Most common failures | No# failures |
---|
Brake pipe excessively corroded | 17 |
Headlamp aim out of alignment | 11 |
Windscreen wiper does not clear the windscreen effectively | 8 |
Brake hose excessively deteriorated | 6 |
Offside Rear fog lamp not working |1.3.2b| | 4 |
Registration plate issues | 4 |
Nearside Front position lamp|s| not working |1.1.A.3b| | 4 |
Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 3 |
Rear fog lamp not working |1.3.2b| | 3 |
Offside Headlamp not working on dipped beam |1.7.5a| | 3 |
Rear parking brake recording little or no effort | 3 |
Registration plate lamp issues | 3 |
Rear brake binding | 3 |
Parking brake: efficiency below requirements |3.7.B.7| | 3 |
Windscreen washer not working | 3 |
Offside Obligatory mirror missing |8.1.1| | 2 |
Nearside Front Brake hose bulging under pressure |3.6.B.3| | 2 |
Offside Rear Rear wheel bearing rough when rotated |2.6.1| | 2 |
Rear Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
Rear Brake cable insecure | 2 |
Offside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
Offside Steering rack gaiter split |2.2.D.2d| | 2 |
Main beam `tell-tale` not working |1.7.4c| | 2 |
An item not tested |Manual| | 2 |
Brake performance not tested |3.7.A.1| | 2 |
Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
Offside Front brake disc excessively pitted |3.5.1h| | 2 |
Brake load sensing valve linkage seized |3.6.E.3| | 2 |
Offside Headlamp light intensity severely reduced |4.1.4 |a|| | 1 |
Nearside Headlamp not working on main beam |4.1.1 |a| |ii|| | 1 |
Nearside Front Suspension arm pin or bush excessively worn tie rod bushes |5.3.4 |a| |i|| | 1 |
Offside Front Suspension arm pin or bush excessively worn tie rod bushes |5.3.4 |a| |i|| | 1 |
Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
Fuel pipe leaking tank area |7.2.3| | 1 |
Nearside Headlamp insecure |1.7.3| | 1 |
Fuel hose leaking |7.2.3| | 1 |
Nearside Front Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
Nearside Headlamp not working on dipped beam |1.7.5a| | 1 |
Offside Stop lamp not working |1.2.1b| | 1 |
Rear Power steering pipe|s| or hose|s| leaking |2.3.3b| | 1 |
Nearside Stop lamp not working |1.2.1b| | 1 |
Offside Front Brake hose bulging under pressure |3.6.B.3| | 1 |
Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
Rear fog lamp switch missing |1.3.1a| | 1 |
Offside Headlamp aim beam image kick up to the offside |1.6.B1| | 1 |
Nearside Headlamp aim beam image kick up to the offside |1.6.B1| | 1 |
Nearside Front Upper Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
Parking brake lever has no reserve travel |3.1.6b| | 1 |
Nearside Rear position lamp|s| excessively damaged so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
Nearside Front Service brake excessively fluctuating |1.2.1 |e|| | 1 |
Offside Front Brake hose bulging under pressure wheel end |3.6.B.3| | 1 |
Centre Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
Nearside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Nearside Rear Direction indicator not working |1.4.A.2c| | 1 |
Offside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
Offside Front Headlamp insecure |1.7.3| | 1 |
Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Rear Direction indicator adversely affected by the operation of another lamp |1.4.A.2h| | 1 |
Service brake: efficiency below requirements |3.7.C.1a| | 1 |
Parking brake: efficiency below requirements |3.7.C.1b| | 1 |
Nearside Headlamp aim beam image kick up to the offside |1.8| | 1 |
Offside Headlamp aim beam image kick up to the offside |1.8| | 1 |
Rear Body has a sharp edge caused by corrosion tailgate |6.1.C.1| | 1 |
Offside Rear Suspension component mounting prescribed area is excessively corroded outer sill |2.4.A.3| | 1 |
Offside Front Suspension component mounting prescribed area is excessively corroded wheel arch |2.4.A.3| | 1 |
Nearside Front Lower Suspension component mounting prescribed area is excessively corroded wheel arc to floor |2.4.A.3| | 1 |
Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings inner wheel arch |6.1.B.2| | 1 |
Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings inner wheel arch |6.1.B.2| | 1 |
Nearside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings out rigger to inner sill |6.1.B.2| | 1 |
Nearside Rear Lower Shock absorber has an excessively worn bush bush |2.7.4| | 1 |
Offside Rear Lower Shock absorber has an excessively worn bush bush |2.7.4| | 1 |
Nearside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings back panel to chassis rail |6.1.B.2| | 1 |
Offside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings back panel to chassis rail |6.1.B.2| | 1 |
Nearside Rear Body has a sharp edge caused by corrosion wheel arch |6.1.C.1| | 1 |
Offside Rear Body has a sharp edge caused by corrosion wheel arch |6.1.C.1| | 1 |
Nearside Front Steering arm has relative movement at its fixings inner rack arm |2.2.B.1h| | 1 |
Fuel cap/sealing device mounting flange/sealing method defective |7.2.4c| | 1 |
Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Offside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Nearside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Nearside Steering rack gaiter split |2.2.D.2d| | 1 |
Offside Upper Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
Nearside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
Parking brake lever, pawl mechanism pivot|s| locking device missing |3.1.4b| | 1 |
Front brake disc excessively pitted |3.5.1h| | 1 |
Fuel cap/sealing device does not fasten securely by positive means |7.2.4b| | 1 |
Offside Front Driver`s door does not latch securely closed |6.2.B.1a| | 1 |
Nearside Front Driver`s door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
Nearside Front Driver`s door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
Nearside Front Headlamp aim beam image kick up to the offside |1.8| | 1 |
Offside Front Headlamp aim beam image kick up to the offside |1.8| | 1 |
Nearside Rear Rear position lamp|s| excessively damaged so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
Nearside Rear Stop lamp not working |1.2.1b| | 1 |
Nearside Rear Direction indicators not working |1.4.A.2c| | 1 |
Nearside Rear Hazard warning lamps not flashing in phase, with ignition on |1.4.B.1f| | 1 |
Offside Rear Hazard warning lamps not flashing in phase, with ignition on |1.4.B.1f| | 1 |
Parking brake lever ratchet mechanism is broken |3.1.5| | 1 |
Offside front brake juddering severely |3.7.A.2b| | 1 |
Brake rod has restricted free movement |3.5.1k| | 1 |
Nearside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
Offside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
Nearside Rear fog lamp not working |1.3.2b| | 1 |
Front brake application uneven | 1 |
Exhaust system not adequately supported |7.1.1| | 1 |
Nearside Front Outer Cab or chassis has excessive corrosion, seriously affecting its strength within 30cm of a cab mounting inner foot step sill areas |6.2.2 |d| |i|| | 1 |
Offside Front Outer Cab or chassis has excessive corrosion, seriously affecting its strength within 30cm of a cab mounting foot step areas |6.2.2 |d| |i|| | 1 |
Nearside Front Axle king pin has excessive play in pin and/or bush adversely affecting the steering |2.5.A.3a| | 1 |
Rear Brake load sensing valve linkage seized |3.6.E.3| | 1 |
Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Offside Side repeater not working |1.4.A.2c| | 1 |
Horn not working |1.6.2a| | 1 |
Direction indicators not working |1.4.A.2c| | 1 |
Nearside Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
Offside Obligatory mirror insecure |8.1.1| | 1 |
Driver`s seat fore and aft adjustment mechanism not functioning as intended. |6.2.A.3| | 1 |
Driver`s seat insecure |6.2.A.1| | 1 |
Nearside Front Passenger`s seat insecure |6.2.A.1| | 1 |
Fuel system component leaking |7.2.3| | 1 |
Headlamp not working on dipped beam drivers |1.7.5a| | 1 |
Parking brake efficiency below requirements (1.4.2 (a) (i)) | 1 |
Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
Nearside Front Service brake excessively fluctuating (1.2.1 (e)) | 1 |
Offside Front Service brake excessively fluctuating (1.2.1 (e)) | 1 |
Brake pedal anti-slip provision missing (1.1.2 (c)) | 1 |
Brake lever has insufficient reserve travel (1.1.2 (a)) | 1 |
Nearside Front Headlamp insecure (4.1.1 (c)) | 1 |
Offside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
Offside Front Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
Oil leaking excessively from engine engine (8.4.1 (a) (i)) | 1 |
Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
Offside Rear Anti-roll bar attachment bracket/mounting corroded and seriously weakened (5.3.3 (b) (i)) | 1 |
Nearside Front Lower Axle king pin is loose in the axle beam (5.1.2 (d) (i)) | 1 |
Offside Front Lower Axle king pin is loose in the axle beam (5.1.2 (d) (i)) | 1 |
Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
Nearside Front Headlamp light source and lamp not compatible (4.1.4 (c)) | 1 |
Offside Front Headlamp light source and lamp not compatible (4.1.4 (c)) | 1 |
Nearside Front passenger door cannot be opened from outside the vehicle (6.2.3 (a)) | 1 |
Parking brake lever defective so that it cannot be satisfactorily operated linkage broken (1.1.6 (d)) | 1 |
Nearside Front Service brake excessively binding (1.2.1 (f)) | 1 |
Offside Front Service brake excessively binding (1.2.1 (f)) | 1 |
Nearside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
Offside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 1 |