| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 8 |
| Registration plate lamp issues | 5 |
| Windscreen wiper does not clear the windscreen effectively | 4 |
| Brakes imbalanced across an axle | 3 |
| Nearside Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 3 |
| Nearside Stop lamp not working |1.2.1b| | 3 |
| Nearside Rear Other passenger door cannot be opened from outside the vehicle |6.2.3 |a|| | 2 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 2 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 2 |
| Engine MIL inoperative or indicates a malfunction |8.2.1.2 |h|| | 2 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 2 |
| Supplementary restraint system warning lamp indicates a fault (7.1.6 (a)) | 2 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 2 |
| Registration plate issues | 2 |
| Nearside Front Front constant velocity joint gaiter split |2.5.C.1a| | 2 |
| Front brake disc in such a condition that it is seriously weakened | 2 |
| Brake hose excessively deteriorated | 2 |
| Offside Rear Other passenger door cannot be opened from outside the vehicle (6.2.3 (a)) | 2 |
| Nearside front brake recording little or no effort |3.7.B.5a| | 1 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Headlamp aim beam image obviously incorrect both headlights badly deteriorated |1.8.A.1b| | 1 |
| Nearside Outer Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Nearside Front Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Rear brake disc in such a condition that it is seriously weakened | 1 |
| Front Lower Suspension arm rubber bush deteriorated resulting in excessive movement rear arms |both |2.4.G.2| | 1 |
| Engine MIL inoperative or indicates a malfunction EML illuminated |8.2.1.2 |h|| | 1 |
| Offside Front Position lamp not working |4.2.1 |a|| | 1 |
| Nearside Headlamp lens seriously defective Fogged to the extent that a beam image cannot be seen |4.1.1 |b| |ii|| | 1 |
| Offside Headlamp lens seriously defective Fogged to the extent that a beam image cannot be seen |4.1.1 |b| |ii|| | 1 |
| Offside Front Coil spring fractured or broken |5.3.1 |b| |i|| | 1 |
| Trailer electrical socket damaged so that lead cannot be securely connected |1.9.3b| | 1 |
| Offside Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 1 |
| Nearside Headlamp insecure |4.1.1 |c|| | 1 |
| Front Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
| Rear Direction indicators incorrect colour |1.4.A.2f| | 1 |
| Nearside Rear Direction indicators incorrect colour |1.4.A.2f| | 1 |
| Offside Rear Direction indicators incorrect colour |1.4.A.2f| | 1 |
| Nearside Rear Stop lamp not working |1.2.1b| | 1 |
| Offside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Nearside Front Brake hose twisted |found during steering lock to lock check| |2.2.D.2b| | 1 |
| Offside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Anti-lock braking system warning lamp indicates an ABS fault | 1 |
| Nearside Headlamp insecure |1.7.3| | 1 |
| Offside Headlamp insecure Front bumper insecure |1.7.3| | 1 |
| Nearside Headlamp insecure front bumper insecure |1.7.3| | 1 |
| Supplementary restraint system warning lamp indicates a fault |7.1.6 |a|| | 1 |
| Front Exhaust has a major leak of exhaust gases |6.1.2 |a|| | 1 |
| Nearside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 1 |
| Offside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 1 |
| Nearside Rear passenger door cannot be opened from outside the vehicle |6.2.B.1c| | 1 |
| Fuel system component leaking engine bay smells of gas |7.2.3| | 1 |
| Nearside Obligatory mirror seriously damaged, affecting the rear view (3.3 (b) (ii)) | 1 |
| Offside Headlamp lens seriously defective (4.1.1 (b) (ii)) | 1 |
| Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Nearside Rear Other passenger door cannot be opened from outside the vehicle (6.2.3 (a)) | 1 |
| Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Nearside Headlamp has a product on the lens so that the light output is severely reduced |4.1.4 |b|| | 1 |
| Offside Headlamp has a product on the lens so that the light output is severely reduced |4.1.4 |b|| | 1 |
| Headlamp aim not tested |4.1.2 |b|| | 1 |
| Offside Front Track rod end ball joint has excessive play |2.1.3 |b| |i|| | 1 |
| Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
| Centre Rear Seat belt damaged sufficient to obstruct correct operation of the belt |5.2.2a| | 1 |
| Headlamp lens missing Both (4.1.1 (b) (ii)) | 1 |
| Parking brake: efficiency below requirements |3.7.B.7| | 1 |
| Offside Side repeater not working |1.4.A.2c| | 1 |
| Nearside Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Exhaust has a major leak of exhaust gases all system corroded |7.1.2| | 1 |
| Nearside Front Headlamp aim beam image obviously incorrect water ingress |1.8.A.1b| | 1 |
| Nearside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Exhaust emits excessive dense blue smoke during acceleration |7.3.A.2c| | 1 |
| Exhaust emits dense blue smoke at idle |7.3.A.2b| | 1 |
| Offside Front Side repeater not working |1.4.A.2c| | 1 |
| Front brake application uneven | 1 |
| Offside Front Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
| Nearside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Nearside Front Body has a sharp edge caused by corrosion Wheel arch |6.1.C.1| | 1 |
| Offside Front Body has a sharp edge caused by damage |6.1.C.1| | 1 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Rear Stop lamp(s) adversely affected by the operation of another lamp (4.3.3 (b)) | 1 |
| Offside Rear Stop lamp(s) adversely affected by the operation of another lamp (4.3.3 (b)) | 1 |
| Nearside Rear Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Offside Rear Service brake grabbing severely (1.2.1 (c)) | 1 |
| Front Brake fluid not visible (1.1.10 (d) (iii)) | 1 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 1 |
| Offside Headlamp insecure |1.7.3| | 1 |
| Offside Rear coil spring fractured |2.4.C.1a| | 1 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Direction indicator flashing more than 120 times a minute |1.4.A.2g| | 1 |
| Hazard warning switch faulty |1.4.B.1d| | 1 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 1 |
| Offside Headlamp light intensity severely reduced (4.1.4 (a)) | 1 |
| Offside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Oil leaking excessively from engine (8.4.1 (a) (i)) | 1 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Electronic stability control warning lamp indicates a fault (7.12 (e)) | 1 |
| Nearside Front Suspension arm pin or bush excessively worn rear lower arm bush worn (chalked) (5.3.4 (a) (i)) | 1 |
| Oil leaking excessively from engine |8.4.1 |a| |i|| | 1 |
| Offside Front Anti-roll bar linkage pin or bush excessively worn |5.3.4 |a| |i|| | 1 |
| Offside Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Nearside Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |