| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 30 |
| Registration plate issues | 15 |
| Parking brake: efficiency below requirements |3.7.B.7| | 11 |
| Registration plate lamp issues | 9 |
| Windscreen wiper does not clear the windscreen effectively | 9 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 6 |
| Front brake disc in such a condition that it is seriously weakened | 5 |
| Rear brake binding | 5 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 5 |
| Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 4 |
| Service brake: efficiency below requirements |3.7.B.7| | 4 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 4 |
| Windscreen has damage | 3 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 3 |
| Nearside Front Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 3 |
| Rear brake disc in such a condition that it is seriously weakened | 3 |
| Rear parking brake recording little or no effort | 3 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 2 |
| Nearside Rear Other passenger door cannot be opened from outside the vehicle (6.2.3 (a)) | 2 |
| Nearside Rear Service brake excessively binding (1.2.1 (f)) | 2 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 2 |
| Parking brake is not capable of being maintained in operation by direct mechanical action only |3.1.2| | 2 |
| Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
| Offside Front Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 2 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 2 |
| Offside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 2 |
| Offside Front front brake binding |3.7.B.1| | 2 |
| Offside passenger door cannot be opened from outside the vehicle |6.2.B.1c| | 2 |
| Offside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
| Nearside Rear Braking system leaking |3.6.A.1| | 2 |
| Nearside Headlamp cleaning device inoperative |1.7.2| | 2 |
| Offside Headlamp cleaning device inoperative |1.7.2| | 2 |
| Nearside front brake binding |3.7.B.1| | 2 |
| Brakes imbalanced across an axle | 2 |
| Rear Mechanical brake component has restricted free movement | 2 |
| Offside Rear Braking system leaking |3.6.A.1| | 2 |
| Front brake excessively fluctuating | 2 |
| Nearside Side repeater not working |1.4.A.2c| | 2 |
| Brake pedal has no servo assistance |3.3.B.2| | 1 |
| Offside Front Fuel hose leaking |7.2.3| | 1 |
| Parking brake lever is not capable of being maintained in operation by direct mechanical action only (1.1.6 (f)) | 1 |
| Parking brake lever ratchet not holding correctly (1.1.6 (a)) | 1 |
| Offside Steering rack gaiter split |2.2.D.2d| | 1 |
| Nearside Steering rack gaiter insecure |2.2.D.2d| | 1 |
| Offside Front Suspension arm has excessive play in a ball joint front ball joint, arm with strut mounting |2.4.G.2| | 1 |
| Exhaust emissions exceed level of metered smoke for a turbo charged engine (8.2.2.2 (b)) | 1 |
| Rear Service brake excessively fluctuating Both sides. (1.2.1 (e)) | 1 |
| Nearside Rear Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 1 |
| Offside Rear Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 1 |
| Offside Front Lower Anti-roll bar linkage pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Offside Front Upper Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Lower Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front Lower Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Offside Rear Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Rear Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced outer sill corroded |6.1.1 |c| |i|| | 1 |
| Exhaust emits excessive smoke or vapour of any colour |7.4.B.4| | 1 |
| Emissions not tested |7.3.A.1| | 1 |
| Brake performance not tested |3.7.A.1| | 1 |
| rear brake excessively fluctuating |3.7.B.3| | 1 |
| Nearside Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Front Road wheel cracked |4.2.A.1a| | 1 |
| Nearside Rear Rear wheel bearing rough when rotated |2.6.1| | 1 |
| Nearside Front Upper Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Hazard warning lamps not flashing in phase, with ignition on |1.4.B.1f| | 1 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Rear Other passenger door cannot be opened from outside the vehicle (6.2.3 (a)) | 1 |
| Nearside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt insecure (6.1.7 (g) (ii)) | 1 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 1 |
| Nearside Rear Inner Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Front Outer Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Offside Front Outer Front constant velocity joint is insecure |2.5.C.1b| | 1 |
| Centre Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Offside Front Upper Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 1 |
| Offside Parking brake inoperative on one side |1.4.1 |a|| | 1 |
| Nearside Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Nearside Outer Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Offside Front constant velocity joint gaiter insecurely mounted to its housing |2.5.C.1a| | 1 |
| Nearside Rear Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Rear Stop lamp not working |1.2.1b| | 1 |
| Offside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Rear Tailgate cannot be secured in the closed position |6.4.1| | 1 |
| Nearside Front front brake binding |3.7.B.1| | 1 |
| Front Bonnet cannot be secured in the closed position |8.4.1| | 1 |
| Bonnet retaining device ineffective unable to check under bonnet components |8.4.2| | 1 |
| Emissions not tested (8.2.2.2 (e)) | 1 |
| Nearside Front Brake pipe leaking on a hydraulic braking system (1.1.11 (b) (ii)) | 1 |
| Offside Front Service brake excessively binding (1.2.1 (f)) | 1 |
| Offside Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Windscreen washer not working | 1 |
| Offside Front Side repeater not working |1.4.A.2c| | 1 |
| Offside Side repeater not working |1.4.A.2c| | 1 |
| Electronic stability system warning lamp indicates a fault |3.4.1c| | 1 |
| Nearside Front Lower Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Upper Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
| Nearside Front Anti-roll bar linkage pin or bush excessively worn |5.3.4 |a| |i|| | 1 |
| Offside Front Anti-roll bar linkage pin or bush excessively worn |5.3.4 |a| |i|| | 1 |
| Offside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Nearside Front Brake hose bulging under pressure (1.1.12 (d)) | 1 |
| Nearside Front Lower Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
| Front Anti-roll bar linkage rubber mounting deteriorated resulting in excessive movement Both |2.4.G.2| | 1 |
| Nearside Service brake excessively binding (1.2.1 (f)) | 1 |
| Nearside Front Upper Suspension arm pin or bush excessively worn REAR ARM BUSH (5.3.4 (a) (i)) | 1 |
| Offside Front Upper Suspension arm pin or bush excessively worn REAR ARM BUSH (5.3.4 (a) (i)) | 1 |
| Offside Front Direction indicator not working |1.4.A.2c| | 1 |
| Offside Front Lower Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Emissions not tested |7.4.B.1| | 1 |
| Offside Rear passenger door cannot be opened from outside the vehicle |6.2.B.1c| | 1 |
| Offside Rear position lamp|s| obscured more than 50% |1.1.A.3c| | 1 |
| Offside Stop lamp obscured more than 50% |1.2.1c| | 1 |
| Offside front brake binding |3.7.B.1| | 1 |
| passenger door cannot be opened from outside the vehicle |6.2.B.1c| | 1 |
| Nearside Front All position lamps not working |1.1.A.3b| | 1 |
| Offside Rear Upper Anti-roll bar linkage ball joint likely to become detached DETACHED (5.3.4 (a) (ii)) | 1 |
| Front Service brake excessively fluctuating (1.2.1 (e)) | 1 |
| Offside Rear Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Brake lever has insufficient reserve travel (1.1.2 (a)) | 1 |
| Nearside Front Lower Suspension arm pin or bush excessively worn Rear arm - Inner bush (5.3.4 (a) (i)) | 1 |
| Nearside Rear Brake pipe at imminent risk of failure or fracture (1.1.11 (a)) | 1 |
| Offside Rear Brake pipe at imminent risk of failure or fracture (1.1.11 (a)) | 1 |
| Nearside Front Upper Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Rear Service brake excessively binding |1.2.1 |f|| | 1 |
| Offside Front Body has a sharp edge caused by damage |6.1.C.1| | 1 |
| Nearside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Rear Anti-roll bar linkage pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Rear Anti-roll bar linkage pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Rear Lower Suspension arm pin or bush excessively worn outer bush (5.3.4 (a) (i)) | 1 |
| Offside Front Service brake excessively fluctuating (1.2.1 (e)) | 1 |
| Front Front position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Stop lamp not working |1.2.1b| | 1 |
| Nearside Rear brake caliper leaking |3.6.A.1| | 1 |
| Nearside Power steering pipe|s| or hose|s| excessively damaged |2.3.2| | 1 |
| Tailgate cannot be secured in the closed position |6.4.1| | 1 |
| Nearside Inner Front Lower Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Inner Front Lower Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Hazard warning switch faulty |1.4.B.1d| | 1 |
| Nearside Front Service brake grabbing severely |3.7.C.2| | 1 |
| Offside Front Service brake grabbing severely |3.7.C.2| | 1 |
| Offside Obligatory mirror insecure glass |8.1.1| | 1 |
| Nearside Rear Seat belt retracting mechanism defective |5.2.5b| | 1 |
| Nearside Front Headlamp cleaning device inoperative |1.7.2| | 1 |
| Nearside Front Headlamp has a product on the light source so that the light output is severely reduced |1.7.5a| | 1 |
| Engine MIL inoperative or indicates a malfunction |8.2.1.2 |h|| | 1 |
| Nearside Front Windscreen wiper not working |3.4 |a|| | 1 |
| Service brake efficiency less than 50% of the required value (1.2.2 (a) (ii)) | 1 |
| Brake operation has insufficient reserve pressure/vacuum to provide assistance for at least four more brake applications after the warning device has operated (or gauge shows an unsafe reading) (1.1.3 (a) (i)) | 1 |
| Front Fuel system component leaking |7.2.3| | 1 |