| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 14 |
| Rear fog lamp not working |1.3.2b| | 5 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 5 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 5 |
| Steering system has excessive free play detected at the steering wheel |steering box fitted| |2.2.A.1a| | 4 |
| Exhaust emissions hydrocarbon content after 2nd fast idle excessive |7.3.D.3| | 4 |
| Windscreen wiper does not clear the windscreen effectively | 4 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 3 |
| Brake hose damaged | 3 |
| Brake hose has insufficient room to move | 3 |
| Registration plate lamp issues | 3 |
| Offside Rear fog lamp not working |1.3.2b| | 3 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
| Nearside Front Lower Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced SILL/INNER ARCH/B POST/ ABOVE JACKING POINT (6.1.1 (c) (i)) | 2 |
| Offside Rear Vehicle structure excessively corroded within 30cm of towbar mounting BATTERY TRAY (6.1.6 (i) (i)) | 2 |
| Rear Towbar component excessively damaged BALL MOUNT (6.1.6 (a)) | 2 |
| Fuel cap/sealing device ineffective (6.1.3 (b) (i)) | 2 |
| Offside Rear Rear fog lamp missing (4.5.1 (a) (ii)) | 2 |
| Nearside Rear Road wheel badly distorted (5.2.2 (c) (i)) | 2 |
| Offside Front Steering linkage fouling BRAKE PIPE FOULING STEERING ARM ON FULL LOCK (2.1.4 (a)) | 2 |
| Steering system fouling (2.1.4 (a)) | 2 |
| Nearside Front Axle king pin so loose it is likely to affect directional stability (5.1.2 (d) (ii)) | 2 |
| Offside Front Axle king pin is loose in the axle beam (5.1.2 (d) (i)) | 2 |
| Nearside Rear Parking brake inoperative on one side (1.4.1 (a)) | 2 |
| Exhaust carbon monoxide content at idle exceeds default limits (8.2.1.2 (b)) | 2 |
| Windscreen washer not working | 2 |
| Steering system excessively tight |2.2.D.1| | 2 |
| Offside Rear fog lamp missing |1.3.2a| | 2 |
| Nearside front brake binding |3.7.B.1| | 2 |
| Rear parking brake recording little or no effort | 2 |
| Parking brake lever has no reserve travel |3.1.6b| | 2 |
| Parking brake: efficiency below requirements |3.7.B.7| | 2 |
| Brakes imbalanced across an axle | 2 |
| Exhaust system not adequately supported |7.1.1| | 2 |
| Nearside Side repeater not working |1.4.A.2c| | 2 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 2 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 2 |
| Nearside Hazard warning lamps inoperative |1.4.B.1b| | 2 |
| Offside Front Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced FLOOR (FOOTWELL) (6.1.1 (c) (i)) | 1 |
| Nearside Rear Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced OUTER SILL (6.1.1 (c) (i)) | 1 |
| Front Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced UNDER WINDSCREEN (6.1.1 (c) (i)) | 1 |
| Horn not working (7.7 (a)) | 1 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds manufacturers specified limits (8.2.1.2 (a)) | 1 |
| Offside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Front Shock absorbers insecurely attached (5.3.2 (a) (i)) | 1 |
| Offside Front Shock absorbers insecurely attached both sides NY lock nut not reaching threads (5.3.2 (a) (i)) | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds manufacturers specified limits CAT u/s (8.2.1.2 (a)) | 1 |
| Indicator tell tale inoperative |1.4.A.2a| | 1 |
| Nearside Front Side repeater missing |1.4.A.2b| | 1 |
| Offside Front Side repeater missing |1.4.A.2b| | 1 |
| Nearside Front Lower Anti-roll bar attachment bracket/mounting insecure |2.4.G.1| | 1 |
| Front Anti-roll bar rubber mounting bonding deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Parking brake lever ratchet mechanism is broken |3.1.5| | 1 |
| Vehicle Identification Number not legible |6.3.5.a| | 1 |
| Nearside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Offside Front Lower Axle king pin has excessive play in pin and/or bush adversely affecting the steering |2.5.A.3a| | 1 |
| Driver`s seat fore and aft adjustment mechanism not functioning as intended. |6.2.A.3| | 1 |
| Offside Rear Service brake lagging in operation (1.2.1 (d)) | 1 |
| Brake pedal spongy |3.3.B.1b| | 1 |
| Parking brake lever inoperative (1.1.6 (d)) | 1 |
| Nearside Front Shock absorbers has an excessively worn bush (5.3.2 (c)) | 1 |
| Offside Front Shock absorbers has an excessively worn bush (5.3.2 (c)) | 1 |
| Nearside Inner Track rod end ball joint dust cover insecure so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Nearside Outer Track rod end ball joint dust cover insecure so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Driver`s door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
| Emissions not tested |7.3.A.1| | 1 |
| Offside Side repeater incorrect colour |1.4.A.2f| | 1 |
| Offside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Nearside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Nearside Steering arm deformed and unserviceable |2.2.C.1d| | 1 |
| Offside Steering arm deformed and unserviceable |2.2.C.1d| | 1 |
| Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Rear fog lamp tell tale not working |1.3.1b| | 1 |
| Nearside Hazard warning lamps not flashing in phase, with ignition on |1.4.B.1f| | 1 |
| Front Windscreen wiper not working (3.4 (a)) | 1 |
| Battery insecure and likely to fall from carrier (4.13 (a) (ii)) | 1 |
| Offside Rear Rear fog lamp not working |4.5.1 |a| |ii|| | 1 |
| Offside Front Suspension component pin or bush excessively worn |5.3.4 |a| |i|| | 1 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 1 |
| Nearside Front Anti-roll bar attachment bracket/mounting insecure |5.3.3 |a| |i|| | 1 |
| Horn not working |1.6.2a| | 1 |
| Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Rear Passenger`s seat insecure |6.2.A.1| | 1 |
| Rear Statutory seat belt missing |5.1.1| | 1 |
| Nearside Front Battery insecure |1.9.1| | 1 |
| Rear Stop lamp(s) light intensity significantly reduced Both sides (4.3.3 (a) (ii)) | 1 |
| Offside Rear Other passenger door cannot be opened from outside the vehicle (6.2.3 (a)) | 1 |
| Steering box insecure |2.2.B.1a| | 1 |
| Exhaust hydrocarbon content after 2nd fast idle exceeds manufacturers specified limits (8.2.1.2 (a)) | 1 |
| Nearside Body or chassis has an inadequate repair, seriously affecting its strength within 30cm of the body mountings inner sill |6.1.B.2| | 1 |
| Offside Body or chassis has an inadequate repair, seriously affecting its strength within 30cm of the body mountings inner sill |6.1.B.2| | 1 |
| Brake pedal has insufficient reserve movement |3.3.A.5| | 1 |
| Nearside Front Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Front Shock absorber insecure |2.7.2b| | 1 |
| Nearside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings inner sill |6.1.B.2| | 1 |
| Offside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings inner sill |6.1.B.2| | 1 |
| Rear Rear fog lamp not working |1.3.2b| | 1 |
| Registration plate issues | 1 |
| Offside Rear Rear fog lamp obscured more than 50% |1.3.2c| | 1 |
| Offside Rear Rear fog lamp insecure |1.3.2a| | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds default limits |8.2.1.2 |b|| | 1 |
| Exhaust carbon monoxide content at idle exceeds default limits |8.2.1.2 |b|| | 1 |
| Centre Passenger`s seat insecure |6.2.A.1| | 1 |
| Rear Battery insecure |1.9.1| | 1 |
| Offside Front Lower Anti-roll bar attachment bracket/mounting insecure |2.4.G.1| | 1 |
| Rear Towbar locking device missing |6.6.3b| | 1 |