| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 11 |
| Windscreen wiper does not clear the windscreen effectively | 10 |
| Registration plate lamp issues | 7 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 7 |
| Parking brake: efficiency below requirements |3.7.B.7| | 3 |
| Exhaust emits an excessive level of metered smoke |7.4.B.3a| | 3 |
| Brake pipe excessively corroded | 3 |
| Windscreen has damage | 3 |
| Stop lamp(s) all not working (4.3.1 (a) (iii)) | 2 |
| Engine MIL inoperative or indicates a malfunction |8.2.2.2 |g|| | 2 |
| Windscreen washer not working | 2 |
| Nearside Rear coil spring broken |2.4.C.1a| | 2 |
| Offside Front Service brake excessively binding (1.2.1 (f)) | 2 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Rear Lower Anti-roll bar linkage rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Nearside Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 1 |
| Nearside Front Lower Suspension component ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Rear parking brake recording little or no effort | 1 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Front Lower Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Rear fog lamp not working |1.3.2b| | 1 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Rear coil spring broken |2.4.C.1a| | 1 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Stop lamp not working |1.2.1b| | 1 |
| Anti-lock braking system warning lamp indicates an ABS fault | 1 |
| Offside Front Drive shaft bearing housing insecure |6.1.7 |f| |i|| | 1 |
| Exhaust emits an excessive level of metered smoke (7.4.B.3a) | 1 |
| Nearside Rear reflector missing (1.5.1a) | 1 |
| Offside Side repeater not working (1.4.A.2c) | 1 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Front Lower Suspension arm ball joint excessively worn both sides (5.3.4 (a) (i)) | 1 |
| Nearside Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Exhaust emissions exceed manufacturers specified limit (8.2.2.2 (a)) | 1 |
| Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 1 |
| Nearside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Front brake disc in such a condition that it is seriously weakened | 1 |
| Front Anti-roll bar linkage rubber bush deteriorated resulting in excessive movement (2.4.G.2) | 1 |
| Nearside Track rod end ball joint has excessive play (2.2.B.1f) | 1 |
| Offside Track rod end ball joint has excessive play (2.2.B.1f) | 1 |
| Parking brake: efficiency below requirements (3.7.B.7) | 1 |
| Offside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Nearside Rear Coil spring fractured or broken (5.3.1 (b) (i)) | 1 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 1 |
| Offside Front Brake hose excessively twisted (1.1.12 (b) (ii)) | 1 |
| Service brake efficiency less than 50% of the required value (1.2.2 (a) (ii)) | 1 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 1 |
| Brakes imbalanced across an axle | 1 |
| Nearside Front Suspension component ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Front Lower Suspension component ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Front Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Nearside Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Offside Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Bonnet retaining device excessively deteriorated |8.4.2| | 1 |
| Offside Rear Seat belt anchorage loose (7.1.1 (b)) | 1 |
| Offside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Nearside Front Upper Outline marker lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Rear Outline marker lamp light intensity significantly reduced (4.2.3 (a) (ii)) | 1 |
| Nearside Front Suspension arm pin or bush excessively worn Excessive movement (5.3.4 (a) (i)) | 1 |
| Offside Front Suspension arm pin or bush excessively worn Excessive movement (5.3.4 (a) (i)) | 1 |
| Nearside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Offside Front Side repeater not working (4.4.1 (a) (ii)) | 1 |
| Offside Front Lower Suspension component ball joint dust cover no longer prevents the ingress of dirt split (5.3.4 (b) (ii)) | 1 |
| Offside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Offside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 1 |