| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 9 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 5 |
| Brake hose excessively deteriorated | 4 |
| Registration plate lamp issues | 3 |
| Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 3 |
| Rear Brake load sensing valve linkage seized |3.6.E.3| | 3 |
| Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 3 |
| Offside Outer Front constant velocity joint gaiter insecure to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 2 |
| Offside Steering rack gaiter split |2.2.D.2d| | 2 |
| Brake pipe excessively corroded | 2 |
| Brakes imbalanced across an axle | 2 |
| Exhaust engine idle speed too high |7.3.D.1| | 2 |
| Offside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
| Windscreen wiper does not clear the windscreen effectively | 2 |
| Centre Upper Stop lamp emits other than a steady red light |1.2.1e| | 2 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 1 |
| Battery insecure |1.9.1| | 1 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Offside Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Front Lower Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Horn not working |7.7 |a| |ii|| | 1 |
| Offside Rear Service brake effort inadequate at a wheel |1.2.1 |a| |i|| | 1 |
| Exhaust emissions carbon monoxide content excessive |8.2.1.2 |b|| | 1 |
| Stop lamp not working offside,nearside & upper |1.2.1b| | 1 |
| Nearside Rear reflector missing reflector in rear bumper |1.5.1a| | 1 |
| Trailer electrical socket |13 pin| not operating the trailer lamps as intended |1.9.4| | 1 |
| Offside Track rod end ball joint has excessive play steering |2.2.B.1f| | 1 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Offside Rear Rear position lamp|s| incorrect colour lamp unit lens broken & showing white light to rear |1.1.A.3e| | 1 |
| Offside Rear Direction indicator incorrect colour lamp unit broken & showing white light to rear |1.4.A.2f| | 1 |
| Offside Front Direction indicator excessively damaged so that it is not visible from a reasonable distance indicator lamp unit broken |1.4.A.2e| | 1 |
| Nearside Front Direction indicator not working |1.4.A.2c| | 1 |
| Stop lamp not working all stop lamps inoperative |1.2.1b| | 1 |
| Nearside Rear Rear reflector missing bumper mounted reflector unit missing |1.5.1a| | 1 |
| Offside Front Anti-roll bar linkage insecure suspension anti-roll bar link top attachment insecure & misplaced |2.4.G.1| | 1 |
| Nearside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Front Upper Anti-roll bar linkage rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Upper Anti-roll bar linkage rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Centre Exhaust system not adequately supported |7.1.1| | 1 |
| Stop lamp|s| all not working |4.3.1 |a| |iii|| | 1 |
| Steering wheel in a condition that hampers proper control device fitted to steering. |2.1.1| | 1 |
| Nearside Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Offside Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Nearside Rear Stop lamp not working |1.2.1b| | 1 |
| Offside Rear Stop lamp not working |1.2.1b| | 1 |
| Upper Stop lamp emits other than a steady red light |1.2.1e| | 1 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 1 |
| Rear Brake load sensing valve seized |3.6.E.3| | 1 |
| Offside Front Front constant velocity joint gaiter insecure to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Offside Front Upper Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Front Lower Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Rear fog lamp not working |1.3.2b| | 1 |
| Offside Inner Headlamp insecure |1.7.3| | 1 |
| Nearside Front Driver`s seat insecure |6.2.A.1| | 1 |
| Offside Outer Front constant velocity joint gaiter insecurely mounted to its housing |2.5.C.1a| | 1 |
| Nearside Rear coil spring fractured |2.4.C.1a| | 1 |
| Rear brake application uneven | 1 |
| Rear Body has a projection caused by damage |6.1.C.1| | 1 |
| Offside Front Obligatory mirror missing |8.1.1| | 1 |
| Offside Headlamp insecure |1.7.3| | 1 |
| Nearside Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Outer Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
| Nearside Outer Front constant velocity joint gaiter insecurely mounted to its housing |2.5.C.1a| | 1 |
| Offside Front Passenger`s seat insecure |6.2.A.1| | 1 |
| Offside Rear fog lamp not working |4.5.1 |a| |ii|| | 1 |
| Nearside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt swivel joint |5.3.4 |b| |ii|| | 1 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Rear Service brake is causing the vehicle to swerve to the nearside |3.7.C.2| | 1 |
| Nearside Front Brake hose bulging under pressure |3.6.B.3| | 1 |
| Offside Front Brake hose bulging under pressure |3.6.B.3| | 1 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Rear Rear fog lamp missing |1.3.2a| | 1 |
| Front Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Offside Front Steering rack gaiter split |2.2.D.2d| | 1 |
| Steering system has excessive free play detected at the steering wheel |steering rack fitted| N/S Front inner rack end |2.2.A.1b| | 1 |
| Nearside Front Headlamp aim not tested (4.1.2 (b)) | 1 |
| Nearside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Obligatory mirror seriously damaged, affecting the rear view (3.3 (b) (ii)) | 1 |
| Nearside Rear Service brake lagging in operation (1.2.1 (d)) | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds manufacturers specified limits (8.2.1.2 (a)) | 1 |