| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 51 |
| Offside Stop lamp not working |1.2.1b| | 27 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 26 |
| Windscreen wiper does not clear the windscreen effectively | 24 |
| Registration plate lamp issues | 17 |
| Nearside Stop lamp not working |1.2.1b| | 16 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 15 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 14 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 14 |
| Parking brake: efficiency below requirements |3.7.B.7| | 13 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 11 |
| Rear parking brake recording little or no effort | 11 |
| Registration plate issues | 10 |
| Offside Side repeater not working |1.4.A.2c| | 10 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 9 |
| Nearside Rear Stop lamp not working |1.2.1b| | 9 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 9 |
| Offside Rear coil spring broken |2.4.C.1a| | 8 |
| Centre Exhaust system not adequately supported |7.1.1| | 7 |
| Offside Rear Stop lamp not working |1.2.1b| | 7 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 7 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 7 |
| Nearside Front Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 6 |
| Offside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 6 |
| Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 6 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 6 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 6 |
| Front brake disc in such a condition that it is seriously weakened | 5 |
| Anti-lock braking system warning lamp indicates an ABS fault | 5 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 5 |
| Nearside Front Macpherson strut top bush or bearing has excessive wear or free play (5.3.4 (a) (i)) | 5 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 5 |
| Nearside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 5 |
| Offside Stop lamp(s) not working (4.3.1 (a) (ii)) | 4 |
| Offside Front Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 4 |
| Offside Rear Coil spring fractured or broken (5.3.1 (b) (i)) | 4 |
| Offside Parking brake inoperative on one side (1.4.1 (a)) | 4 |
| Supplementary restraint system warning lamp indicates a fault (7.1.6 (a)) | 4 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 4 |
| Nearside Front Inner Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 4 |
| Offside Front Macpherson strut top bush or bearing has excessive wear or free play (5.3.4 (a) (i)) | 4 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 4 |
| Rear brake disc in such a condition that it is seriously weakened | 4 |
| Offside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 4 |
| Rear Exhaust system not adequately supported |7.1.1| | 3 |
| Offside Front Coil spring fractured or broken (5.3.1 (b) (i)) | 3 |
| Offside Front Side repeater not working |1.4.A.2c| | 3 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 3 |
| Nearside Front Anti-roll bar ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 3 |
| Offside Front Anti-roll bar ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 3 |
| Nearside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 3 |
| Exhaust system not adequately supported |7.1.1| | 3 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 3 |
| Offside Front coil spring broken |2.4.C.1a| | 3 |
| Nearside Front Anti-roll bar linkage ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 3 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 3 |
| Offside Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 3 |
| Offside Rear fog lamp not working |1.3.2b| | 3 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits |8.2.1.2 |c|| | 3 |
| Nearside Front Position lamp not working |4.2.1 |a|| | 3 |
| Nearside Rear Shock absorber has a serious fluid leak |2.7.3| | 3 |
| Nearside Steering rack gaiter split |2.2.D.2d| | 3 |
| Rear Exhaust system insecure (6.1.2 (a)) | 3 |
| Nearside Headlamp not working on main beam |1.7.5a| | 3 |
| Nearside Front Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 3 |
| Offside Rear Shock absorber has a serious fluid leak |2.7.3| | 3 |
| Nearside Rear Coil spring fractured or broken |5.3.1 |b| |i|| | 3 |
| Offside Rear Direction indicator not working |1.4.A.2c| | 3 |
| Brake pipe excessively corroded | 3 |
| Offside Front Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 2 |
| Offside Stop lamp|s| not working |4.3.1 |a| |ii|| | 2 |
| Nearside Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 2 |
| Offside Rear passenger door cannot be opened from outside the vehicle |6.2.B.1c| | 2 |
| Offside Rear Parking brake inoperative on one side (1.4.1 (a)) | 2 |
| Nearside Rear Coil spring fractured or broken (5.3.1 (b) (i)) | 2 |
| Nearside Rear Shock absorbers has a serious fluid leak | 2 |
| Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 2 |
| Exhaust carbon monoxide content at idle exceeds default limits (8.2.1.2 (b)) | 2 |
| Exhaust hydrocarbon content after 2nd fast idle exceeds default limits (8.2.1.2 (b)) | 2 |
| Offside Front Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced inner sill (6.1.1 (c) (i)) | 2 |
| Nearside Front Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced inner sill (6.1.1 (c) (i)) | 2 |
| Nearside Front Anti-roll bar linkage ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 2 |
| Rear Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 2 |
| Nearside Front Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 2 |
| Nearside Front Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 2 |
| Offside Front Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 2 |
| Nearside Side repeater excessively damaged so that it is not visible from a reasonable distance |1.4.A.2e| | 2 |
| Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 2 |
| Nearside Stop lamp|s| not working |4.3.1 |a| |ii|| | 2 |
| Windscreen washer not working | 2 |
| Offside Front wheel bearing rough when rotated |2.5.A.2| | 2 |
| Nearside Front Macpherson strut has excessive movement at the upper attachment |2.5.A.1c| | 2 |
| Offside Front Macpherson strut has excessive movement at the upper attachment |2.5.A.1c| | 2 |
| Nearside Front coil spring broken |2.4.C.1a| | 2 |
| Brakes imbalanced across an axle | 2 |
| Nearside Inner Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 2 |
| Nearside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 2 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 2 |
| Offside Outer Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 2 |
| Nearside Rear Position lamp not working (4.2.1 (a) (ii)) | 2 |
| Offside Rear Coil spring fractured or broken |5.3.1 |b| |i|| | 2 |
| Offside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 2 |
| Brake hose excessively deteriorated | 2 |
| Offside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 2 |
| Front brake application uneven | 2 |
| Front position lamp|s| not working |1.1.A.3b| | 2 |
| Driver`s seat fore and aft adjustment mechanism not functioning as intended. |6.2.A.3| | 2 |
| Nearside Front All position lamps not working |1.1.A.3b| | 2 |
| Offside Front Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 2 |
| Offside Rear Anti-roll bar pin or bush excessively worn (5.3.4 (a) (i)) | 2 |
| Nearside Rear Anti-roll bar pin or bush excessively worn (5.3.4 (a) (i)) | 2 |
| Offside Front Upper Anti-roll bar ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 2 |
| Exhaust hydrocarbon content after 2nd fast idle exceeds manufacturer`s specified limits |8.2.1.2 |a|| | 2 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 2 |
| Offside Rear Parking brake inoperative on one side |1.4.1 |a|| | 2 |
| Offside Front Anti-roll bar linkage ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 2 |
| Nearside Rear Other passenger door cannot be opened from outside the vehicle (6.2.3 (a)) | 2 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
| Offside Front Upper Macpherson strut pin or bush excessively worn (5.3.4 (a) (i)) | 2 |
| Nearside Front Front passenger door cannot be opened from outside the vehicle |6.2.B.1b| | 2 |
| Nearside Front Side repeater not working |1.4.A.2c| | 2 |
| Nearside Side repeater not working |1.4.A.2c| | 2 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 2 |
| Emissions not tested |7.0| | 2 |
| Offside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 2 |
| Offside Front Wheel bearing rough when rotated (5.1.3 (b) (i)) | 2 |
| Nearside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 2 |
| Offside Rear Shock absorbers has a serious fluid leak | 2 |
| Offside Front Direction indicator flashing more than 120 times a minute |1.4.A.2g| | 2 |
| Centre Exhaust has part of the system excessively deteriorated |7.1.1a| | 2 |
| Nearside Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 2 |
| Offside Front Anti-roll bar linkage ball joint excessively worn |5.3.4 |a| |i|| | 2 |
| Nearside Rear coil spring broken |2.4.C.1a| | 2 |
| Rear brake binding | 2 |
| Nearside Rear Anti-roll bar attachment bracket/mounting insecure |2.4.G.1| | 2 |
| Offside Rear Anti-roll bar attachment bracket/mounting insecure |2.4.G.1| | 2 |