Most common failures | No# failures |
---|
Headlamp aim out of alignment | 14 |
Registration plate lamp issues | 13 |
Brake pipe excessively corroded | 10 |
Nearside Headlamp aim beam image kick up to the offside |1.8| | 9 |
Offside Headlamp aim beam image kick up to the offside |1.8| | 8 |
Windscreen wiper does not clear the windscreen effectively | 8 |
Parking brake: efficiency below requirements |3.7.B.7| | 7 |
Horn not working |1.6.2a| | 7 |
Offside Stop lamp not working |1.2.1b| | 5 |
Offside Rear fog lamp not working |1.3.2b| | 4 |
Nearside Stop lamp not working |1.2.1b| | 4 |
Rear parking brake recording little or no effort | 3 |
Offside Front position lamp|s| not working |1.1.A.3b| | 3 |
Front brake excessively fluctuating | 3 |
Offside Rear fog lamp missing |1.3.2a| | 3 |
Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
Offside Front Anti-roll bar linkage rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 3 |
Offside Track rod end ball joint has excessive play |2.2.B.1f| | 3 |
Brakes imbalanced across an axle | 3 |
Offside Outer Front Lower Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 2 |
Brake load sensing valve linkage seized |3.6.E.3| | 2 |
Service brake efficiency below requirements |1.2.2 |a| |i|| | 2 |
Rear brake binding | 2 |
Rear Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
Nearside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
Rear Exhaust system not adequately supported |7.1.1| | 2 |
Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 2 |
Front passenger door cannot be opened from outside the vehicle |6.2.B.1b| | 2 |
Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 2 |
Nearside Front position lamp|s| not working |1.1.A.3b| | 2 |
Nearside rear brake recording little or no effort |3.7.B.5a| | 2 |
Offside rear brake recording little or no effort |3.7.B.5a| | 2 |
Brake load sensing valve seized |3.6.E.3| | 2 |
Nearside Headlamp insecure |1.7.3| | 2 |
Offside Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 2 |
Service brake efficiency below requirements (1.2.2 (a) (i)) | 2 |
Bonnet cannot be secured in the closed position |3.1 |b| |i|| | 1 |
Nearside Front Headlamp aim beam image kick up to the offside |1.8| | 1 |
Offside Front Headlamp aim beam image kick up to the offside |1.8| | 1 |
Driver`s door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
Towbar component excessively corroded |6.6.1| | 1 |
Brake hose has insufficient room to move | 1 |
Front Headlamp aim beam image kick up to the offside |1.8| | 1 |
Offside Front Steering rack gaiter split |2.2.D.2d| | 1 |
Offside Obligatory mirror does not provide a view to the rear |3.3 |c|| | 1 |
Offside Outer Suspension component mounting prescribed area excessively corroded significantly reducing structural strength sill |5.3.6 |a| |i|| | 1 |
Offside Rear coil spring broken |2.4.C.1a| | 1 |
Hazard warning lamps inoperative |1.4.B.1b| | 1 |
Offside front brake binding |3.7.B.1| | 1 |
Nearside Front Upper Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Offside Front Upper Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Nearside Front Lower Front suspension ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Nearside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
Front brake application uneven | 1 |
Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
Rear fog lamp missing |1.3.2a| | 1 |
Front brake disc in such a condition that it is seriously weakened | 1 |
Offside Front Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
Offside Drive shaft which forms part of the suspension coupling gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.4.G.4e| | 1 |
Anti-lock braking system warning lamp indicates an ABS fault | 1 |
Nearside Front Upper Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Offside Front Lower Shock absorber has an excessively worn bush |2.7.4| | 1 |
Centre Rear Brake load sensing valve seized |3.6.E.3| | 1 |
Offside Front Lower Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Offside Rear fog lamp obviously incorrectly positioned |1.3.2a| | 1 |
Rear Brake load sensing valve linkage seized |3.6.E.3| | 1 |
Offside Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
Offside Front Brake hose twisted |3.6.B.4c| | 1 |
Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
Nearside Front Shock absorber has an excessively worn bush |2.7.4| | 1 |
Nearside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
Offside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
Nearside Obligatory mirror seriously damaged, affecting the rear view |3.3 |b| |ii|| | 1 |
Offside Obligatory mirror seriously damaged, affecting the rear view |3.3 |b| |ii|| | 1 |
Nearside Steering rack gaiter missing or no longer prevents the ingress of dirt |2.1.3 |g| |ii|| | 1 |
Offside Front Upper Suspension arm ball joint dust cover no longer prevents the ingress of dirt |5.3.4 |b| |ii|| | 1 |
Brake load sensing valve linkage defective and function impaired seized |1.1.17 |a|| | 1 |
Offside Front Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced leg holed in wheel arch |6.1.1 |c| |i|| | 1 |
Parking brake efficiency below requirements |1.4.2 |a| |i|| | 1 |
Horn not working |7.7 |a| |ii|| | 1 |
Nearside Front Shock absorbers likely to become detached |5.3.2 |a| |ii|| | 1 |
Exhaust has a major leak of exhaust gases forward of rear silencer |6.1.2 |a|| | 1 |
Offside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
Nearside Rear Body has a sharp edge caused by damage |6.1.C.1| | 1 |
Nearside Inner Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Nearside Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 1 |
Offside Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 1 |
Exhaust emits an excessive level of metered smoke for a non-turbo charged engine |7.4.B.3b| | 1 |
Exhaust system not adequately supported |7.1.1| | 1 |
Nearside Front Lower Ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
Offside Front Anti-roll bar linkage rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Nearside Front Anti-roll bar linkage rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Nearside Front Anti-roll bar linkage rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Hazard warning lamps not flashing in phase, with ignition off |1.4.B.1f| | 1 |
Brake pedal anti-slip provision missing |3.3.A.1b| | 1 |
Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength outer sill |5.3.6 |a| |i|| | 1 |
Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner sill |5.3.6 |a| |i|| | 1 |
Nearside Front Brake hose bulging under pressure |3.6.B.3| | 1 |
Offside Front Brake hose bulging under pressure |3.6.B.3| | 1 |
Body insecure and dangerous to other road users |6.1.B.1b| | 1 |
Headlamp switch faulty |1.7.1| | 1 |
Main beam `tell-tale` not working |1.7.4c| | 1 |
Offside Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
Offside Front Lower Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Offside Rear coil spring incomplete |2.4.C.1a| | 1 |
Offside Rear Coil spring not correctly located |2.4.C.2| | 1 |
Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
Emissions not tested |7.0| | 1 |
Offside Obligatory mirror does not provide a view to the rear |8.1.2b| | 1 |
Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
Service brake: efficiency below requirements |3.7.B.7| | 1 |
Battery insecure |1.9.1| | 1 |
Nearside front brake binding |3.7.B.1| | 1 |
Offside Seat belt damaged sufficient to obstruct correct operation of the belt |5.2.2a| | 1 |
Nearside Front Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Brake cable has wires broken and is significantly weakened |3.5.1b| | 1 |
Nearside Front Seat belt has a cut which has significantly weakened the webbing |5.2.2a| | 1 |
Registration plate issues | 1 |
Offside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
Exhaust system not adequately supported mountings broken |7.1.1| | 1 |
Offside Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 1 |
Fuel cap/sealing device does not fasten securely by positive means |7.2.4b| | 1 |
Nearside Rear Rear reflector missing |1.5.1a| | 1 |
Offside Rear Rear reflector missing |1.5.1a| | 1 |
Offside Steering rack gaiter split |2.2.D.2d| | 1 |
Exhaust silencer insecure (8.1.1 (b) (i)) | 1 |
Nearside Front Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
Nearside Front Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
Offside Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
Nearside Front Headlamp aim projected beam image is obviously incorrect Beam kick up incorrect side (4.1.2 (c)) | 1 |
Offside Front Headlamp aim projected beam image is obviously incorrect Beam kick up incorrect side (4.1.2 (c)) | 1 |
Brake load sensing valve seized and ABS not fitted or inoperative inoperative (1.1.17 (c) (ii)) | 1 |
Anti-lock braking system warning lamp does not illuminate (1.6 (a)) | 1 |
Front Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
Brake cable damaged (1.1.15 (a)) | 1 |
Drivers door cannot be opened from inside the vehicle (6.2.3 (a)) | 1 |
Drivers door cannot be opened from outside the vehicle (6.2.3 (a)) | 1 |
Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
Windscreen washer not working | 1 |
Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
Hazard warning switch inoperative (4.4.2 (a) (ii)) | 1 |
Central Rear Brake load sensing valve seized but ABS functioning (1.1.17 (c) (i)) | 1 |
Offside Front Body component corroded and likely to cause injury wheel arch (6.2.1 (a) (i)) | 1 |
Exhaust emissions test not completed because smoke levels are significantly in excess of the specified limit values reading 4.81 (8.2.2.2 (f)) | 1 |
Service brake efficiency less than 50% of the required value (1.2.2 (a) (ii)) | 1 |
Offside Outer Seat belt anchorage prescribed area strength or continuity significantly reduced sill (7.1.1 (a) (i)) | 1 |
Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength outer sill / arch (5.3.6 (a) (i)) | 1 |
Horn not working (7.7 (a) (ii)) | 1 |
Main beam tell-tale not working not working on main beam (4.9.1 (a) (ii)) | 1 |
Headlamp aim projected beam image is obviously incorrect dip wrong way (4.1.2 (c)) | 1 |
Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
Rear fog lamp tell-tale not working (4.9.1 (a) (ii)) | 1 |
Offside Front Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced inner and outer sill (6.1.1 (c) (i)) | 1 |
Nearside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
Offside Front Service brake excessively binding (1.2.1 (f)) | 1 |
Nearside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength chassis (5.3.6 (a) (i)) | 1 |