| Most common failures | No# failures |
|---|
| Registration plate lamp issues | 41 |
| Headlamp aim out of alignment | 31 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 17 |
| Registration plate issues | 15 |
| Windscreen wiper does not clear the windscreen effectively | 14 |
| Windscreen washer not working | 8 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 7 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 5 |
| Parking brake: efficiency below requirements |3.7.B.7| | 4 |
| Offside Rear passenger door cannot be opened from outside the vehicle |6.2.B.1c| | 3 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 3 |
| Nearside Headlamp cleaning device inoperative |1.7.2| | 3 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 3 |
| Offside Front Headlamp cleaning device for LED or HID headlamp inoperative (4.1.6 (a) (ii)) | 3 |
| Offside Side repeater not working (4.4.1 (a) (ii)) | 3 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 3 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 3 |
| Engine MIL inoperative or indicates a malfunction (8.2.2.2 (g)) | 3 |
| Nearside Rear Service brake excessively binding (1.2.1 (f)) | 3 |
| Offside Rear Stop lamp not working |1.2.1b| | 2 |
| Electronic stability control warning lamp indicates a fault (7.12 (e)) | 2 |
| Offside Rear Inner Brake disc in such a condition that it is seriously weakened (1.1.14 (a) (ii)) | 2 |
| Nearside Side repeater not working |1.4.A.2c| | 2 |
| Nearside Rear Direction indicator not working (4.4.1 (a) (ii)) | 2 |
| Nearside Front Lower Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 2 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 2 |
| Nearside Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 2 |
| Offside Front Position lamp not working |4.2.1 |a|| | 2 |
| Engine MIL inoperative or indicates a malfunction |8.2.1.2 |h|| | 2 |
| Nearside Rear Other passenger door cannot be opened from outside the vehicle (6.2.3 (a)) | 2 |
| Offside Side repeater light intensity significantly reduced (4.4.3 (a)) | 2 |
| Nearside Rear Direction indicator not working |4.4.1 |a| |ii|| | 2 |
| Offside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 2 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 2 |
| Offside Front Service brake excessively fluctuating (1.2.1 (e)) | 2 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 2 |
| Fuel tank leaking (6.1.3 (b) (i)) | 2 |
| Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 2 |
| Nearside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 2 |
| Offside Direction indicator lens defective such that the emitted light is adversely affected (4.4.1 (b) (ii)) | 1 |
| Offside Front Headlamp light source and lamp not compatible (4.1.4 (c)) | 1 |
| Nearside Rear Direction indicator with a multiple light source more than 1/2 not functioning (4.4.1 (a) (ii)) | 1 |
| Offside Rear Inner Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Offside Rear Inner Stop lamp not working |1.2.1b| | 1 |
| Anti-lock braking system warning lamp indicates an ABS fault | 1 |
| Nearside Rear Direction indicator adversely affected by the operation of another lamp (4.4.3 (b)) | 1 |
| Offside Rear Direction indicator adversely affected by the operation of another lamp (4.4.3 (b)) | 1 |
| Offside Inner Stop lamp not working |1.2.1b| | 1 |
| Front Brake disc significantly and obviously worn both fronts (1.1.14 (a) (i)) | 1 |
| Oil leaking excessively from engine (8.4.1 (a) (i)) | 1 |
| Nearside Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Rear Brake pipe leaking on a hydraulic braking system (1.1.11 (b) (ii)) | 1 |
| Offside Rear Hydraulic brake calliper leaking and braking performance affected (1.1.16 (b) (ii)) | 1 |
| Nearside Rear Hydraulic brake calliper leaking and braking performance affected (1.1.16 (b) (ii)) | 1 |
| Front brake application uneven | 1 |
| Nearside Front Upper Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Nearside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Front Suspension arm synthetic mounting deteriorated resulting in excessive movement rear arm |2.4.G.2| | 1 |
| Offside Front Suspension arm synthetic mounting deteriorated resulting in excessive movement rear arm |2.4.G.2| | 1 |
| Offside Front Suspension arm ball joint excessively worn of front top (5.3.4 (a) (i)) | 1 |
| Nearside Indicator tell tale inoperative |1.4.A.2a| | 1 |
| Nearside Front Bumper damaged and likely to cause injury when grazed or contacted (6.1.4 (a) (i)) | 1 |
| Nearside Rear Wheel bearing has excessive play (5.1.3 (a) (i)) | 1 |
| Nearside Headlamp cleaning device for LED or HID headlamp inoperative |4.1.6 |a| |ii|| | 1 |
| Offside Headlamp cleaning device for LED or HID headlamp inoperative |4.1.6 |a| |ii|| | 1 |
| Offside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Nearside Front Track rod end ball joint has excessive play ball joint boot split (2.1.3 (b) (i)) | 1 |
| Exhaust emissions likely to be affected by an exhaust leak Centre section (8.2.2.1 (b)) | 1 |
| Front Brake disc significantly and obviously worn Inner faces |1.1.14 |a| |i|| | 1 |
| Nearside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Front Power steering pipe/hose leaking Beside steering Rack boot at metal union/pipes (2.1.5 (a)) | 1 |
| Nearside Front Headlamp light intensity severely reduced (4.1.4 (a)) | 1 |
| Offside Front Headlamp light intensity severely reduced (4.1.4 (a)) | 1 |
| Nearside Front Lower Suspension arm pin or bush excessively worn Rear. (5.3.4 (a) (i)) | 1 |
| Offside Front Lower Suspension arm pin or bush excessively worn Rear. (5.3.4 (a) (i)) | 1 |
| Offside Rear Position lamp with a multiple light source more than 1/2 not functioning LED UNIT (4.2.1 (a) (ii)) | 1 |
| Nearside Rear Hazard warning lamps inoperative |1.4.B.1b| | 1 |
| Nearside Rear Direction indicator not working |1.4.A.2c| | 1 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Front Lower Suspension arm rubber mounting deteriorated resulting in excessive movement rear arm |2.4.G.2| | 1 |
| Offside Front Lower Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Brake performance not tested (1.2.1 (g)) | 1 |
| Offside Rear Hydraulic brake calliper inadequately mounted (1.1.16 (c) (i)) | 1 |
| Offside Rear Parking brake inoperative on one side |1.4.1 |a|| | 1 |
| Offside Front Headlamp cleaning device inoperative |1.7.2| | 1 |
| Nearside Front Windscreen washer jets misaligned and not providing sufficient fluid to the windscreen (3.5 (a)) | 1 |
| Nearside Front Headlamp cleaning device for LED or HID headlamp inoperative (4.1.6 (a) (ii)) | 1 |
| Nearside Front Power steering pipe/hose leaking (2.1.5 (a)) | 1 |
| Suspension arm pin or bush excessively worn both front top outer suspension arm rubber bushes split x2 (5.3.4 (a) (i)) | 1 |
| Nearside Side repeater not working (4.4.1 (a) (ii)) | 1 |
| Offside Obligatory mirror insecure mirror glass (3.3 (b) (ii)) | 1 |
| Nearside Rear Stop lamp not working |1.2.1b| | 1 |
| Centre Rear Stop lamp not working |1.2.1b| | 1 |
| Nearside Front Side repeater not working |1.4.A.2c| | 1 |
| Nearside Front Bumper damaged and likely to cause injury when grazed or contacted |6.1.4 |a| |i|| | 1 |
| Nearside Front Side repeater not working (4.4.1 (a) (ii)) | 1 |
| Front Supplementary restraint system warning lamp indicates a fault (7.1.6 (a)) | 1 |
| Offside Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Offside Side repeater excessively damaged so that it is not visible from a reasonable distance wing mirror |1.4.A.2e| | 1 |
| Nearside Front Road wheel cracked inner edge |4.2.A.1a| | 1 |
| Offside Front Upper Suspension arm ball joint excessively worn OSF upper rear arm (marked with chalk) (5.3.4 (a) (i)) | 1 |
| Offside Front Upper Suspension arm ball joint excessively worn Upper rear outer ball joint excessively worn (Marked with chalk) (5.3.4 (a) (i)) | 1 |
| Drivers view of an obligatory external mirror significantly affected by an obstruction (3.1 (a) (ii)) | 1 |
| Nearside Front Suspension arm has excessive play in a track control arm inner bush |2.5.B.2b| | 1 |
| Offside Front Suspension arm has excessive play in a track control arm inner bush |2.5.B.2b| | 1 |
| Hazard warning switch insecure |1.4.B.1d| | 1 |
| Offside Rear Parking |secondary brake| on a single line braking system grabbing severely |1.3.1 |c|| | 1 |
| Nearside Side repeater excessively deteriorated so that it is not visible from a reasonable distance |1.4.A.2e| | 1 |
| Nearside Rear Inner Road wheel cracked |4.2.A.1a| | 1 |
| Offside Headlamp cleaning device inoperative |1.7.2| | 1 |
| Offside Rear Other passenger door cannot be opened from outside the vehicle (6.2.3 (a)) | 1 |
| Nearside Stop lamp not working |1.2.1b| | 1 |
| Front Inner Brake disc significantly and obviously worn Both sides (1.1.14 (a) (i)) | 1 |
| Rear Service brake effort inadequate at a wheel Both sides (1.2.1 (a) (i)) | 1 |
| Rear Brake disc significantly and obviously worn Both sides (1.1.14 (a) (i)) | 1 |
| Nearside Front Service brake excessively binding (1.2.1 (f)) | 1 |
| Offside Rear Service brake excessively binding parking brake not releasing fully (1.2.1 (f)) | 1 |
| Offside Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Offside Rear Direction indicator not working |4.4.1 |a| |ii|| | 1 |
| Nearside Rear Other passenger door cannot be opened from outside the vehicle |6.2.3 |a|| | 1 |
| Front Exhaust has a major leak of exhaust gases flexy pipe |6.1.2 |a|| | 1 |
| Offside Rear Service brake excessively binding parking brake not fully releasing |1.2.1 |f|| | 1 |
| Nearside Front Undertray likely to become detached |6.2.1 |a| |ii|| | 1 |
| Nearside Rear wheel bearing rough when rotated |2.6.1| | 1 |
| Nearside Front Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 1 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 1 |
| Offside Front Bumper damaged and likely to cause injury when grazed or contacted (6.1.4 (a) (i)) | 1 |
| Engine MIL inoperative or indicates a malfunction |8.2.2.2 |g|| | 1 |
| Offside Rear Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 1 |
| Hazard warning switch inoperative (4.4.2 (a) (ii)) | 1 |
| Oil leaking excessively from engine sump plug (8.4.1 (a) (i)) | 1 |
| Power steering pipe/hose leaking pipe work at n/s/f wheel arch aggressive leak (2.1.5 (a)) | 1 |
| Nearside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Rear Service brake excessively fluctuating nearside and offside (1.2.1 (e)) | 1 |
| Nearside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Nearside Front Headlamp incorrect colour (4.1.4 (a)) | 1 |
| Nearside Rear Brake lining|s| less than 1.5 mm thick |3.5.1g| | 1 |
| Nearside Rear passenger door cannot be opened from outside the vehicle |6.2.B.1c| | 1 |
| Nearside Front Service brake excessively fluctuating (1.2.1 (e)) | 1 |
| Parking brake lever defective so that it cannot be satisfactorily operated (1.1.6 (d)) | 1 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 1 |
| Nearside Front Headlamp has a product on the lens so that the light output is severely reduced (4.1.4 (b)) | 1 |
| Offside Front Headlamp has a product on the lens so that the light output is severely reduced (4.1.4 (b)) | 1 |
| Nearside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Offside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Nearside Front Anti-roll bar linkage pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Anti-roll bar linkage pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Upper Suspension arm pin or bush excessively worn Rear bush, Front arm (5.3.4 (a) (i)) | 1 |
| Fuel pipe leaking Pipe by fuel tank (6.1.3 (b) (i)) | 1 |
| Offside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Nearside Rear Anti-roll bar linkage pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Rear brake binding | 1 |
| Stop lamp adversely affected by the operation of another lamp when fog lamp is switched on only half of brake lights iluminate |1.2.1f| | 1 |
| Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Central Rear Seat belt buckle missing (7.1.2 (d)) | 1 |
| Nearside Front Lower Suspension arm pin or bush excessively worn track control arm |5.3.4 |a| |i|| | 1 |
| Offside Front Lower Suspension arm pin or bush excessively worn track control arm |5.3.4 |a| |i|| | 1 |
| Offside Front Suspension component ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Windscreen washer jets misaligned and not providing sufficient fluid to the windscreen |3.5 |a|| | 1 |
| Nearside Rear Direction indicator has less than 50% of the light sources illuminating |1.4.A.2c| | 1 |
| Offside Headlamp not working on main beam |1.7.5a| | 1 |
| Nearside Headlamp incorrect colour |1.7.5b| | 1 |
| Offside Front All position lamps not working |1.1.A.3b| | 1 |
| Nearside Rear Hydraulic brake calliper leaking |1.1.16 |b| |i|| | 1 |
| Fuel cap/sealing device does not fasten securely by positive means |7.2.4b| | 1 |
| Driver`s door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
| Brakes imbalanced across an axle | 1 |
| Offside Front Coil spring fractured or broken (5.3.1 (b) (i)) | 1 |
| Nearside Rear Wheel bearing rough when rotated (5.1.3 (b) (i)) | 1 |
| Nearside Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Nearside Rear Service brake excessively binding Restricted movement. (1.2.1 (f)) | 1 |
| Offside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Offside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Stop lamp(s) all not working (4.3.1 (a) (iii)) | 1 |
| Stop lamp(s) not working all (4.3.1 (a) (ii)) | 1 |
| Centre Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
| Nearside Front Headlamp cleaning device inoperative |1.7.2| | 1 |
| Nearside Front Power steering pipe|s| or hose|s| leaking from a joint |2.3.3b| | 1 |
| Offside Front Track rod end ball joint has excessive play inner (2.1.3 (b) (i)) | 1 |
| Nearside Rear Stop lamp(s) adversely affected by the operation of another lamp inner (4.3.3 (b)) | 1 |
| Nearside Rear Position lamp adversely affected by the operation of another lamp inner (4.2.3 (c)) | 1 |
| Nearside Rear Direction indicator lens defective such that the emitted light is adversely affected (4.4.1 (b) (ii)) | 1 |
| Nearside Front Road wheel badly distorted (5.2.2 (c) (i)) | 1 |
| Nearside Rear Road wheel badly distorted (5.2.2 (c) (i)) | 1 |
| Front brake disc in such a condition that it is seriously weakened | 1 |
| Nearside Side repeater excessively deteriorated so that it is not visible from a reasonable distance not visible from rear |1.4.A.2e| | 1 |
| Undertray likely to become detached |6.2.1 |a| |ii|| | 1 |
| Offside Front Lower Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear Direction indicator light intensity significantly reduced |4.4.3 |a|| | 1 |