| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 28 |
| Registration plate lamp issues | 19 |
| Windscreen wiper does not clear the windscreen effectively | 14 |
| Parking brake: efficiency below requirements (3.7.B.7) | 12 |
| Brake pipe excessively corroded | 10 |
| Rear parking brake recording little or no effort | 8 |
| Parking brake: efficiency below requirements |3.7.B.7| | 7 |
| Front brake disc in such a condition that it is seriously weakened | 6 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 6 |
| Exhaust emissions exceed manufacturers specified limit (8.2.2.2 (a)) | 5 |
| Parking brake lever has no reserve travel |3.1.6b| | 4 |
| Brakes imbalanced across an axle | 4 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 3 |
| Front brake application uneven | 3 |
| Nearside Headlamp not working on main beam |1.7.5a| | 2 |
| Centre Stop lamp not working |1.2.1b| | 2 |
| Rear brake disc in such a condition that it is seriously weakened | 2 |
| Exhaust emissions exceed level of metered smoke for a turbo charged engine (8.2.2.2 (b)) | 2 |
| Offside Headlamp not working on main beam (4.1.1 (a) (ii)) | 2 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 2 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 2 |
| Registration plate issues | 2 |
| Offside Parking brake inoperative on one side (1.4.1 (a)) | 2 |
| Nearside Front Direction indicator incorrect colour (4.4.3 (a)) | 2 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 2 |
| Offside Rear fog lamp not working (4.5.1 (a) (ii)) | 2 |
| Offside Rear Coil spring fractured or broken (5.3.1 (b) (i)) | 2 |
| Offside Front position lamp(s) not working (1.1.A.3b) | 2 |
| Transmission brake efficiency below requirements (3.8.A.9/10) | 2 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 2 |
| Offside Front Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 2 |
| Nearside Parking brake inoperative on one side (1.4.1 (a)) | 2 |
| Horn not working (7.7 (a)) | 2 |
| Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 2 |
| Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 2 |
| Headlamp levelling device inoperative (4.1.5 (a)) | 2 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Nearside Front Anti-roll bar attachment bracket/mounting insecure bracket missing |2.4.G.1| | 1 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Nearside Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Offside Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Nearside Front Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Rear Stop lamp not working |1.2.1b| | 1 |
| Nearside Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
| Offside Headlamp not working on main beam |4.1.1 |a| |ii|| | 1 |
| Nearside Rear Outline marker lamp not working |4.2.1 |a|| | 1 |
| Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Offside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Rear fog lamp not working |1.3.2b| | 1 |
| Emissions not tested Oil below min |7.3.A.1| | 1 |
| Offside Stop lamp not working |1.2.1b| | 1 |
| Nearside Front Position lamp not working |4.2.1 |a| |ii|| | 1 |
| Offside Front Direction indicator incorrect colour |4.4.3 |a|| | 1 |
| Offside Lower Body panel corroded and likely to cause injury edge of drivers door |6.2.1 |a| |i|| | 1 |
| Nearside Front Lower Suspension arm ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Offside Front Lower Suspension arm ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Nearside Rear Body component insecure lower sill holed and corroded |6.2.1 |a| |i|| | 1 |
| Brake pedal has insufficient reserve travel spongey |1.1.2 |a|| | 1 |
| Brake load sensing valve seized but ABS functioning |1.1.17 |c| |i|| | 1 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Anti-roll bar has excessive play in a pin/bush All front roll bar bushes |2.4.G.2| | 1 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Front Headlamp not working on main beam |1.7.5a| | 1 |
| Offside Rear Stop lamp not working |1.2.1b| | 1 |
| Windscreen has damage | 1 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Power steering inoperative |2.3.3a| | 1 |
| Nearside Stop lamp not working |1.2.1b| | 1 |
| Windscreen wiper blade insecure | 1 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Anti-lock braking system warning lamp indicates an ABS fault | 1 |
| Nearside rear brake excessively fluctuating |3.7.B.3| | 1 |
| Offside Front Anti-roll bar linkage ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Headlamp aim beam image obviously incorrect bulb in wrong |1.8.A.1b| | 1 |
| Nearside Side repeater incorrect colour |1.4.A.2f| | 1 |
| Offside Front Inner Steering system has excessive free play detected at the steering wheel |steering rack fitted| rack end joint |2.2.A.1b| | 1 |
| Nearside Front Brake hose twisted |found during steering lock to lock check| |2.2.D.2b| | 1 |
| Nearside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Front Side repeater excessively damaged so that it is not visible from a reasonable distance |1.4.A.2e| | 1 |
| Nearside Front Body has a sharp edge caused by damage |6.1.C.1| | 1 |
| Offside Rear Rear reflector excessively damaged so that its function is impaired |1.5.1c| | 1 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Front brake disc excessively pitted |3.5.1h| | 1 |
| Offside Front brake disc excessively pitted |3.5.1h| | 1 |
| Nearside Rear Bumper damaged and likely to cause injury when grazed or contacted (6.1.4 (a) (i)) | 1 |
| Offside Rear Bumper damaged and likely to cause injury when grazed or contacted (6.1.4 (a) (i)) | 1 |
| Exhaust system insecure (6.1.2 (a)) | 1 |
| Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Exhaust emissions test not completed because smoke levels are significantly in excess of the specified limit values (8.2.2.2 (f)) | 1 |
| Nearside Rear passenger door cannot be opened from outside the vehicle (6.2.B.1c) | 1 |
| Offside Seat belt damaged sufficient to obstruct correct operation of the belt (5.2.2a) | 1 |
| Offside Rear wheel bearing rough when rotated (2.6.1) | 1 |
| Offside Front Shock absorbers has a serious fluid leak | 1 |
| Headlamp levelling device inoperative both (4.1.5 (a)) | 1 |
| Offside Stop lamp not working (1.2.1b) | 1 |
| Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Offside Rear Position lamp light intensity significantly reduced (4.2.3 (a) (ii)) | 1 |
| Nearside Rear Suspension component attachment bracket/mounting damaged and seriously weakened Lower bracket (5.3.3 (b) (i)) | 1 |
| Exhaust emits excessive smoke or vapour likely to obscure the vision of other road users (8.2.2.2 (c)) | 1 |
| Nearside Rear Rear reflector missing (4.8.2 (a) (ii)) | 1 |
| Nearside Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Nearside Front Upper Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Steering rack has excessive free play detected at the steering wheel (steering rack fitted) (2.3 (a) (i)) | 1 |
| Nearside Rear Body panel corroded and likely to cause injury (6.2.1 (a) (i)) | 1 |
| Nearside Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Offside Rear Rear reflector missing (4.8.2 (a) (ii)) | 1 |
| Nearside Front Inner Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt inner boot split (6.1.7 (g) (ii)) | 1 |
| Offside Rear position lamp(s) not working (1.1.A.3b) | 1 |
| Nearside Front Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt (2.4.G.2) | 1 |
| Offside Front Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt (2.4.G.2) | 1 |
| Parking brake lever has excessive movement indicating incorrect adjustment no reserve travel (1.1.6 (c)) | 1 |
| Nearside Emergency exit sign missing side doors (9.1.2 (b) (ii)) | 1 |
| Emergency exit sign missing n/s and o/s windows (signs missing) (9.1.2 (b) (ii)) | 1 |
| Nearside Rear Electrical wiring likely to drag on the ground at corner (4.11 (a) (iii)) | 1 |
| Rear Exhaust system insecure tail pipe insecure and corroded (6.1.2 (a)) | 1 |
| Nearside Brake hose twisted (found during steering lock to lock check) (2.2.D.2b) | 1 |
| Driving control(s) clutch pedal anti-slip provision loose (6.8.3) | 1 |
| Speed limiter plate missing (6.5.A.1a) | 1 |
| Parking brake lever has no reserve travel (3.1.6b) | 1 |
| Nearside Front Lower Suspension arm has excessive play in a ball joint (2.4.G.2) | 1 |
| Stop lamp not working (1.3.2a) | 1 |
| Offside Front Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Brake load sensing valve seized and ABS not fitted or inoperative (1.1.17 (c) (ii)) | 1 |
| Headlamp not working on dipped beam both (4.1.1 (a) (ii)) | 1 |
| Headlamp not working on main beam both (4.1.1 (a) (ii)) | 1 |
| Nearside Front Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Front Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt (2.4.G.2) | 1 |
| Nearside Rear Stop lamp not working (1.2.1b) | 1 |
| Offside Rear coil spring broken (2.4.C.1a) | 1 |
| Rear fog lamp missing (4.5.1 (a) (ii)) | 1 |
| Rear fog lamp switch missing (4.5.3 (a)) | 1 |
| Rear fog lamp tell-tale missing (4.9.1 (a) (ii)) | 1 |
| Nearside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Nearside Rear Coil spring fractured or broken (5.3.1 (b) (i)) | 1 |
| Front Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Brake load sensing valve seized but ABS functioning (1.1.17 (c) (i)) | 1 |
| Offside Track rod end ball joint has excessive play (2.2.B.1f) | 1 |
| Nearside Front Outer Anti-roll bar has excessive play in a pin/bush (2.4.G.2) | 1 |
| Nearside Front Inner Anti-roll bar has excessive play in a pin/bush (2.4.G.2) | 1 |
| Offside Front Inner Anti-roll bar has excessive play in a pin/bush (2.4.G.2) | 1 |
| Steering system excessively tight (2.2.D.1) | 1 |
| Centre Stop lamp not working (1.2.1b) | 1 |
| Offside Rear Stop lamp not working (1.2.1b) | 1 |
| Nearside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Front Direction indicator not working (4.4.1 (a) (ii)) | 1 |
| Fuel system component leaking fuel filter (6.1.3 (b) (i)) | 1 |
| Nearside Rear Leaf spring shackle bracket corroded and seriously weakened (5.3.1 (b) (i)) | 1 |
| Nearside Rear Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced SILL (6.1.1 (c) (i)) | 1 |
| Headlamp aim projected beam image is obviously incorrect both aims kick off to the offside (4.1.2 (c)) | 1 |
| Nearside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Front Suspension arm ball joint dust cover no longer prevents the ingress of dirt o/s and n/s (5.3.4 (b) (ii)) | 1 |
| Offside Rear Brake lever has restricted free movement (1.1.15 (e)) | 1 |
| Offside Rear Seat belt not functioning as intended (7.1.2 (c)) | 1 |
| Nearside Rear Seat belt not functioning as intended (7.1.2 (c)) | 1 |
| Nearside Front Service brake excessively binding (1.2.1 (f)) | 1 |
| Offside Front Service brake excessively binding (1.2.1 (f)) | 1 |
| Nearside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Offside Front Coil spring fractured or broken (5.3.1 (b) (i)) | 1 |
| Offside Rear Brake pipe leaking on a hydraulic braking system main (1.1.11 (b) (ii)) | 1 |
| Nearside Front Wheel nut(s) missing (4.2.A.1e) | 1 |
| Battery insecure (1.9.1) | 1 |
| Nearside Rear coil spring broken (2.4.C.1a) | 1 |
| Offside Obligatory mirror seriously damaged, affecting the rear view (8.1.2a) | 1 |
| Windscreen has a sticker or other obstruction encroaching by more than 10mm within zone A (8.3.1b) | 1 |
| Offside Headlamp insecure (4.1.1 (c)) | 1 |
| Windscreen washer not working | 1 |
| Offside Front Anti-roll bar linkage ball joint likely to become detached (5.3.4 (a) (ii)) | 1 |
| Headlamp aim projected beam image is obviously incorrect o/s and n/s (4.1.2 (c)) | 1 |
| Nearside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Oil leaking excessively from engine (8.4.1 (a) (i)) | 1 |
| Emissions unable to be completed (8.2.2.2 (e)) | 1 |
| Nearside Front Seat belt buckle damaged (7.1.2 (d)) | 1 |
| Offside Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Brake servo defective or ineffective (1.1.10 (a) (i)) | 1 |
| Nearside Headlamp light intensity severely reduced (4.1.4 (a)) | 1 |