| Most common failures | No# failures |
|---|
| Windscreen wiper does not clear the windscreen effectively | 27 |
| Headlamp aim out of alignment | 24 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 16 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 9 |
| Registration plate issues | 9 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 8 |
| Registration plate lamp issues | 6 |
| Rear fog lamp not working |1.3.2b| | 5 |
| Brake pedal spongy |3.3.B.1b| | 4 |
| Offside Rear fog lamp not working |1.3.2b| | 4 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 4 |
| Steering system has excessive free play detected at the steering wheel |steering box fitted| |2.2.A.1a| | 3 |
| Hazard warning lamps not flashing in phase, with ignition on |1.4.B.1f| | 3 |
| Hazard warning lamps not flashing in phase, with ignition off |1.4.B.1f| | 3 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 3 |
| Hazard warning switch faulty |1.4.B.1d| | 3 |
| Exhaust emissions hydrocarbon content after 2nd fast idle excessive |7.3.D.3| | 3 |
| Steering box insecure |2.2.B.1a| | 3 |
| Offside Front Seat belt anchorage prescribed area strength or continuity significantly reduced (7.1.1 (a) (i)) | 3 |
| Nearside Stop lamp not working |1.2.1b| | 2 |
| Parking brake lever ratchet mechanism is broken |3.1.5| | 2 |
| Offside Rear fog lamp insecure |1.3.2a| | 2 |
| Brake pedal has insufficient reserve movement |3.3.A.5| | 2 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Emissions not tested |7.0| | 2 |
| Nearside Side repeater not working |1.4.A.2c| | 2 |
| Offside Rear Stop lamp|s| not working |4.3.1 |a| |ii|| | 2 |
| Rear brake binding | 2 |
| Offside Rear Body has a sharp edge caused by corrosion |6.1.C.1| | 2 |
| Nearside Rear Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Rear brake application uneven | 2 |
| Brake pipe excessively corroded | 2 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds default limits |8.2.1.2 |b|| | 2 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits |8.2.1.2 |c|| | 2 |
| Nearside Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 2 |
| All direction indicators not working (4.4.1 (a) (ii)) | 2 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 2 |
| Windscreen washer not working | 2 |
| Service brake efficiency below requirements |1.2.2 |a| |i|| | 1 |
| Parking brake efficiency less than 50% of the required value |1.4.2 |a| |ii|| | 1 |
| Speedometer cannot be illuminated. |6.7.3| | 1 |
| Brake hose has insufficient room to move | 1 |
| Nearside Rear Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Front Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
| Parking brake lever defective so that it cannot be satisfactorily operated |3.1.3c| | 1 |
| Seat belt buckle not functioning as intended rears inaccessable |7.1.2 |d|| | 1 |
| Brake pedal has insufficient reserve travel |1.1.2 |a|| | 1 |
| Rear fog lamp not working |4.5.1 |a| |ii|| | 1 |
| Front Brake linkage has restricted free movement |3.5.1k| | 1 |
| Nearside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Offside Front Axle king pin has excessive play in pin and/or bush adversely affecting the steering |2.5.A.3a| | 1 |
| Hazard warning switch inoperative |4.4.2 |a| |ii|| | 1 |
| Offside Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
| Nearside Hazard warning switch inoperative All 3 indicators not operating with hazard switch |4.4.2 |a| |ii|| | 1 |
| Hazard warning lamps inoperative |1.4.B.1b| | 1 |
| Offside Stop lamp not working |1.2.1b| | 1 |
| Rear fog lamp tell tale not working |1.3.1b| | 1 |
| Nearside Front Anti-roll bar linkage insecure |2.4.G.1| | 1 |
| Offside Front Anti-roll bar linkage insecure |2.4.G.1| | 1 |
| Power steering component|s| leaking |2.3.3b| | 1 |
| Nearside Rear Drive shaft which forms part of the suspension coupling gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.4.G.4e| | 1 |
| Steering box has a significant oil leak |2.2.D.2e| | 1 |
| Offside Rear fog lamp not working |4.5.1 |a| |ii|| | 1 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Rear fog lamp missing |1.3.2a| | 1 |
| Nearside Rear Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside Front Hazard warning lamps not fitted |1.4.B.1a| | 1 |
| Offside Rear Hazard warning lamps not fitted |1.4.B.1a| | 1 |
| Nearside Hazard warning lamps inoperative |1.4.B.1b| | 1 |
| Rear Rear fog lamp not working |1.3.2b| | 1 |
| Nearside Rear Hazard warning lamps inoperative |1.4.B.1b| | 1 |
| Nearside Front Hazard warning lamps inoperative |1.4.B.1b| | 1 |
| Offside Side repeater not working |4.4.1 |a| |ii|| | 1 |
| Offside Front Seat belt anchorage prescribed area strength or continuity significantly reduced |7.1.1 |a| |i|| | 1 |
| Nearside Rear Seat belt anchorage prescribed area strength or continuity significantly reduced |7.1.1 |a| |i|| | 1 |
| Offside Rear Seat belt anchorage prescribed area strength or continuity significantly reduced |7.1.1 |a| |i|| | 1 |
| Offside Front Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced outrigger/floor |6.1.1 |c| |i|| | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner wheel arch /outer sill |5.3.6 |a| |i|| | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner wheel arch /outer sill |5.3.6 |a| |i|| | 1 |
| Nearside Front Suspension has inadequate clearance with the bump stop |2.4.A.1a| | 1 |
| Offside Front Suspension has inadequate clearance with the bump stop |2.4.A.1a| | 1 |
| Exhaust system not adequately supported |7.1.1| | 1 |
| Offside Rear fog lamp missing |1.3.2a| | 1 |
| Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Nearside Rear Battery insecure and likely to cause a short circuit |4.13 |a| |ii|| | 1 |
| Nearside Front Side repeater missing |1.4.A.2b| | 1 |
| Offside Front Side repeater missing |1.4.A.2b| | 1 |
| Battery insecure |1.9.1| | 1 |
| Nearside Rear Battery insecure |1.9.1| | 1 |
| An item not tested |Manual| | 1 |
| Nearside Front Hazard warning switch faulty |1.4.B.1d| | 1 |
| Nearside Rear Hazard warning switch faulty |1.4.B.1d| | 1 |
| Windscreen wiper blade insecure | 1 |
| Nearside Rear Brake pipe excessively damaged |3.6.B.2c| | 1 |
| Offside Rear Brake pipe excessively damaged |3.6.B.2c| | 1 |
| Parking brake: efficiency below requirements |3.7.B.7| | 1 |
| Exhaust carbon monoxide content at idle exceeds default limits |8.2.1.2 |b|| | 1 |
| Offside Rear Rear fog lamp not working |4.5.1 |a| |ii|| | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds manufacturer`s specified limits |8.2.1.2 |a|| | 1 |
| Nearside Front Seat belt insecurely fixed to the vehicles structure |5.2.1a| | 1 |
| Nearside Front Lower Torque/reaction arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Exhaust emissions hydrocarbon content excessive |7.3.B.1b| | 1 |
| Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 1 |
| Rear fog lamp insecure |1.3.2a| | 1 |
| rear brakes release unevenly |3.7.B.4| | 1 |
| Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
| Drag link end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt |2.1.3 |g| |ii|| | 1 |
| Hazard warning lamps inoperative ALL (4.4.1 (e)) | 1 |
| Stop lamp(s) all not working (4.3.1 (a) (iii)) | 1 |
| Electrical wiring insulation so damaged or deteriorated it is likely to cause a short-circuit (4.11 (c) (ii)) | 1 |
| Rear fog lamp switch inoperative (4.5.3 (a) (ii)) | 1 |
| Nearside Front Axle king pin is loose in the axle beam (5.1.2 (d) (i)) | 1 |
| Offside Front Axle king pin is loose in the axle beam (5.1.2 (d) (i)) | 1 |
| Central Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Exhaust hydrocarbon content after 2nd fast idle exceeds default limits (8.2.1.2 (b)) | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds default limits (8.2.1.2 (b)) | 1 |
| Offside Rear Position lamp adversely affected by the operation of another lamp (4.2.3 (c)) | 1 |
| Nearside Rear Exhaust has a major leak of exhaust gases exhaust box (6.1.2 (a)) | 1 |
| Nearside Rear Direction indicator incorrect colour (4.4.3 (a)) | 1 |
| Offside Rear Direction indicator incorrect colour (4.4.3 (a)) | 1 |
| Hazard warning lamps inoperative (4.4.1 (e)) | 1 |
| Oil leaking excessively from engine oil continuous dripping onto exhaust (8.4.1 (a) (i)) | 1 |
| Emissions not tested no tested due to oil leak onto exhaust (8.2.1.2 (d)) | 1 |
| Nearside Front Anti-roll bar pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Front Lower Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced (6.1.1 (c) (i)) | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds manufacturers specified limits (8.2.1.2 (a)) | 1 |
| Offside Front Road wheel fixing missing (5.2.1 (a) (i)) | 1 |
| Nearside Front Lower Suspension arm ball joint excessively worn lower king pin joint (5.3.4 (a) (i)) | 1 |
| Offside Front Lower Suspension arm ball joint excessively worn king pin joint (5.3.4 (a) (i)) | 1 |
| Brake hose excessively deteriorated | 1 |
| Offside Rear Brake hose leaking on an air braking system (1.1.12 (c) (i)) | 1 |
| Offside Front Wheel bearing rough when rotated (5.1.3 (b) (i)) | 1 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 1 |
| Oil leaking excessively from engine (8.4.1 (a) (i)) | 1 |
| Parking (secondary brake) on a single line braking system imbalanced across an axle Axle 1 (1.3.1 (b) (i)) | 1 |
| Exhaust carbon monoxide content at idle exceeds manufacturers specified limits (8.2.1.2 (b)) | 1 |
| Offside Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Front Hazard warning switch inoperative (4.4.2 (a) (ii)) | 1 |
| Rear Exhaust has a major leak of exhaust gases back box (6.1.2 (a)) | 1 |
| Offside Front Drivers seat insecure (6.2.5 (a) (ii)) | 1 |
| Offside Front Wheel bearing has excessive play (5.1.3 (a) (i)) | 1 |
| Brake pedal has insufficient reserve travel (1.1.2 (a)) | 1 |
| Rear Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Nearside Front Suspension arm ball joint excessively worn play in king pins (5.3.4 (a) (i)) | 1 |
| Nearside Side repeater lens defective such that the emitted light is adversely affected (4.4.1 (b) (ii)) | 1 |
| Offside Front Suspension arm ball joint excessively worn play in king pins (5.3.4 (a) (i)) | 1 |
| Nearside Rear Shock absorbers has an excessively worn bush (5.3.2 (c)) | 1 |
| Emissions unable to be completed due to exhaust leak (8.2.1.2 (d)) | 1 |
| Offside Exhaust has a major leak of exhaust gases flange to cylinder head (6.1.2 (a)) | 1 |
| Nearside Side repeater not working (4.4.1 (a) (ii)) | 1 |
| Nearside Rear Direction indicator not working (4.4.1 (a) (ii)) | 1 |