| Most common failures | No# failures |
|---|
| Registration plate lamp issues | 47 |
| Brake pipe excessively corroded | 44 |
| Windscreen wiper does not clear the windscreen effectively | 44 |
| Brake hose excessively deteriorated | 30 |
| Headlamp aim out of alignment | 25 |
| Service brake: efficiency below requirements |3.7.B.7| | 23 |
| Horn not working |1.6.2a| | 23 |
| Brakes imbalanced across an axle | 17 |
| Parking brake: efficiency below requirements |3.7.B.7| | 14 |
| Offside Stop lamp not working |1.2.1b| | 13 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 13 |
| Nearside Stop lamp not working |1.2.1b| | 12 |
| Registration plate issues | 10 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 9 |
| Offside Rear fog lamp not working |1.3.2b| | 6 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 6 |
| Offside Front Direction indicator incorrect colour |1.4.A.2f| | 6 |
| Nearside Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 6 |
| Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 5 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 5 |
| Offside Rear coil spring fractured |2.4.C.1a| | 5 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 5 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 5 |
| Rear parking brake recording little or no effort | 5 |
| Brake load sensing valve linkage seized |3.6.E.3| | 5 |
| Offside Rear coil spring incomplete |2.4.C.1a| | 5 |
| Nearside Front Direction indicator incorrect colour |1.4.A.2f| | 5 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 5 |
| Windscreen has damage | 5 |
| Nearside Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 5 |
| Windscreen washer not working | 5 |
| Offside Rear rear brake recording little or no effort |3.7.B.5a| | 4 |
| Nearside Rear coil spring fractured |2.4.C.1a| | 4 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 4 |
| Emissions not tested |7.0| | 4 |
| Rear fog lamp not working |1.3.2b| | 4 |
| Rear brake disc in such a condition that it is seriously weakened | 4 |
| Rear brake binding | 4 |
| Rear brake application uneven | 4 |
| Front Brake cable has wires broken and is significantly weakened |3.5.1b| | 4 |
| Exhaust emits an excessive level of metered smoke for a turbo charged engine |7.4.B.3b| | 4 |
| Nearside Rear Stop lamp not working |1.2.1b| | 4 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 4 |
| Offside Rear Stop lamp not working |1.2.1b| | 4 |
| Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 4 |
| Exhaust emissions exceed level of metered smoke for a turbo charged engine (8.2.2.2 (b)) | 4 |
| Offside Rear Coil spring fractured or broken (5.3.1 (b) (i)) | 4 |
| Offside Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 4 |
| Nearside Front Lower Front suspension ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 3 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 3 |
| Brake cable has wires broken and is significantly weakened |3.5.1b| | 3 |
| Nearside Headlamp aim beam image kick up to the offside |1.8| | 3 |
| Nearside Front Position lamp not working |4.2.1 |a|| | 3 |
| Nearside Front Direction indicators incorrect colour |1.4.A.2f| | 3 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
| Service brake efficiency below requirements |1.2.2 |a| |i|| | 3 |
| Nearside Inner Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 3 |
| Rear Brake load sensing valve linkage seized |3.6.E.3| | 3 |
| Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 3 |
| Offside Front Front constant velocity joint gaiter split |2.5.C.1a| | 3 |
| Offside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 3 |
| Nearside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 3 |
| Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 3 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 3 |
| Fuel system component leaking (6.1.3 (b) (i)) | 3 |
| Offside Headlamp aim beam image kick up to the offside |1.8| | 2 |
| Offside Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 2 |
| Nearside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings outer sill |6.1.B.2| | 2 |
| Exhaust system not adequately supported |7.1.1| | 2 |
| Horn not working |7.7 |a| |ii|| | 2 |
| Nearside Front Inner Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 2 |
| Nearside Rear Service brake effort inadequate at a wheel |1.2.1 |a| |i|| | 2 |
| Offside Rear Service brake effort inadequate at a wheel |1.2.1 |a| |i|| | 2 |
| Nearside Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 2 |
| Fuel pipe leaking |7.2.3| | 2 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 2 |
| Offside Rear brake disc excessively pitted |3.5.1h| | 2 |
| Nearside Steering rack gaiter split |2.2.D.2d| | 2 |
| Offside Steering rack gaiter split |2.2.D.2d| | 2 |
| Offside Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 2 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
| Offside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 2 |
| Stop lamp not working |1.2.1b| | 2 |
| Offside Front Direction indicators incorrect colour |1.4.A.2f| | 2 |
| Battery insecure |1.9.1| | 2 |
| Driver`s door cannot be opened from inside the vehicle |6.2.B.1b| | 2 |
| Nearside Front Direction indicator incorrect colour |4.4.3 |a|| | 2 |
| Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
| Stop lamp|s| all not working |4.3.1 |a| |iii|| | 2 |
| Offside Front Lower Ball joint has excessive play |2.2.B.1f| | 2 |
| Nearside Front Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 2 |
| Offside Front Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 2 |
| Offside Steering rack gaiter insecure |2.2.D.2d| | 2 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 2 |
| Nearside Front Lower Front suspension ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 2 |
| Nearside Headlamp not working on main beam |1.7.5a| | 2 |
| Nearside Rear coil spring cracked |2.4.C.1a| | 2 |
| Offside Front Lower Front suspension ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 2 |
| Front Brake servo vacuum pipe split |3.6.C.1b| | 2 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 2 |
| Nearside Direction indicator excessively damaged so that it is not visible from a reasonable distance |1.4.A.2e| | 2 |
| Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 2 |
| Offside Rear fog lamp not working |4.5.1 |a| |ii|| | 2 |
| Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 2 |
| Brake load sensing valve seized and ABS not fitted or inoperative (1.1.17 (c) (ii)) | 2 |
| Offside Front Anti-lock braking system wiring excessively damaged (1.6 (d)) | 2 |
| Anti-lock braking system warning lamp indicates an ABS fault | 2 |
| Offside Parking brake inoperative on one side (1.4.1 (a)) | 2 |
| Nearside Rear Service brake has no recorded effort at a wheel (1.2.1 (a) (ii)) | 2 |
| Offside Stop lamp(s) not working (4.3.1 (a) (ii)) | 2 |
| Horn not working (7.7 (a) (ii)) | 2 |
| Front passenger door cannot be opened from outside the vehicle (6.2.3 (a)) | 2 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 2 |
| Nearside Front Inner Anti-roll bar pin or bush excessively worn (5.3.4 (a) (i)) | 2 |
| Nearside Front Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 2 |
| Nearside Front Service brake excessively binding (1.2.1 (f)) | 2 |
| Nearside Rear Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 2 |
| Horn not working (7.7 (a)) | 2 |
| Exhaust emissions exceed manufacturers specified limit (8.2.2.2 (a)) | 2 |
| Central Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 2 |
| Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 2 |
| Nearside Front Anti-roll bar linkage pin or bush excessively worn (5.3.4 (a) (i)) | 2 |
| Offside Front Anti-roll bar linkage pin or bush excessively worn (5.3.4 (a) (i)) | 2 |
| Offside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Nearside Track rod end ball joint dust cover missing |2.2.C.1c| | 1 |
| Nearside Front Outer Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Offside Rear Rear fog lamp missing fog lamp casing is present but has no electrical connections |1.3.2a| | 1 |
| Nearside Front Headlamp aim beam image kick up to the offside and offside front |1.8| | 1 |
| Nearside Front Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt and offside front |2.2.C.1c| | 1 |
| Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt and offside front inner lower |2.4.G.2| | 1 |
| Exhaust catalytic converter obviously modified Catalytic Convertor Obviously Modified & Wrapped In a Tape Material |8.2.1.1 |a|| | 1 |
| Nearside Front Track rod end ball joint has excessive play |2.1.3 |b| |i|| | 1 |
| Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
| Offside Rear Direction indicators not working |1.4.A.2c| | 1 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Brake cable has wires broken and is significantly weakened hand brake |3.5.1b| | 1 |
| Exhaust has a major leak of exhaust gases holed mid and front |7.1.2| | 1 |
| Front Brake cable has wires broken and is significantly weakened hand brake cable |3.5.1b| | 1 |
| Nearside Rear Direction indicator not working |1.4.A.2c| | 1 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Front Inner Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 1 |
| Exhaust has a major leak of exhaust gases |6.1.2 |a|| | 1 |
| Brake load sensing valve seized and ABS not fitted or inoperative |1.1.17 |c| |ii|| | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength chassis |5.3.6 |a| |i|| | 1 |
| Nearside Rear Seat belt anchorage prescribed area strength or continuity significantly reduced floor |7.1.1 |a| |i|| | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength floor |5.3.6 |a| |i|| | 1 |
| Fuel hose leaking |7.2.3| | 1 |
| Brake load sensing valve inoperative |3.6.E.3| | 1 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Rear Brake hose bulging under pressure |3.6.B.3| | 1 |
| Nearside Front Front suspension ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Front Lower Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Front Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front brake disc excessively pitted |3.5.1h| | 1 |
| Offside Rear rear brake excessively fluctuating |3.7.B.3| | 1 |
| Front Direction indicators incorrect colour |1.4.A.2f| | 1 |
| Centre Brake cable has wires broken and is significantly weakened |3.5.1b| | 1 |
| Front Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Nearside Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Rear Statutory seat belt missing |5.1.1| | 1 |
| Nearside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Rear brake caliper leaking |3.6.A.1| | 1 |
| Front All direction indicators incorrect colour |4.4.3 |a|| | 1 |
| Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced both front chassis |6.1.1 |c| |i|| | 1 |
| Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced front cross member |6.1.1 |c| |i|| | 1 |
| Towbar excessively corroded within 30cm of towbar mounting rear cross member |6.1.6 |i| |i|| | 1 |
| Direction indicator incorrect colour both front |4.4.3 |a|| | 1 |
| Offside Inner Track rod end ball joint has excessive play |2.1.3 |b| |i|| | 1 |
| Offside Front Brake hose porous |1.1.12 |e|| | 1 |
| Nearside Rear brake disc excessively pitted |3.5.1h| | 1 |
| Nearside rear brake juddering severely |3.7.A.5b| | 1 |
| Offside rear brake juddering severely |3.7.A.5b| | 1 |
| Windscreen wiper control is inaccessible to the driver |8.2.1a| | 1 |
| Front passenger door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
| Nearside Front Body has a sharp edge caused by damage mirror |6.1.C.1| | 1 |
| Offside Front Body insecure and dangerous to other road users bumper |6.1.B.1b| | 1 |
| Nearside Rear coil spring broken |2.4.C.1a| | 1 |
| Brake pedal anti-slip provision incomplete |3.3.A.1b| | 1 |
| Offside Front Seat belt retracting mechanism defective |5.2.5b| | 1 |
| Power steering component|s| leaking |2.3.3b| | 1 |
| Offside Front constant velocity joint is excessively worn |2.5.C.1b| | 1 |
| Nearside Body has a sharp edge caused by damage |6.1.C.1| | 1 |
| Front brake application uneven | 1 |
| Offside front brake juddering severely |3.7.A.2b| | 1 |
| Brake operation has insufficient assistance for at least two more brake applications after the warning device has operated |3.3.D.3b| | 1 |
| Nearside Rear Statutory seat belt missing |5.1.1| | 1 |
| Offside Rear Statutory seat belt missing |5.1.1| | 1 |
| Nearside Front Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Front suspension ball joint dust cover missing |2.4.G.2| | 1 |
| Brake hose has insufficient room to move | 1 |
| Nearside Front Lower Suspension arm ball joint dust cover missing |2.4.G.2| | 1 |
| Offside Front Lower Suspension arm ball joint dust cover missing |2.4.G.2| | 1 |
| Nearside Front Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
| Offside Front Direction indicator incorrect colour |4.4.3 |a|| | 1 |
| Nearside Rear Brake hose excessively damaged on axle |1.1.12 |b| |ii|| | 1 |
| Parking |secondary brake| on a single line braking system has inadequate effort at a wheel both sides |1.3.1 |a| |i|| | 1 |
| Nearside Front Lower Suspension component ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Offside Front Lower Suspension component ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Steering column top bearing excessively worn |2.2.2 |b|| | 1 |
| Offside Front position lamp|s| has less than 50% of the light sources illuminating |1.1.A.3b| | 1 |
| Offside Rear Brake cable has wires broken and is significantly weakened |3.5.1b| | 1 |
| Steering column top bearing excessively worn steering wheel loose ?? |2.1.2c| | 1 |
| Nearside Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
| Offside Front Upper Anti-roll bar linkage rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Front Lower Suspension arm rubber bush deteriorated resulting in excessive movement front bush |2.4.G.2| | 1 |
| Nearside Front Inner Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Outer Front Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Nearside Front Anti-roll bar linkage rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Anti-roll bar linkage rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Headlamp aim not tested |1.8.A.1c| | 1 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Rear position lamp|s| has less than 50% of the light sources illuminating |1.1.A.3b| | 1 |
| Offside Rear Rear position lamp|s| excessively damaged so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Offside Front Lower Ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Brake hose damaged | 1 |
| Offside Rear Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Offside Front Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Offside Front Direction indicator incomplete |1.5.A1b| | 1 |
| Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Nearside Rear Rear reflector missing |1.5.1a| | 1 |
| Centre Rear Statutory seat belt missing |5.1.1| | 1 |
| Driver`s door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
| Offside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Offside Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 1 |
| Offside Rear Direction indicator adversely affected by the operation of another lamp |1.4.A.2h| | 1 |
| Centre Rear Seat belt has a cut which has significantly weakened the webbing |5.2.2a| | 1 |
| Nearside Headlamp insecure |4.1.1 |c|| | 1 |
| Nearside Front Lower Suspension component ball joint dust cover no longer prevents the ingress of dirt |5.3.4 |b| |ii|| | 1 |
| Offside Front Lower Suspension component ball joint dust cover no longer prevents the ingress of dirt |5.3.4 |b| |ii|| | 1 |
| Offside Front Front position lamp|s| has less than 50% of the light sources illuminating |1.1.A.3b| | 1 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Headlamp insecure |1.7.3| | 1 |
| Central Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Rear brake disc excessively pitted |3.5.1h| | 1 |
| Offside Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
| Front position lamp|s| adversely affected by the operation of another lamp when brake lights are on front side lights work??? |1.1.A.3f| | 1 |
| Offside Rear coil spring broken |2.4.C.1a| | 1 |
| Direction indicators not working |1.4.A.2c| | 1 |
| Hazard warning switch faulty |1.4.B.1d| | 1 |
| Front Undertray insecure |8.1.1 |b| |i|| | 1 |
| Nearside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Rear Brake load sensing valve linkage obviously incorrectly adjusted |3.6.E.3| | 1 |
| Nearside Outer Front Seat belt has a cut which has significantly weakened the webbing |5.2.2a| | 1 |
| Nearside Rear position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Rear Brake valve damaged |3.6.A.2c| | 1 |
| Nearside Side repeater not working |1.4.A.2c| | 1 |
| Nearside Brake cable has wires broken and is significantly weakened |3.5.1b| | 1 |
| Steering pivot point has excessive play |2.2.B.1g| | 1 |
| Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Nearside Front Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
| Offside Front Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
| Offside Front Brake hose twisted |found during steering lock to lock check| |2.2.D.2b| | 1 |
| Offside Rear Rear fog lamp excessively damaged so that it is not visible from a reasonable distance |1.3.2d| | 1 |
| Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings chassis marked yellow |6.1.B.2| | 1 |
| Exhaust emits excessive smoke or vapour of any colour |7.4.B.4| | 1 |
| Nearside Front Steering arm has relative movement at its fixings rack side |2.2.B.1h| | 1 |
| Offside Front Front position lamp|s| insecure |1.1.A.3a| | 1 |
| Nearside Front Front passenger door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
| Nearside Front front brake recording little or no effort |3.7.B.5a| | 1 |
| Rear fog lamp tell tale not working |1.3.1b| | 1 |
| Nearside Outer Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
| Offside Headlamp insecure |1.7.3| | 1 |
| Nearside Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
| Offside Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
| Nearside Front Lower Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Centre Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Nearside Rear Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Front Brake lining|s| less than 1.5 mm thick |1.1.13 |a| |ii|| | 1 |
| Offside Front Lower Front suspension ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Front Exhaust system not adequately supported |7.1.1| | 1 |
| Offside Rear Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Rear Passenger`s seat insecure |6.2.A.1| | 1 |
| Rear Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced Rear Cross member |6.1.1 |c| |i|| | 1 |
| Nearside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength Within 30cm of torsion bar mounting |5.3.6 |a| |i|| | 1 |
| Offside Exhaust emissions likely to be affected by an exhaust leak center box |8.2.2.1 |b|| | 1 |
| Offside Rear Parking brake inoperative on one side |1.4.1 |a|| | 1 |
| Brake load sensing valve seized |3.6.E.3| | 1 |
| Offside Front Lower Ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Nearside Rear coil spring incomplete |2.4.C.1a| | 1 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Offside Front Wheel bolt|s| missing |4.2.A.1e| | 1 |
| Exhaust emissions exceed manufacturer`s specified limit |8.2.2.2 |a|| | 1 |
| Rear fog lamp not working |4.5.1 |a| |ii|| | 1 |
| Fuel system component leaking leak off hoses |7.2.3| | 1 |
| Offside Front Track rod end ball joint has excessive play |2.1.3 |b| |i|| | 1 |
| Offside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings sill |6.1.B.2| | 1 |
| Nearside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Front Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front Driver`s door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
| Front Body panel corroded and likely to cause injury both wings |6.2.1 |a| |i|| | 1 |
| Exhaust emissions exceed level of metered smoke for a turbo charged engine |8.2.2.2 |b|| | 1 |
| Nearside Steering rack gaiter missing or no longer prevents the ingress of dirt |2.1.3 |g| |ii|| | 1 |
| Offside Parking brake inoperative on one side |1.4.1 |a|| | 1 |
| Nearside Front Seat belt damaged sufficient to significantly weakened the webbing |5.2.2a| | 1 |
| Offside Front Lower Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| coil spring broken |2.4.C.1a| | 1 |
| Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Front position lamp|s| not working |1.1.A.3b| | 1 |
| Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings crash panel corroded near exhaust |6.1.B.2| | 1 |
| Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Rear Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Offside Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
| Front position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Rear coil spring fractured |2.4.C.1a| | 1 |
| Exhaust has a major leak of exhaust gases on cat |7.1.2| | 1 |
| Rear Brake load sensing valve seized |3.6.E.3| | 1 |
| Emissions not tested |7.4.B.1| | 1 |
| Steering column top bearing excessively worn |2.1.2c| | 1 |
| Nearside Front Steering rack gaiter split |2.2.D.2d| | 1 |
| Offside Front Steering rack gaiter split |2.2.D.2d| | 1 |
| Nearside Front Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Nearside Front Upper Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front Upper Suspension arm ball joint dust cover no longer prevents the ingress of dirt |5.3.4 |b| |ii|| | 1 |
| Offside Front Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Rear fog lamp obviously incorrectly positioned |1.3.2a| | 1 |
| Emissions not tested due to rear silencer adrift |8.2.2.2 |e|| | 1 |
| Rear Exhaust has a major leak of exhaust gases |6.1.2 |a|| | 1 |
| Rear Exhaust silencer insecure adrift |8.1.1 |b| |i|| | 1 |
| Nearside Headlamp aim projected beam image is obviously incorrect kick up to right |4.1.2 |c|| | 1 |
| Offside Headlamp aim projected beam image is obviously incorrect kick up to right |4.1.2 |c|| | 1 |
| Nearside Rear Coil spring fractured or broken |5.3.1 |b| |i|| | 1 |
| Nearside Rear Service brake excessively binding |1.2.1 |f|| | 1 |
| Headlamp aim so that beam "kick up" is not visible on the screen both kick up to right |4.1.2 |a|| | 1 |
| Offside Rear Body insecure bumper |6.2.2 |a| |i|| | 1 |
| Nearside Headlamp aim beam image kick up to the offside and to low |1.8| | 1 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 1 |
| Offside Rear Body insecure and dangerous to other road users bumper |6.1.B.1b| | 1 |
| Offside Rear Body has a sharp edge caused by damage light unit broken |6.1.C.1| | 1 |
| Nearside Front Position lamp not working bulb holder damaged (4.2.1 (a) (ii)) | 1 |
| Nearside Front Anti-lock braking system wheel speed sensor excessively damaged (1.6 (c)) | 1 |
| Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Nearside Drivers door cannot be opened from inside the vehicle (6.2.3 (a)) | 1 |
| Nearside Drivers door cannot be opened from outside the vehicle (6.2.3 (a)) | 1 |
| Front Body component corroded and likely to cause injury both outer wings (6.2.1 (a) (i)) | 1 |
| Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength both outer sills (5.3.6 (a) (i)) | 1 |
| Offside Front Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Offside Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Offside Rear Brake hose leaking on a hydraulic braking system (1.1.12 (c) (ii)) | 1 |
| Offside Rear Service brake has no recorded effort at a wheel (1.2.1 (a) (ii)) | 1 |
| Offside Front Anti-roll bar linkage insecurely attached not attached (5.3.3 (a) (i)) | 1 |
| Nearside Obligatory mirror insecure (3.3 (b) (ii)) | 1 |
| Offside Obligatory mirror seriously damaged, affecting the rear view glass broken (3.3 (b) (ii)) | 1 |
| Central Exhaust has a major leak of exhaust gases box (6.1.2 (a)) | 1 |
| Offside Front Drivers door cannot be opened from inside the vehicle (6.2.3 (a)) | 1 |
| Nearside Front Front passenger door cannot be opened from inside the vehicle (6.2.3 (a)) | 1 |
| Nearside Front Front passenger door cannot be opened from outside the vehicle (6.2.3 (a)) | 1 |
| Hazard warning switch inoperative (4.4.2 (a) (ii)) | 1 |
| All direction indicators not working (4.4.1 (a) (ii)) | 1 |
| Nearside Front Position lamp not working replaced bulb. Tested ok (4.2.1 (a) (ii)) | 1 |
| Front passenger door cannot be opened from inside the vehicle (6.2.3 (a)) | 1 |
| Seat belt webbing significantly weakened drivers (7.1.2 (b) (ii)) | 1 |
| Brake hydraulic reservoir fluid level significantly below minimum level (1.1.10 (d) (ii)) | 1 |
| Offside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt insecure (6.1.7 (g) (ii)) | 1 |
| Nearside Front Service brake lagging in operation (1.2.1 (d)) | 1 |
| Nearside Front Service brake effort inadequate at a wheel (1.2.1 (a) (i)) | 1 |
| Offside Rear Service brake effort inadequate at a wheel (1.2.1 (a) (i)) | 1 |
| Nearside Rear Service brake effort inadequate at a wheel (1.2.1 (a) (i)) | 1 |
| Brake pipe leaking on a hydraulic braking system (1.1.11 (b) (ii)) | 1 |
| Service brake efficiency less than 50% of the required value (1.2.2 (a) (ii)) | 1 |
| Steering column has excessive movement up and down steering wheel pulls up and down (2.2.2 (a)) | 1 |
| Nearside Front Anti-roll bar pin or bush excessively worn drop link (5.3.4 (a) (i)) | 1 |
| Offside Front Anti-roll bar pin or bush excessively worn drop link (5.3.4 (a) (i)) | 1 |
| Nearside Rear Direction indicator incorrect colour (4.4.3 (a)) | 1 |
| Nearside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength chasis area in inner wing (5.3.6 (a) (i)) | 1 |
| Offside Front Inner Anti-roll bar pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Rear Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Front Steering rack insecure to the extent there is excessive movement at the mountings on both mountings (2.1.3 (a) (ii)) | 1 |
| Central Front Brake cable damaged park brake (1.1.15 (a)) | 1 |
| Nearside Power steering component leaking (2.1.5 (a)) | 1 |
| Exhaust emissions test not completed because smoke levels are significantly in excess of the specified limit values (8.2.2.2 (f)) | 1 |
| Nearside Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Offside Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Nearside Front Upper Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Front Lower Suspension arm pin or bush excessively worn front bush (5.3.4 (a) (i)) | 1 |
| Oil leaking excessively from engine (8.4.1 (a) (i)) | 1 |
| Brake fluid significantly below minimum mark (1.1.10 (d) (ii)) | 1 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 1 |
| Nearside Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Nearside Front Lower Suspension arm ball joint likely to become detached (5.3.4 (a) (ii)) | 1 |
| Service brake effort inadequate at a wheel both rear (1.2.1 (a) (i)) | 1 |
| Brake load sensing valve linkage defective and function impaired (1.1.17 (a)) | 1 |
| Brake load sensing valve inoperative and ABS not fitted or inoperative (1.1.17 (c) (ii)) | 1 |
| Nearside Front All direction indicators incorrect colour (4.4.3 (a)) | 1 |
| Nearside Rear All direction indicators not working (4.4.1 (a) (ii)) | 1 |
| Rear Stop lamp(s) all not working (4.3.1 (a) (iii)) | 1 |
| Nearside Front Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced inner sill (6.1.1 (c) (i)) | 1 |
| Nearside Front Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced inner arch area (6.1.1 (c) (i)) | 1 |
| Offside Rear Body panel corroded and likely to cause injury (6.2.1 (a) (i)) | 1 |
| Nearside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Nearside Stop lamp(s) light intensity significantly reduced (4.3.3 (a) (ii)) | 1 |
| Offside Stop lamp(s) light intensity significantly reduced (4.3.3 (a) (ii)) | 1 |
| Offside Rear Position lamp adversely affected by the operation of another lamp brake and side light (4.2.3 (c)) | 1 |
| Nearside Steering rack gaiter missing or no longer prevents the ingress of dirt split (2.1.3 (g) (ii)) | 1 |
| Nearside Parking brake inoperative on one side calliper leaver sized (1.4.1 (a)) | 1 |
| Offside Front Seat belt retracting mechanism defective (7.1.2 (e)) | 1 |
| Nearside Front Front passenger door cannot be opened from inside the vehicle Cable tie attached (6.2.3 (a)) | 1 |
| Offside Front Seat belt webbing significantly weakened (7.1.2 (b) (ii)) | 1 |
| Offside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Nearside Front Anti-roll bar pin or bush excessively worn D Bush (5.3.4 (a) (i)) | 1 |
| Offside Front Anti-roll bar pin or bush excessively worn D Bush (5.3.4 (a) (i)) | 1 |
| Nearside Front Lower Suspension arm pin or bush excessively worn Rear Bush (5.3.4 (a) (i)) | 1 |
| Supplementary restraint system warning lamp indicates a fault (7.1.6 (a)) | 1 |
| Brake lever has insufficient reserve travel (1.1.2 (a)) | 1 |
| Nearside Rear Outer Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Nearside Rear Inner Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Nearside Inner Suspension component mounting prescribed area excessively corroded significantly reducing structural strength middle section chalked (5.3.6 (a) (i)) | 1 |
| Nearside Front Inner Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Nearside Front Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced inside wheel arch (6.1.1 (c) (i)) | 1 |
| Rear Vehicle structure is so weakened by corrosion within 30cm of a towbar mounting, the towbar is likely to become detached (6.1.6 (i) (ii)) | 1 |
| Nearside Front Lower Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Offside Front Lower Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Front brake disc in such a condition that it is seriously weakened | 1 |
| Nearside Front Lower Seat belt anchorage prescribed area strength or continuity significantly reduced (7.1.1 (a) (i)) | 1 |
| Trailer electrical socket (13 pin) not functioning at all unable to plug in (4.10 (c) (ii)) | 1 |
| Nearside Front Steering rack gaiter missing or no longer prevents the ingress of dirt loose (2.1.3 (g) (ii)) | 1 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Front Lower Integral body structure is fractured and structural rigidity is significantly reduced sill area damaged / corroded (6.1.1 (a) (i)) | 1 |
| Nearside Front Inner Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced wheel arch / subframe area (6.1.1 (c) (i)) | 1 |
| Offside Rear Inner Suspension component mounting prescribed area excessively corroded significantly reducing structural strength wheel arch area / suspension mounting (5.3.6 (a) (i)) | 1 |
| Nearside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Offside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Emissions not tested exhaust blow (8.2.2.2 (e)) | 1 |
| Offside Front Subframe mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Horn sound not in accordance with requirements (7.7 (c)) | 1 |
| Offside Front Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Nearside Rear Inner Suspension component mounting prescribed area excessively corroded significantly reducing structural strength sill, at suspension arm mount (5.3.6 (a) (i)) | 1 |
| Offside Rear Inner Suspension component mounting prescribed area excessively corroded significantly reducing structural strength sill, at suspension arm mount (5.3.6 (a) (i)) | 1 |
| Offside Outer Suspension component mounting prescribed area excessively corroded significantly reducing structural strength sill (5.3.6 (a) (i)) | 1 |
| Nearside Front Inner Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Offside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Front Inner Suspension component mounting prescribed area excessively corroded significantly reducing structural strength wing / chassis (5.3.6 (a) (i)) | 1 |
| Central Rear Brake load sensing valve inoperative but ABS functioning (1.1.17 (c) (i)) | 1 |
| Central Rear Brake load sensing valve linkage obviously incorrectly adjusted (1.1.17 (b)) | 1 |
| Rear Service brake effort inadequate at a wheel both (1.2.1 (a) (i)) | 1 |
| Emissions unable to be completed Due to exhaust leak (8.2.2.2 (e)) | 1 |
| Exhaust has a major leak of exhaust gases centre silencer holed (6.1.2 (a)) | 1 |
| Nearside Front Lower Suspension component ball joint dust cover no longer prevents the ingress of dirt in bottom of hub (5.3.4 (b) (ii)) | 1 |
| Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength crossmember (5.3.6 (a) (i)) | 1 |
| Nearside Front Track rod end ball joint dust cover insecure so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Offside Obligatory mirror missing (3.3 (a)) | 1 |
| Nearside Headlamp aim projected beam image is obviously incorrect dip wrong way (4.1.2 (c)) | 1 |
| Offside Headlamp aim projected beam image is obviously incorrect dip wrong way (4.1.2 (c)) | 1 |
| Offside Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced outer sill (6.1.1 (c) (i)) | 1 |
| Nearside Front Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced out rigger (6.1.1 (c) (i)) | 1 |
| Offside Front Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced out rigger (6.1.1 (c) (i)) | 1 |
| Nearside Front Direction indicator incorrect colour (4.4.3 (a)) | 1 |
| Nearside Front Lower Suspension component ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Vehicle structure or chassis has excessive corrosion to the extent that overall security or stability of the body is impaired (6.2.2 (d) (ii)) | 1 |
| Rear Service brake effort inadequate at a wheel nearside and offside (1.2.1 (a) (i)) | 1 |
| Nearside Front Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced Inner Sill (6.1.1 (c) (i)) | 1 |
| Nearside Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced Inner Sill/ Step (6.1.1 (c) (i)) | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength Inner Sill - Next To Arm Mounting (5.3.6 (a) (i)) | 1 |
| Nearside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Rear Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Offside Front Vehicle structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting Inner wing (6.2.2 (d) (i)) | 1 |
| Emissions unable to be completed (8.2.2.2 (e)) | 1 |
| Front Exhaust has a major leak of exhaust gases snapped (6.1.2 (a)) | 1 |
| Emissions unable to be completed due to exhaust leak (8.2.2.2 (e)) | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength outer arm mount (5.3.6 (a) (i)) | 1 |
| Nearside Front Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced (6.1.1 (c) (i)) | 1 |
| Nearside Front Service brake has no recorded effort at a wheel (1.2.1 (a) (ii)) | 1 |
| Offside Front Service brake has no recorded effort at a wheel (1.2.1 (a) (ii)) | 1 |
| Nearside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Offside Front Direction indicator not working (4.4.1 (a) (ii)) | 1 |
| Nearside Front Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Power steering pipe/hose leaking pipe from steering rack (2.1.5 (a)) | 1 |
| Fuel tank leaking (6.1.3 (b) (i)) | 1 |
| Offside Front Lower Power steering pump leaking (2.1.5 (a)) | 1 |
| Nearside Front Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Offside Front Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced inner arch / step (6.1.1 (c) (i)) | 1 |
| Offside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Offside Rear Direction indicator not working (4.4.1 (a) (ii)) | 1 |
| Central Exhaust has a major leak of exhaust gases centre exhaust box holed (6.1.2 (a)) | 1 |
| Exhaust emissions likely to be affected by an exhaust leak (8.2.2.1 (b)) | 1 |
| Offside Front Inner Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Nearside Front Inner Seat belt anchorage prescribed area strength or continuity significantly reduced SILL (7.1.1 (a) (i)) | 1 |
| Nearside Rear Position lamp adversely affected by the operation of another lamp (4.2.3 (c)) | 1 |
| Nearside Front Steering rack gaiter missing or no longer prevents the ingress of dirt gaiter split (2.1.3 (g) (ii)) | 1 |
| Nearside Rear Coil spring fractured or broken (5.3.1 (b) (i)) | 1 |