Most common failures | No# failures |
---|
Headlamp aim out of alignment | 13 |
Windscreen wiper does not clear the windscreen effectively | 11 |
Registration plate lamp issues | 10 |
Brakes imbalanced across an axle | 8 |
Rear parking brake recording little or no effort | 7 |
Parking brake: efficiency below requirements |3.7.B.7| | 7 |
Horn not working |1.6.2a| | 6 |
Offside Stop lamp not working |1.2.1b| | 6 |
Nearside Rear wheel bearing rough when rotated |2.6.1| | 5 |
Nearside Stop lamp not working |1.2.1b| | 5 |
Offside Rear position lamp|s| not working |1.1.A.3b| | 4 |
Offside Rear wheel bearing rough when rotated |2.6.1| | 3 |
Service brake: efficiency below requirements |3.7.B.7| | 3 |
Steering component mounting prescribed area is excessively corroded |2.2.C.1h| | 2 |
Offside Headlamp not working on dipped beam |1.7.5a| | 2 |
Nearside Headlamp not working on main beam |1.7.5a| | 2 |
Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
Nearside Front position lamp|s| not working |1.1.A.3b| | 2 |
Brake pedal anti-slip provision missing |3.3.A.1b| | 2 |
Nearside Rear Shock absorber has negligible damping effect |2.7.5| | 2 |
Offside Rear Shock absorber has negligible damping effect |2.7.5| | 2 |
Brake pedal has insufficient reserve movement |3.3.A.5| | 2 |
Battery insecure |1.9.1| | 2 |
Nearside Rear Direction indicator not working |1.4.A.2c| | 2 |
Nearside Rear position lamp|s| not working |1.1.A.3b| | 2 |
Windscreen wiper not operating over a large enough area to give an adequate view |8.2.1c| | 2 |
Nearside Front Axle king pin has excessive play in pin and/or bush adversely affecting the steering |2.5.A.3a| | 2 |
Brake pipe excessively corroded | 2 |
Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 2 |
Front Headlamp not working on main beam |1.7.5a| | 2 |
Nearside Front Headlamp not working on main beam |1.7.5a| | 2 |
Offside Front Headlamp not working on main beam |1.7.5a| | 2 |
Offside Front Front position lamp|s| not working |1.1.A.3b| | 2 |
Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 2 |
Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Stop lamp not working |1.2.1b| | 1 |
Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
Nearside Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
Offside Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
Nearside Inner Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Steering system has excessive free play detected at the steering wheel |steering box fitted| |2.2.A.1a| | 1 |
Steering system excessively rough |2.2.D.1| | 1 |
Brake master cylinder leaking hydraulic fluid |3.6.G.1f| | 1 |
Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
Dipswitch operation does not extinguish all main beam headlamps leaving at least one pair of dipped beam headlamps |1.7.4b| | 1 |
Nearside Battery insecure |1.9.1| | 1 |
Nearside Front Upper Shock absorber has an excessively worn bush |2.7.4| | 1 |
Nearside Windscreen wiper not operating over a large enough area to give an adequate view |8.2.1c| | 1 |
Offside Windscreen wiper not operating over a large enough area to give an adequate view |8.2.1c| | 1 |
Nearside Front Wheel bolt|s| missing |4.2.A.1e| | 1 |
Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
Nearside Front Statutory seat belt of the wrong type. |5.1.1| | 1 |
Offside Front Statutory seat belt of the wrong type. |5.1.1| | 1 |
Offside Front position lamp|s| not working |1.1.A.3b| | 1 |
Front Windscreen washer control missing |8.2.1a| | 1 |
Offside Rear Rear position lamp|s| excessively damaged so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
Nearside Rear position lamp|s| insecure |1.1.A.3a| | 1 |
Offside Rear position lamp|s| insecure |1.1.A.3a| | 1 |
Nearside Lower Torque/reaction arm has excessive play in a pin/bush |2.4.G.2| | 1 |
Centre Steering pivot point has excessive play |2.2.B.1g| | 1 |
Front Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
Offside Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
Nearside Headlamp not working on dipped beam |1.7.5a| | 1 |
Rear Direction indicator not working |1.4.A.2c| | 1 |
Indicator tell tale inoperative |1.4.A.2a| | 1 |
Nearside Direction indicators not working |1.4.A.2c| | 1 |
Offside Direction indicators not working |1.4.A.2c| | 1 |
Brake pedal spongy |3.3.B.1b| | 1 |
Nearside Front Direction indicator not working |1.4.A.2c| | 1 |
Offside Rear Direction indicator not working |1.4.A.2c| | 1 |
Indicator switch insecure |1.4.A.1| | 1 |
Driver`s door does not latch securely closed |6.2.B.1a| | 1 |
Nearside Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
Offside Front Axle king pin has excessive play in pin and/or bush adversely affecting the steering |2.5.A.3a| | 1 |
Nearside Front Anti-roll bar attachment bracket/mounting insecure |2.4.G.1| | 1 |
Dipswitch operation does not deflect all main beam headlamps to make them dipped beams |1.7.4b| | 1 |
Registration plate issues | 1 |
Nearside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
Nearside Rear Direction indicator incorrect colour |4.4.3 |a|| | 1 |
Nearside Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
Offside Rear Direction indicator light intensity significantly reduced |4.4.3 |a|| | 1 |
Offside Front Service brake excessively binding |1.2.1 |f|| | 1 |
Offside Rear Service brake excessively binding |1.2.1 |f|| | 1 |
Nearside Rear Service brake excessively binding |1.2.1 |f|| | 1 |
Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner sill |5.3.6 |a| |i|| | 1 |
Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength outer sill |5.3.6 |a| |i|| | 1 |
Nearside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength under front step |5.3.6 |a| |i|| | 1 |
Battery insecure and likely to cause a short circuit |4.13 |a| |ii|| | 1 |
Electrical wiring insecure and in contact with sharp edges above half shafts |4.11 |a| |ii|| | 1 |
Electrical wiring insecure and in contact with sharp edges engine bay |4.11 |a| |ii|| | 1 |
Nearside Rear Inner Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 1 |
Offside Rear Inner Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 1 |
Nearside Service brake has no recorded effort at a wheel (1.2.1 (a) (ii)) | 1 |
Nearside Parking brake inoperative on one side (1.4.1 (a)) | 1 |
Nearside Rear Brake hose excessively damaged (1.1.12 (b) (ii)) | 1 |
Service brake efficiency below requirements (1.2.2 (a) (i)) | 1 |
Nearside Rear Service brake effort inadequate at a wheel |1.2.1 |a| |i|| | 1 |
Nearside Parking brake inoperative on one side |1.4.1 |a|| | 1 |
Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Offside rear brake recording little or no effort |3.7.B.5a| | 1 |
Rear brake application uneven | 1 |
Nearside Front Brake hose excessively damaged |3.6.B.4d| | 1 |
Offside Front Brake hose excessively damaged |3.6.B.4d| | 1 |
Nearside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
Front brake excessively fluctuating | 1 |
Front front brake recording little or no effort |3.7.B.5a| | 1 |
Offside front parking brake recording little or no effort |3.7.B.6a| | 1 |
Nearside Rear Rear position lamp|s| not working |1.1.A.3b| | 1 |
Nearside Rear Wheel bolt|s| missing |4.2.A.1e| | 1 |
Offside Rear Wheel bolt|s| missing |4.2.A.1e| | 1 |
Rear Stop lamp not working |1.2.1b| | 1 |
Offside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
Centre Front Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
Nearside rear brake recording little or no effort |3.7.B.5a| | 1 |
Centre Front Horn not working |1.6.2a| | 1 |
Nearside Rear Battery insecure |1.9.1| | 1 |
Nearside Rear passenger door cannot be opened from outside the vehicle |6.2.B.1c| | 1 |
Offside Rear Direction indicators incorrect colour |1.4.A.2f| | 1 |
Offside Headlamp not working on main beam |1.7.5a| | 1 |
Rear position lamp|s| incorrect colour |1.1.A.3e| | 1 |
Front Anti-roll bar attachment bracket/mounting insecure |2.4.G.1| | 1 |
Offside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
Parking brake lever has no reserve travel |3.1.6b| | 1 |
Hazard warning lamps not flashing in phase, with ignition on |1.4.B.1f| | 1 |
Hazard warning lamps not flashing in phase, with ignition off |1.4.B.1f| | 1 |
Offside Rear Direction indicators not working |1.4.A.2c| | 1 |
Stop lamp(s) all not working (4.3.1 (a) (iii)) | 1 |
Offside Front Seat belt damaged sufficient to obstruct correct operation of the belt |5.2.2a| | 1 |
Front position lamp|s| not working |1.1.A.3b| | 1 |
Offside Front Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt both inner and outer ball joints defective boots. |2.2.C.1c| | 1 |
Nearside Front Seat belt anchorage prescribed area is excessively corroded floor |5.2.6| | 1 |
Indicator switch faulty |1.4.A.1| | 1 |
Front passenger door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
Suspension component mounting prescribed area is excessively corroded both front inner arches |2.4.A.3| | 1 |
Nearside Rear Suspension component mounting prescribed area is excessively corroded inner arch |2.4.A.3| | 1 |
Nearside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Front Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
Nearside Rear Braking system leaking |3.6.A.1| | 1 |
Nearside Rear Drive shaft which forms part of the suspension coupling gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.4.G.4e| | 1 |
Offside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Parking brake: efficiency below requirements |3.7.D.4| | 1 |
Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Offside Rear Rear position lamp|s| not working |1.1.A.3b| | 1 |
Nearside Rear Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
Direction indicators not working |1.4.A.2c| | 1 |
Intermediate drop arm excessively corroded and unserviceable |2.2.C.1d| | 1 |
Windscreen washer control missing |8.2.1a| | 1 |
Nearside Front Track rod end loose |2.2.B.1d| | 1 |
Nearside Front Headlamp insecure |1.7.3| | 1 |
Offside Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 1 |