |
| Nearside Front Lower Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Front Axle king pin has excessive play in pin and/or bush adversely affecting the steering |2.5.A.3a| | 1 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 1 |
| Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Nearside Front Outer Axle swivel pins and bushes swivel pin and/or bush excessively worn (5.1.2 (b) (i)) | 1 |
| Offside Front Outer Axle swivel pins and bushes swivel pin and/or bush excessively worn (5.1.2 (b) (i)) | 1 |
| Front Drag link end ball joint has excessive play front arm from steering box, rear ball joint (2.1.3 (b) (i)) | 1 |
| Boot lid corroded and likely to cause injury (6.2.1 (a) (i)) | 1 |
| Nearside Front Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced outer sill by door (6.1.1 (c) (i)) | 1 |
| Offside Front Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced outer sill by door (6.1.1 (c) (i)) | 1 |
| Offside Rear Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Emissions not tested Excessive exhaust leak. (8.2.1.2 (d)) | 1 |
| Parking brake lever has excessive movement indicating incorrect adjustment (1.1.6 (c)) | 1 |
| Offside Front Wheel bearing rough when rotated (5.1.3 (b) (i)) | 1 |
| Brake master cylinder leaking (1.1.10 (b) (ii)) | 1 |
| Brake pedal has insufficient reserve travel (1.1.2 (a)) | 1 |
| Nearside Front Valve stem seriously damaged (5.2.3 (j)) | 1 |
| Offside Front Valve stem seriously damaged (5.2.3 (j)) | 1 |
| Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced Rear chassis cross member (6.1.1 (c) (i)) | 1 |
| Brake pedal has insufficient reserve travel |1.1.2 |a|| | 1 |
| Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Front All direction indicators incorrect colour (4.4.3 (a)) | 1 |
| Rear All direction indicators incorrect colour (4.4.3 (a)) | 1 |
| Rear fog lamp not working 382 bulb |1.3.2b| | 1 |
| Offside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Rear fog lamp not working poor connection |4.5.1 |a| |ii|| | 1 |
| Offside Headlamp not working on main beam |1.7.5a| | 1 |
| Central Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Rear fog lamp missing |1.3.2a| | 1 |
| Rear Exhaust has a major leak of exhaust gases silencer |6.1.2 |a|| | 1 |
| Rear parking brake recording little or no effort | 1 |
| Offside Front Direction indicator not working |1.4.A.2c| | 1 |
| Hazard warning switch inoperative |4.4.2 |a| |ii|| | 1 |
| Horn not working |7.7 |a| |ii|| | 1 |
| Offside Rear Rear fog lamp obviously incorrectly positioned (4.5.4 (a)) | 1 |
| Centre Front Steering rack gaiter split |2.2.D.2d| | 1 |
| Offside Front Steering column universal joint has excessive play from transfer box to steering rack |2.1.5| | 1 |
| Rear An item not tested |Manual| | 1 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 1 |
| Nearside Direction indicator not working |1.4.A.2c| | 1 |
| Offside Direction indicator not working |1.4.A.2c| | 1 |
| Offside Front Side repeater not working |1.4.A.2c| | 1 |
| Vehicle Identification Number not permanently displayed |6.3.5.a| | 1 |
| Steering column top bearing excessively worn |2.1.2c| | 1 |
| Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 1 |
| Offside Front Seat belt insecurely fixed to the vehicles structure |5.2.1a| | 1 |
| Nearside Front Seat belt insecurely fixed to the vehicles structure |5.2.1a| | 1 |
| Rear Brake pipe inadequately supported |3.6.B.1| | 1 |
| Offside Rear Brake pipe inadequately clipped |3.6.B.1| | 1 |
| Horn not working (7.7 (a)) | 1 |
| Emissions not tested |7.3.A.1| | 1 |