| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 7 |
| Parking brake: efficiency below requirements |3.7.B.7| | 6 |
| Windscreen wiper does not clear the windscreen effectively | 5 |
| Rear parking brake recording little or no effort | 4 |
| Brakes imbalanced across an axle | 3 |
| Brake load sensing valve linkage seized |3.6.E.3| | 3 |
| Rear brake binding | 2 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 2 |
| Offside Side repeater not working |1.4.A.2c| | 2 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 2 |
| Drivers seat insecure (6.2.5 (a) (ii)) | 2 |
| Passengers seat insecure (6.2.6 (a) (ii)) | 2 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 2 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 2 |
| Brake pipe excessively corroded | 2 |
| Nearside Front Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Offside Front Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Rear fog lamp tell tale not working |1.3.1b| | 1 |
| Nearside Side repeater not working |1.4.A.2c| | 1 |
| Offside Rear Upper Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Battery insecure |1.9.1| | 1 |
| Nearside Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
| Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Brake load sensing valve seized |3.6.E.3| | 1 |
| Nearside Rear Brake pipe kinked |3.6.B.2b| | 1 |
| Brake cable has wires broken and is significantly weakened |3.5.1b| | 1 |
| Exhaust emits an excessive level of metered smoke for a turbo charged engine |7.4.B.3b| | 1 |
| Nearside Front Side repeater not working |1.4.A.2c| | 1 |
| Rear Rear fog lamp not working |1.3.2b| | 1 |
| Horn not working |1.6.2a| | 1 |
| Emissions not tested |7.3.A.1| | 1 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Parking brake lever defective so that it cannot be satisfactorily operated |3.1.3c| | 1 |
| Registration plate lamp issues | 1 |
| Nearside Stop lamp not working |1.2.1b| | 1 |
| Offside Front Direction indicator not working |1.4.A.2c| | 1 |
| Nearside Body or chassis has an unsatisfactory modification, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Nearside Front Direction indicators not working |1.4.A.2c| | 1 |
| Emissions not tested |7.0| | 1 |
| Parking brake lever ratchet mechanism is broken |3.1.5| | 1 |
| Parking brake mechanism/associated mounting prescribed area is excessively corroded |3.1.9| | 1 |
| Front position lamp|s| not working |1.1.A.3b| | 1 |
| Hazard warning tell tale not working correctly |1.4.B.1e| | 1 |
| Direction indicator excessively deteriorated so that it is not visible from a reasonable distance |1.4.A.2e| | 1 |
| Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Axle king pin has excessive play in pin and/or bush adversely affecting the steering |2.5.A.3a| | 1 |
| Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 1 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Nearside Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 1 |
| Offside Rear Direction indicator adversely affected by the operation of another lamp |1.4.A.2h| | 1 |
| Nearside Rear Stop lamp not working |1.2.1b| | 1 |
| Nearside Rear Direction indicator not working |1.4.A.2c| | 1 |
| Rear Exhaust system not adequately supported |7.1.1| | 1 |
| Windscreen washer not working | 1 |
| Horn not working (7.7 (a) (ii)) | 1 |
| Offside Body component likely to become detached body trim and panel (6.2.1 (a) (ii)) | 1 |
| Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Offside Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Registration plate issues | 1 |
| Battery insecure and likely to cause a short circuit (4.13 (a) (ii)) | 1 |
| Nearside Headlamp aim projected beam image is obviously incorrect |4.1.2 |c|| | 1 |
| Offside Front Direction indicator not working (4.4.1 (a) (ii)) | 1 |
| Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Nearside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength floor (5.3.6 (a) (i)) | 1 |
| Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength floor (5.3.6 (a) (i)) | 1 |
| Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength rear floor (5.3.6 (a) (i)) | 1 |
| Exhaust fumes causing a danger to health of persons on board tail pipe missing (6.1.2 (b) (ii)) | 1 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 1 |
| Offside Headlamp aim projected beam image is obviously incorrect |4.1.2 |c|| | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength Inner arch x2 inner sill x1 (5.3.6 (a) (i)) | 1 |
| Offside Front Outer Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Service brake efficiency less than 50% of the required value (1.2.2 (a) (ii)) | 1 |
| Exhaust fumes entering cabin (6.1.2 (b) (i)) | 1 |
| Windscreen wiper not working (3.4 (a)) | 1 |
| Nearside Front Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
| Sound deadening material insecure (8.1.1 (b) (i)) | 1 |
| Nearside Front Body modification likely to adversely affect braking or steering (6.2.1 (d) (ii)) | 1 |
| Offside Front Body modification likely to adversely affect braking or steering (6.2.1 (d) (ii)) | 1 |
| Rear fog lamp switch inoperative (4.5.3 (a)) | 1 |
| Offside Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Nearside Front Obligatory mirror insecure (3.3 (b) (ii)) | 1 |
| Offside Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Offside Rear Coil spring fractured or broken (5.3.1 (b) (i)) | 1 |
| Nearside Rear Coil spring fractured or broken (5.3.1 (b) (i)) | 1 |